2008 Saturn Astra

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

The contact owns a 2008 Saturn Astra. The contact stated that while shifted to park(P), the vehicle occasionally started rolling forward or backwards. The contact engaged the parking brake. Additionally, the contact was unable to start the vehicle and had to jiggle the key to start it. The contact stated that the gear shift lever was shifted from park(P) to neutral(N) several times before the vehicle started. The contact stated that the failure was intermittent. The contact stated that recently the check engine and low tire pressure warning lights were illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic to be diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was 61,830.

NHTSA ID

11731553

Incident

Mar 27, 2026

Mileage

61,830 mi

THE CONTACT ALSO STATED THAT THE VEHICLE WOULD NOT SHIFT OUT OF REVERSE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SHIFT BUSHING FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE

NHTSA ID

11649379

Incident

Mar 20, 2018

Lost power steering without any warning it got very stiff i could not steer the car it got electric power steering pump not mechanical. i want online and this vehicle is made by GM / Opel . many people having the same issue .and parts are discontinuned and only available as used or you can get it shipped from Europe.

NHTSA ID

11648523

Incident

Mar 16, 2025

My right headlight, kept going out. I couldnt get a sticker because the mechanic stated the headlight kept burning. He reground the right headlight so it could get energy from the battery. Currently, everything in the diagnostic of the car says low beam.

NHTSA ID

11473109

Incident

Apr 22, 2022

I can't get in gear. Sometimes I can put it gear but after I have stopped and put it in park, it will not go into any gear so I get stuck. I am a senior and bought this second hand. It only has 47,000 miles on it. It appears it doesn't always go into park properly. This shift problem has been recalled on other cars of this make and model and I need it repaired as soon as possible. It happens all the time and I am afraid to drive it anywhere.

NHTSA ID

11468414

Incident

Jun 4, 2022

The car suffers from improper gear shifter issues. The gear shifter will not move into park properly, and has multiple times made the car slide after we leave the car. Car will not start unless gear is moved to Neutral many times. Looks like this is a similar problem to the one on Saturn Aura that has recalls on it for the same issue. Why is the Astra not covered under the recall?..,,

NHTSA ID

11435169

Incident

Sep 24, 2021

I have received the recall and the dealership said they ordered the part and told me it was safe to drive till the part came in as they have ordered it. So then i had them put it in writing that it is safe to drive.I am asking why are they letting me drive this vehicle with this dangerous recall.

NHTSA ID

11417614

Incident

May 18, 2021

I BOUGHT THIS 2008 SATURN ASTRA XR USED IN 2014 FROM A CAR DEALERSHIP. WITHIN A FEW WEEKS I BEGAN HAVING PROBLEMS STARTING THE CAR. AND IT STALLED WHILE DRIVING. I TOOK IT TO MANY REPAIR SHOPS FOR DIAGNOSTICS AND REPAIRS BUT AFTER SPENDING HUNDREDS AND THEN THOUSANDS OF DOLLARS REPLACING VARIOUS PARTS AND COMPONENTS IT STILL CONTINUED HAVING THE SAME EXACT PROBLEMS THAT ALL THE GENIUS MECHANICS COULDN'T FIGURE OUT THE CAUSE. I SUSPECT THAT THE CAR DEALERSHIP SOLD ME A TRADE-IN CAR THAT WAS INVOLVED IN A WATER FLOOD DAMAGE SITUATION AND ALL OR MOST OF THE HIDDEN WIRING AND ELECTRICAL COMPONENTS WERE PROBABLY CORRODED AND RUSTED. BUT NONE OF THE GENIUS MECHANICS WHO WORKED ON MY CAR EVEN SUSPECTED THAT ALL THE PROBLEMS WITH MY CAR COULD'VE BEEN CAUSED BY WATER FLOOD DAMAGE. THEY JUST KEPT REPLACING MANY OLD PARTS WITH NEW PARTS AND CHARGING ME LOTS OF MONEY. PLEASE HELP ME FIND OUT OR FIGURE OUT IF MY CAR WAS INVOLVED IN A WATER FLOOD DAMAGE SITUATION THAT IS STILL CAUSING THESE STARTING PROBLEMS. IT TAKES ME 15 MINUTES TO OVER AN HOUR TO START THIS CAR EACH TIME FOR ALL THESE YEARS SINCE I BOUGHT IT USED IN 2014. TODAY IS FRIDAY 3-19-2021, THANK YOU

NHTSA ID

11403807

Incident

Aug 3, 2014

Mileage

75,000 mi

New Vehicle Monitoring Programs Section in IVH

This Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. Technician may find Diagnostic Trouble Codes B3055, B3060, B3935, C0750, C0755, C0760, C0765, and/or C0775.

This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.