2024 Toyota Tundra Fuel system Problems

2 issues to report: 1. Truck has a pull to the right since new. Found the front strut springs installed wrong. Attached photos show 2024 tundras on the dealer (pink dot on drivers side, yellow dot on passenger side) lot vs. mine (pink dot on passengers side, yellow dot on drivers side). Dealer corrected. Following repairs, pull is much better, but still present. Over 20 alignments completed; 3 by toyota and 3 by 3rd party. Problem continues. I believe it is a manufacturing defect in the safety equipment, suspension, or bent frame. 2. Toyota recalled V35A engines through my manufactured date. Because mine is a hybrid, it was excluded. Crankshaft main bearings seize due to a defect. I am forced to drive a vehicle on public roads while toyota recognizes the issue.

NHTSA ID

11739152

Incident

Aug 15, 2023

It has been occurring ever since I purchased the truck in October 2023. I finally thought I should say something. Usually, the truck is at a complete stop. The truck can be warm or cold. As I press the accelerator down to move in the forward direction, there is a hesitation. No immediate acceleration. It lasts for at least one second before the acceleration begins. This can create a serious safety issue when there is cross traffic. Putting myself and passengers in possible danger of a collision. This occurs almost every time I drive the vehicle. When I had my truck in for a recall on 4/19/26, I asked a Toyota service manager if this is a common problem. He told me it is very common in the 2024 Toyota Tundra, with a V6 twin turbo. This leads me to believe that the Toyota Corporation is aware of the problem. As per the service manager, Toyota has not done anything about this issue and there isn’t a repair for it.

NHTSA ID

11732263

Incident

Oct 23, 2023

The brakes squeal when reversing and sometimes when you’re driving forward coming to a stop. It has done this since the day I picked it up at the dealership. The dealership says there’s no remedy for it yet. The next thing is the front fog lights also draw moisture just like the rear reverse lights. Dealership says there’s no remedy for it or fix for it. I’ve had to have the radiator replaced twice in this vehicle and it only has 44,000 miles on it. The dealership says it’s a factory defect. Not sure if that’s true or not. It was not covered under warranty so I had to spend $200 to use my extended warranty. I do not think that is right it should’ve been covered under the manufacturers warning, especially if it was a manufacturer defect. The last but most important thing is the lag when you give it gas. This happens from a complete stop or also like if you’re trying to accelerate to get on the highway you can press it nice and slow and it won’t takeoff or you can mash on it all the way to the floor and it still takes a few seconds and then kind of vibrates and pops like it’s trying to skip gears before it takes off and goes. Dealership also says there’s nothing wrong with it. I believe it is a factory defect or some kind of wiring problem. The reason why I think it is a computer or wiring issue is that if you put the vehicle in sport mode, it will not do it coming from a complete stop. It does do it when you’re getting on the highway even in sport mode. I am on a few Facebook forums and I see this problem where people report this problem all the time and ask how to fix it. I would like information on how to get Toyota to buy my vehicle back. These trucks have had so many issues with engine recalls, engine replacement, and other issues that are an actual safety concern and I do not feel like it is a safe vehicle to be traveling with my family. Thanks, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11720082

Incident

Feb 23, 2026

The engine repair was a short block only, even thoe the main bearings spun and sent debis threw the engine. #1 rod went as well. Apon recieving the truck back, with in 200 miles, I've had the same hesitation with the engines as I had just before the first engine failed. Took it by the dealer and no issues found. oil preasure stays up and temp normal. I've had many issue with throtle lag sence day one. The milage has stayed in the low 11 gpm when before i would get on average 14 to 16. Dealer stated toyota would make it right if the engine fails again. Very unhappy with Toyota as I feel they are just kicking the can down the road.

NHTSA ID

11716527

Incident

Feb 2, 2026

When starting from a very slight rolling stop I sometimes get no throttle response at all. When this happens i end up applying more throttle and I still do not move. Then after a second or two the truck takes off like a rocket. This usually happens at an intersection with the steering wheel turned one way or the other. Not sure if this is an engine or transmission issue or both.

NHTSA ID

11711671

Incident

Dec 9, 2025

Purchased new in 2024. since ownership, Ive experienced throttle lag. Especially from the stopped position. I have also experienced occasional stalling for no apparent reason. Dealership has noted issues I have mentioned. vehicle now has 32000 miles and issues continue .Delaership has been unable to remedy either situation

NHTSA ID

11711632

Incident

Aug 5, 2025

Acceleration pause or lag dead spot from slow like yielding at yield sign or from stop. Not always from stop but consistent from slow rolling from situations like yield sign or merging to traffic. I have encountered several situations where I was afraid I would be hit by another vehicle but lucky enough to make it or the other driver slowed or break. Then when it does go there is a huge jerk like it kicked in and I punched the accelerator. This occurs frequently.

NHTSA ID

11711349

Incident

May 15, 2024

Throttle hesitation when leaving from a stop. Completely random and occurs maybe a few times a month.

NHTSA ID

11705392

Incident

Dec 13, 2025

Throttle hesitation and loss of power when transitioning from stop to start risking accident when pulling into traffic. Problem occurs all the time.

NHTSA ID

11705051

Incident

May 1, 2025

Vehicle hesitates to accelerate from stop or slow roll when pedal is engaged. This hesitation nearly caused a collision when attempting a left-hand turn in heavy traffic. Problem can be reproduced easily and is exacerbated when on an incline. It has not been confirmed by dealer or service center. Occurs regardless of whether auto start/stop feature is enabled or not. Putting transmission in "S" mode and manually down shifting to first gear appears to prevent the issue. After the hesitation, when the vehicle begins to accelerate, it performs a "hard" acceleration, like the pedal was slammed to the floor, even though consistent pressure was maintained on the the pedal. Problem has existed since purchasing the vehicle new in Dec. 2023.

NHTSA ID

11702796

Incident

Dec 1, 2025

The vehicle experiences throttle lag/hesitation when going from a stop. At stop lights or when at a complete stop when you apply gas there is a good amount of hesitation before the engine moves. I found this is dangerous because the warmer the vehicle is the more I expirience it. Very concerning when trying to move out of traffic, when making left and right turns at intersections. There has not been an accident yet but it is a ticking time bomb.

NHTSA ID

11702742

Incident

Dec 31, 2023

On Wednesday 10/21 at approximately 11:30pm I was traveling on the Clearview Expressway. While changing from the middle last to the left lane at 20mph due to a construction merge with some traffic. When trying to accelerate the truck lost all throttle power and my speed quickly dropped to 12mph before throttle response came back. No noticeable or harsh change of gear for this episode.

NHTSA ID

11696530

Incident

Oct 22, 2025

On Tuesday 10/21 at approximately 4:30pm I was on the Grand Central Parkway traveling about 50mph. When trying to accelerate the truck lost all throttle power and I quickly lost speed down to 40mph before throttle response came back. There was a noticeable change in gear upon throttle resuming.

NHTSA ID

11696529

Incident

Oct 21, 2025

On Saturday 10/18 I was traveling about 60mph on the Long Island Expressway at approximately 12:30pm when I went to accelerate to pass a vehicle. Immediately upon pressing the accelerator the truck lost all throttle power and I quickly lost speed down to 45mph before throttle response came back. The truck harshly went into gear once throttle power resumed.

NHTSA ID

11696525

Incident

Oct 18, 2025

Brakes - When descending down a hill at speed the brakes on my truck pulsate as if the rotors are warped. My family was put at risk due to the brakes not functioning properly and causing me to let off the braking system in order to prevent overheating. I asked my dealer to review the brakes and they indicated nothing is wrong, I can reproduce this action anytime for the dealership with a simple ride up and down the mountain. This could result in a crash harming myself, my family, or other motorists. The problem began between 5k-10k miles and is getting worse. My truck currently has 16k miles. The brakes should last 40k-60k miles with no problem. Engine/fuel system - Since new, my truck has never met the window sticker EPA ratings listed. 22-23 models being recalled due to engine failure leads me to believe my engine is not performing at peak performance, thus, affecting fuel economy. I am afraid my model (built in 2023) is slowly experiencing the same main bearing failure as the 22-23 models suffered, having catastrophic results and was recalled to have a full engine replacement. My engine failing while driving could result in a crash harming myself, my family, or other motorists. I prefer not to wait for my engine to fail, given the fact that 22-23 models have all been recalled due to this manufacturing defect. Some, if not all 2024 models should also be recalled out of abundance of precaution.

NHTSA ID

11696010

Incident

Feb 5, 2025

I am writing to formally document a series of serious safety incidents and ongoing concerns regarding my 2024 Toyota Tundra, which I believe reflect a critical design flaw and a failure by Toyota to act in accordance with its obligations to customer safety and product reliability. In August 2025, while driving on the interstate with my minor child in the vehicle, I experienced a sudden and unexpected engine malfunction. The failure required me to swerve off the road at high speed, nearly resulting in a serious collision. This incident placed both my life and my child's life in immediate danger. The vehicle was towed via Toyota’s SOS service to Green’s Toyota of Lexington, KY. Upon evaluation, I was informed by Service Manager Justin that the issue was consistent with the engine failures that led to a recall of the 2022 and 2023 Toyota Tundra models. However, because my 2024 model has not yet been included in the recall—despite sharing the same apparent defect—I was told that Toyota would rebuild the engine rather than replace it. I expressed strong concerns regarding the safety and long-term reliability of a rebuilt engine in a new vehicle. I was reassured that a rebuilt engine would be “just as good,” despite clear evidence to the contrary based on subsequent events. As a result of this dangerous failure and Toyota’s inadequate response, I submitted a formal buyback request to Toyota Customer Care, citing serious and ongoing safety concerns. The dealership nevertheless indicated I would likely be denied a buyback, which I found deeply troubling given the known defect and the high-risk circumstances involved. During the initial repair, I visited the dealership to retrieve personal belongings and observed the vehicle in a completely dismantled state. The cab had been removed, and the engine was fully disassembled with parts scattered on the ground. This unprofessional and chaotic environment caused further loss of confidence in the repair quality and safety of th

NHTSA ID

11694535

Incident

Aug 23, 2025

Fuel gauge won’t reset after filling the tank or it will stay on full after using the entire tank of gas. Running out of fuel on the freeway is a major safety issue!

NHTSA ID

11688627

Incident

Sep 17, 2025

Ran out of fuel on highway due to erroneous fuel guage. Truck when parked on an incline will show a full tank after starting even though gas tank is 3/4 full. Problem has been reported to Dealer and no follow up nor resolution has been offered. this event is dangerous and troublesome,

NHTSA ID

11679526

Incident

May 2, 2025

The contact owned a 2024 Toyota Tundra. The contact stated while the vehicle was parked in front the detached garage, the vehicle caught on fire and the incident was caught on the neighbor's camera at 4:31 AM. The neighbor then informed the contact of the incident. The contact noticed that the vehicle had caught on fire and the fire was mainly coming out of the gas pillar area. The contact stated that the entire vehicle had burned to the ground. The fire was extinguished by the fire department. A fire department report was filed. No police report was filed. There was no injury sustained. The vehicle remained at the scene and was in the process of being totaled by the insurance company. The dealer was notified of the failure and provided vehicle rental assistance. The manufacturer was notified of the failure and informed the contact that it would take up to 30 days for a field investigator to inspect the vehicle. Additionally, the contact was informed that it could take up to 45-60 days to determine whether there was liability. The failure mileage was approximately 13,900.

NHTSA ID

11673883

Incident

Jul 10, 2025

Mileage

13,900 mi

2024 Toyota Tundra is parked on an semi-inclined driveway. The fuel gauge and miles to empty resets back to full and the miles to empty at the max around 420 miles back to empty. Reported this incident when the mileage was around 300 to the dealership and nothing was done. A year forward I am still having this fuel gauge and miles reset issue. This is a safety hazard primarily due to the risk of unexpectedly running out of fuel. While the inaccurate reading itself doesn't directly damage the engine, running out of gas can lead to several problems. It's important to address a malfunctioning fuel gauge promptly.

NHTSA ID

11672823

Incident

Jun 15, 2024

I am experiencing a recurring issue with my 2024 Toyota Tundra’s fuel gauge. Specifically, when the vehicle is parked on an incline, the fuel gauge resets to indicate a full tank, regardless of the actual fuel level. For instance, after parking on a hill with approximately half a tank, the gauge displayed full upon restarting the vehicle.

NHTSA ID

11660326

Incident

May 5, 2025

Intermittent hesitation issues. Most of the time, happens when accelerating from a stop, but sometimes will happen when trying to accelerate when going to an on-ramp, for example. Hard to tell if transmission, or fuel related problem.

NHTSA ID

11660136

Incident

Feb 1, 2025

Acceleration hesitation every time I push the accelerator

NHTSA ID

11660090

Incident

May 9, 2025

Anytime I come to a yield/traffic circle and do not have to come to a complete stop, when I push the accelerator there is a hesitation and then the truck lurches forward. It happens quite often when I slow down to 5mph give or take before accelerating again. I would estimate it has happened 50 times since I have owned the truck which I bought with 300 miles on it.

NHTSA ID

11660081

Incident

May 4, 2025

Gas gauge randomly reset to full tank after parking, despite being less than half full. Without me noticing, this could have caused risk of running out of fuel due to erroneous computer information about the fuel level.

NHTSA ID

11655862

Incident

Feb 5, 2025