2024 Toyota Tundra Engine Problems

My vehicle has had rough idle, and at times it hesitates where I've come very close to being struck by another vehicle.

NHTSA ID

11776597

Incident

Oct 23, 2026

at low speed the ADCC. FWRD Collison sensor was triggered and the brakes applied which cause the engine and engine powertrain along with the brakes to lose power and did not function as it was designed. The system was to slow and not enough power in engine to compensate for the TSS to activate and lost control temporary, and the object it was trying to avoid the collision with was a parked vehicle. My engines OIL PRESSURE gage at a low speed will at times go past 3/4- 4/4 (80-95%) and normal operation is 1/2 (50%) . I was driving on highway 90 headed east to work at 730am and while in the fast lane my truck SPLUTTERD and lost power and engine light and dash reading said POWER LOSE and my speed dropped to 55 estimate and would not throttle up. for a few seconds the brakes and engine sounded as it was shutting down and I was able to mange the truck to the slower lanes and made it to work at slow speed. The truck when sits for day at a time and when I decide to use it and start it up the truck SPLUTTERS and shakes for a brief moment until warms up. I have a huge gas efficiency problem and MPG use to read in the mid to high 20 now it reads mid 10 to 18 area. the truck is not meeting its efficiency as stated when purchased. the car hesitates and splutters if the throttle is used and the delay boggles the truck engine performance which can lead to loss of steering. The dealership says it was the airflow sensor yet they never changed it or replaced it and i now know that sense mile 6 of purchase the engine has been failing and Toyota refuses to fix or correct the engine issue or give false or misleading details and information and will not correct issues. TBE claim details and facts and images are ignored and denied by TBE. I can submit images of the dash and speed. As well as the Oil pressure gages which are obvious signs of the engine recall issues.

NHTSA ID

11776376

Incident

Jul 7, 2026

See attached document for complaint.

NHTSA ID

11776238

Incident

Jul 31, 2026

While driving on highway i lost power creating a dangerous situation 4 different lights came on including engine light traction control and warning about emergency brake

NHTSA ID

11776084

Incident

Nov 1, 2026

Metal accumulating in oil at increasing rate Multiple recorded stall events IN TRAFFIC -- where I was almost hit by crossing traffic when breaking an intersection I have cases with Toyota open but no one will do anything until the engine totally fails -- this is a 2024 HYBRID -- not covered by the recall Heavilly documented and confirmed by the dealer and Toyota but no one will do anything to remedy the issue.

NHTSA ID

11774839

Incident

Feb 2, 2026

There is a bad throttle lag. Sometimes when you pull out onto the road it lags so bad that you can’t build speed quick enough for merging into traffic.

NHTSA ID

11773511

Incident

Oct 16, 2026

The contact owns a 2024 Toyota Tundra. The contact stated that there was an issue while towing a boat. The contact received notification of NHTSA Campaign Number: 25V767000 (Engine and Engine Cooling). The vehicle was taken to the dealer, but no fault codes were retrieved. The manufacturer was contacted and opened a case. The approximate failure mileage was 26,000.

NHTSA ID

11772900

Incident

Sep 4, 2026

Mileage

26,000 mi

The contact owns a 2024 Toyota Tundra. The contact stated that while driving at 64 MPH, the vehicle stalled, resulting in a loss of power, power braking, and power steering. After three attempts, the vehicle restarted, and the contact drove to the residence safely. The contact associated the failure with NHTSA Campaign Number: 25V767000 (Engine and Engine Cooling). The dealer was notified of the failure. The manufacturer was notified of the failure. The failure mileage was approximately 41,490.

NHTSA ID

11772355

Incident

Aug 25, 2026

Mileage

41,490 mi

I am the original owner of a 2024 Toyota Tundra Limited Nightshade equipped with the 3.4L twin-turbo V6 engine, purchased brand-new from Kerry Toyota in Florence, Kentucky, in July 2024. The vehicle is titled and registered in Indiana. At approximately 33,000 miles, my truck experienced an unexpected engine shutdown while driving highway speeds. I brought it to an authorized Toyota dealership- Kerry Toyota, Florence Kentucky for inspection, but was informed that no issues were found after they had the truck for weeks. Now, at approximately 41,000 miles, my truck has experienced another engine shutdown while traveling approximately 50 mph. After sitting for about 10 minutes, the engine restarted slowly and began making a knocking noise. The truck is currently at a Toyota dealership- Kerry Toyota awaiting inspection. I am extremely concerned about the safety of this vehicle, particularly because I previously reported a similar shutdown and the underlying issue was not identified or resolved.

NHTSA ID

11771896

Incident

Oct 15, 2026

Since about 5,000 miles I reported abnormal tire wear, alignment, harsh or delayed shifting, and braking problems to the dealer. Repair orders from January 2024 to December 2025 show about 7 dealer visits: rear brake work three times including a rear pad replacement around 22,000 miles and an earlier rotor replacement, two drivetrain/shifting visits (first was could not duplicate) plus recall 24TA02, a check engine light diagnosis, and moisture corrosion in the reverse lamps that disabled the backup lamps and camera. The dealer denied the reverse lamp repair as commercial use and I paid 957.37 in January 2025; Toyota later issued recall 25TA06 for the same water intrusion. My truck is also covered by engine stall recall 25TA14 (NHTSA 26V320), but the dealer reported the remedy was not available in December 2025. Losing the backup camera and lamps and an engine that may stall are safety risks, especially when towing and reversing a boat trailer.

NHTSA ID

11770591

Incident

Dec 31, 2025

The contact owns a 2024 Toyota Tundra. The contact received notification of NHTSA Campaign Number: 25V767000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was contacted by phone and made aware of the failure.

NHTSA ID

11769823

Incident

Oct 8, 2026

While driving, engine seized. Truck only has 33,700 miles and has been maintained regularly.

NHTSA ID

11769809

Incident

Oct 5, 2026

The contact owns a 2024 Toyota Tundra. The contact received notification of NHTSA Campaign Numbers: 26V320000 (Engine and Engine Cooling) and 25V322000 (Exterior Lighting); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 14,900.

NHTSA ID

11768387

Incident

Oct 1, 2026

Mileage

14,900 mi

The contact owns a 2024 Toyota Tundra. The contact received notification of NHTSA Campaign Number: 26V320000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that while driving or accelerating from a complete stop, the vehicle hesitated for 5–6 seconds before accelerating as intended, with a ticking sound coming from the engine. Additionally, the contact saw puddles of oil on the garage floor, and there was an abnormal burning oil odor coming from the vehicle. Several dealers and the manufacturer were notified of the failure by phone; however, a diagnostic test was denied, and the contact was advised to wait until parts for the recall repair were available to repair the vehicle. The failure mileage was approximately 9,000.

NHTSA ID

11768019

Incident

Nov 30, 2024

Mileage

9,000 mi

On Saturday, XXX, while driving on [XXX] toward [XXX], our 2024 Toyota Tundra (VIN: [XXX]) lost power and stalled at highway speeds with the warning: "Ignition On / Engine Off – Stop in a safe place." I made an emergency lane change with 6 vehicles trailing closely. After smoke expelled during restart attempts, Toyota Roadside towed the truck to Goldsboro Toyota at 5:15 PM. On Monday,XXX, Goldsboro Toyota exhibited negligent, misleading treatment. A receptionist falsely claimed they "ordered a new engine" for the recall and refused to release the truck to Midlands Toyota near our home in [XXX]. Despite written instructions on the intake form, we waited 7 hours with no update. On Friday, XXX, Toyota Corporate contradicted the dealer, confirming no technical remedy or engine currently exists for active federal Safety Recall 25TA14 (NHTSA [XXX]). This catastrophic engine failure created an extreme safety hazard that severely triggered my wife’s diagnosed ADHD and depression (Eggshell Plaintiff Doctrine). The dealer’s refusal to release our truck also disrupted my work during a critical corporate shareholder transition. Under the federal Magnuson-Moss Warranty Act and state breach of warranty laws, we demand a Full Manufacturer Repurchase (Buyback): 1. Full payoff of our remaining loan balance to our lender. 2. Complete refund of all out-of-pocket payments: down payment, all $824 monthly payments, sales taxes, and county fees. 3. Full reimbursement for direct expenses and tax penalties. 4. Non-economic cash settlement for severe hardship, safety risks, and aggravated emotional distress. 5. 100% coverage of all statutory attorney’s fees as required by law. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11767581

Incident

Sep 19, 2026

When I was driving the engine failed . I have a 2024 hybrid, they are fixing the engine and parts but my frustration is 2024 gas tundra had a recall on the engine and they got a whole new engine with extra warranty , and I'm the first hybrid to have engine fail and since they haven't put a recall out I only get 1 year warranty and they are just replacing the parts not the whole engine . I'm concerned it can happen again past the one year warranty . They need to put out a recall on the hybrids too

NHTSA ID

11766568

Incident

Sep 6, 2026

On XXX6, while driving on the highway at approximately 89 mph and 36,714 miles, the engine misfired and the vehicle began shaking. The check engine light started flashing and a "reduced power, visit dealer" message appeared, along with a loss of motive power. The vehicle was taken to an authorized dealer on XXX at 37,032 miles. The dealer's repair order documents stored diagnostic trouble codes for random misfires, and states that freeze frame data confirmed misfires on cylinders 3, 4 and 5 at 89 mph and 2700 rpm in direct injection mode. Despite this, the repair order was closed as "no issue found." No repair and no further diagnosis was performed. The dealer stated the condition could not be duplicated after driving the vehicle and idling it for about an hour. The vehicle is subject to an open safety recall for machining debris in the engine (NHTSA 25V767, manufacturer 25TB14), for which no remedy is available. The recall summary lists engine knocking, rough running, no-start and loss of motive power as symptoms, and instructs owners experiencing symptoms to contact their dealer. When contacted, the dealer stated the manufacturer is still developing a remedy and that the vehicle can either wait indefinitely or be picked up as is. The defect remains undiagnosed and unrepaired. The vehicle is available for inspection. The safety concern is a sudden loss of motive power at highway speed, which is the same risk identified in the manufacturer's own recall filing. No remedy has been made available more than ten months after the recall was filed. Video of the failure as it occurred, showing the check engine light flashing and the loss of power: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11764487

Incident

Jun 20, 2026

The contact owns a 2024 Toyota Tundra. The contact received notifications for NHTSA Campaign Numbers: 25V322000 (Exterior Lighting) and 25V767000 (Engine and Engine Cooling); however, the parts to perform the recall repairs were unavailable. The contact stated that while driving 60 MPH, the vehicle shuddered and vibrated abnormally and lost motive power, with the check engine warning light illuminated. The contact restarted the vehicle and drove to the dealer for diagnosis; however, the dealer was unable to determine the cause of the failure. The contact stated that the torque converter, transmission, and rear differential were previously replaced to stop the shuddering and vibration while accelerating; however, the failure persisted. The contact stated that the manufacturer failed to repair the vehicle within a reasonable amount of time. The manufacturer was notified of the failure. The failure mileage was 20,000.

NHTSA ID

11764374

Incident

Jun 18, 2025

Mileage

20,000 mi

The contact owns a 2024 Toyota Tundra. The contact stated that while driving approximately 40-45 MPH, the radio started blinking, and the vehicle lost power and stopped in the middle of the road. The contact was able to restart the vehicle; however, there was a burning odor, and white smoke was coming from the HVAC system and the engine compartment. The contact turned off and exited the vehicle and the smoking stopped. The contact called the local Police to assist with directing traffic while waiting for towing assistance. The vehicle was towed to the dealer. The dealer attempted to return the vehicle to the contact after 3 weeks without confirmation of the diagnostic results or any repairs. The contact stated that the vehicle had been taken to the dealer before the failure had occurred to be repaired under NHTSA Campaign Numbers: 25V767000 (Engine and Engine Cooling), 25V322000 (Exterior Lighting), 26V038000 (Back Over Prevention); however, the dealer failed to complete the recall repair because there was not enough mechanics to perform the repairs. The manufacturer was informed of the issue. The failure mileage was approximately 26,000.

NHTSA ID

11763995

Incident

Aug 21, 2026

Mileage

26,000 mi

Engine stalls or hesitates when taking off from a stop. When taking off from a stop the Truck will hesitate after the accelerator is pushed and not move forward. This hesitation causes me to push the accelerator more trying to get the Truck to move. When the truck does move it then lunges forward I assume because I continue to push the accelerator more trying to get the Truck to move. The engine in this Truck is also being recalled in Non Hybrid Models because they are seizing up. This is the exact same engine in the Hybrid and should be under the same recall for the engine seize defect.

NHTSA ID

11763533

Incident

Sep 5, 2026

* 2024 Toyota Tundra Limited non hybrid TRD Off Road with 43k miles with catastrophic engine failure with no warning. Started as a very slight ticking sound while doing about 60 mph level to slightly downhill. * I could only hear it with very light throttle input (between 2 and 5%). Past 5% and at 0 pedal there was nothing. This went on for about 1 minute then it started to get significantly louder and more noticeable with throttle input and while starting to go uphill. * Shortly after it started catastrophically knocking with dash saying loss of power and oil pressure. * I get it stopped and it immediately shut down on its own. Due to very little warning I was forced to pull over on a right curve of a highway potentially putting my family and as well as passing traffic in danger. * Engine leaking oil. Couldn’t find anything obvious where the oil was coming from. After doing some research it seems like the front and main crank seals started leaking. More noticeable on the rear seal. This was a dangerous situation because oil was leaking on the hot exhaust and could have cased a fire on the side of a highway. * The Toyota dealer has possession of the vehicle for repairs. They have not stated if it is possible to be available for inspection. * The dealer has inspected the vehicle and is in the process of ordering a replacement engine.

NHTSA ID

11763527

Incident

Sep 5, 2026

I am writing to formally express my concern regarding my 2024 Toyota Tundra, VIN [XXX], and the engine recall involving certain 2024 Tundra vehicles. I am very concerned about the possibility of engine damage or failure related to machining debris and the potential for loss of power while driving. This is a major safety concern, especially considering the vehicle is relatively new. I would like Toyota to confirm whether my VIN is included in the recall and provide a clear explanation of the required repair or inspection process. If my truck is affected, I am requesting that the recall repair be completed as soon as possible at no cost to me. I would also like confirmation regarding whether Toyota will provide a loaner or rental vehicle if my truck must remain at the dealership for an extended period, particularly if an engine replacement is required. Please document this complaint and provide me with a written response explaining the next steps and expected resolution. Thank you, [XXX] Vehicle: 2024 Toyota Tundra VIN: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11762603

Incident

Feb 2, 2026

The contact owns a 2024 Toyota Tundra. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the engine compartment. No warning lights were illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the short block engine needed to be replaced. The vehicle was repaired. The contact researched and became aware of an unknown recall; however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 20,000.

NHTSA ID

11761247

Incident

May 3, 2026

Mileage

20,000 mi

Total engine failure in v35a at 65- 70 mph which dealer has confirmed was due to main bearing failure. Inability to accelerate vehicle in heavy traffic lead to extreme unsafe situation. No warning lamps came on until after the vehicle completed stopped running. Both the manufacturer and the NHTSA are well aware of the continued problems with these engines and the unsafe failure. The only warning ‘hybrid system malfunction “( which has nothing to do with dealer performed diagnostic of metal in oil pan failed main bearing) came on after the truck was inoperable.

NHTSA ID

11760816

Incident

Aug 24, 2026

engine knocks on start up or is very rough. the truck only has 8200 miles on it. i’m waiting for the recall to be processed but it’s been 2 years and i’m still waiting. i want to sell the truck because im afraid of it breaking down when i need it. but no one wants to buy the truck based on issues with the engines Toyota put in the trucks. how long do i have to wait for a new engine with the same design flaw? why is this issue taking so long to be rectified.How long do i have to wait for the back up light s issue to be resolved also? that’s also been 2 years! who’s sleeping at the wheel here to put pressure on Toyota?

NHTSA ID

11759511

Incident

Aug 25, 2026