2013 Scion Xb

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

The contact owns a 2013 Toyota Scion XB. The contact stated while her daughter was driving or idling, the driver noticed an abnormal knocking sound coming from the engine. The vehicle was taken to the dealer, where it was diagnosed that the engine had failed and needed to be replaced. The manufacturer was notified of the failure but no assistance was provided. The vehicle was parked at the residence. The failure mileage was approximately 41,500.

NHTSA ID

11741808

Incident

May 17, 2026

Mileage

41,500 mi

The contact owns a 2013 Scion XB. The contact stated while the vehicle was stationary, the contact stated that the engine was consuming an excessive amount of engine oil. The check engine warning light was illuminated. The vehicle was not taken to be diagnosed. The vehicle was then taken to a dealer where it was diagnosed with engine oil consumption failure. The vehicle was not repaired because the vehicle was not under recall or warranty. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 120,000.

NHTSA ID

11641161

Incident

Dec 20, 2020

Mileage

120,000 mi

This is a known issue with the 2013 Scion xB and several other models that use the same 2.4L 2AZ-FE engine. A number of Scion owners have reported excessive oil consumption, where the vehicle burns off or consumes engine oil faster than it should. This causes low oil levels which may lead to serious engine damage if not addressed in time. The problem is most noticeable on vehicles with high mileage or older models, as oil consumption can increase over time. In some cases, the excessive oil consumption could be a result of an oil leak, but more commonly, it's due to an engine problem. Possible reasons could include worn piston rings, faulty PCV (Positive Crankcase Ventilation) valve, damaged valve seals or oil sludge build-up. The excess oil is burnt off during combustion, leading to low oil levels. Scion (and Toyota, Scion’s parent company) has acknowledged the problem and extended the warranty on some models to cover the repair of the oil consumption problem. The repairs generally involve the replacement of the pistons and piston rings. But due to my vehicle being over the mileage limit Toyota refuses to fix it

NHTSA ID

11559534

Incident

Jan 10, 2020

Car is using a quarter of oil additional every 3000 miles

NHTSA ID

11524217

Incident

May 21, 2022

On April 22, 2022 the car burst into flames while parked in a supermarket parking lot at 1000 US Route 1, Edison, New Jersey. Fortunately I was not in it at the time but the car was a total loss. There were no warnings ahead of time.

NHTSA ID

11478134

Incident

Apr 22, 2022

Hi, Air bag light started intermittently flashing in January. Toyota could not diagnose until it was on all the time. Charged me $89.95. Air bag light stays on all the time 04-25-21. Take it to Toyota and diagnose intermittent open in driver side front door harness in circuit to left front door air bag sensor. $272.88. Want an additional $739.78 to replace harness. This is same problem that has been recalled on Toyota Venza and Avalon to the best of my knowledge. Harness is too short and rubs on door frame, causing open circuit. I believe this is an overall Toyota/Scion problem.

NHTSA ID

11418123

Incident

Jan 1, 2021

DRIVERS DOOR AIR BAG HARNESS HAS AN OPEN CODE. PART # 82152-12L23. SAME PROBLEM THST TOYOTA HAS WITH RECALLED VENZA. TOYOTA WANTS OVER $1,000 TO FIX. AIR BAG LIGHT ON ALL OF THE TIME.

NHTSA ID

11415634

Incident

Jan 17, 2021

Mileage

175,000 mi

THIS IS NOT A COMPLAINT!! I JUST WANTED TO INFORM YOU THAT THE RECALL NOTICE FOR THIS SCION AND VIN DOESN'T APPLY TO THIS MODEL. CAN THIS RECALL (18E091) NOTICE BE TAKEN OFF PLEASE?

NHTSA ID

11397707

Incident

Feb 18, 2021

DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied during the vehicle manufacturing process, may experience paint peeling on exterior metal body panels. Although the original factory paint is covered by Toyota?s New Vehicle Limited Warranty for 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to the condition described above. The following information is provided to inform you and your staff of the program notification schedule and your degree of involvement.

DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied during the vehicle manufacturing process, may experience paint peeling on exterior metal body panels. Although the original factory paint is covered by Toyota?s New Vehicle Limited Warranty for 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to the condition described above. The following information is provided to inform you and your staff of the program notification schedule and your degree of involvement

DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied during the vehicle manufacturing process, may experience paint peeling on exterior metal body panels. Although the original factory paint is covered by Toyota?s New Vehicle Limited Warranty for 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to the condition described above. The following information is provided to inform you and your staff of the program notification schedule and your degree of involvement.

CSP: Takata CSP Coverage Job Aid - published 7.28.2022

CSP: On July 30, 2018, a settlement of claims for Economic Loss related to Takata airbag inflators was approved for full implementation. The settlement includes Toyota?s agreement to provide a Customer Support Program (?CSP?) for 2002-2019 model year (MY) vehicles originally equipped with certain Takata airbag inflators or repaired under a recall with Takata airbag inflators to provide coverage for repairs of the airbag inflator contained in the airbag module. This CSP letter is to help clarify how to administer this coverage in accordance with the settlement. This is NOT a recall or a campaign, but is provided to reassure owners that Toyota stands behind the reliability of our vehicles.

DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied during the vehicle manufacturing process, may experience paint peeling on exterior metal body panels. Although the original factory paint is covered by Toyota?s New Vehicle Limited Warranty for 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to the condition described above. The following information is provided to inform you and your staff of the program notification schedule and your degree of involvement