2013 Volkswagen Jetta Sportwagen

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626

I had lost power driving over the grapevine on Highway and then recently I had difficulty putting vehicle in gear and it would make a loud noise. Independent service center confirmed that the TCM was faulty.

NHTSA ID

11673116

Incident

Jul 3, 2025

My Bosch CP4 fuel pump failed causing my engine to stall while turning at a very busy/fast intersection. This can occur at speed without any warning of sudden failure, putting everyone on the road at risk. Fault code P0087 and P0191 were present, along with a flashing glow plug. Following EA No.: EA11-003 I removed the fuel metering valve and observed and documented metal shavings. The failed component is still installed on my vehicle as I will be having it serviced shortly. The fact that this same component has been recalled very recently in many domestic trucks, but not in the 600,000 VW/Audi vehicles it is installed in is concerning. EA No.: EA11-003 Date Opened: 7-Feb-2011 Date Closed: 27-Mar-2015 The date this analysis was closed was months before the Dieselgate Scandal broke, leads me to question its credibility. This repair is very expensive as a whole new fuel system needs to be installed, with the same questionable pump.

NHTSA ID

11640739

Incident

Jan 17, 2025

The contact owns a 2013 Volkswagen Jetta Sportwagen. The contact stated that while driving 70 MPH, the vehicle turned off and restarted independently while the vehicle was still in motion, resulting in a momentary loss of control over the vehicle. The contact also stated that the battery was being drained quickly. The vehicle returned to normal functionality, but the failure became a regular failure. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who determined an electrical short was causing the battery to drain and other electrical issues. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 85,000.

NHTSA ID

11615469

Incident

Sep 6, 2023

Mileage

85,000 mi

It seems that my vehicle's clock spring has broken. There is already a warranty issue with this part. However, my local service center cannot get my vehicle in for 5 weeks. How is it acceptable for me to drive a vehicle for 5 weeks without a working airbag and horn?

NHTSA ID

11615445

Incident

Sep 17, 2024

The rear right passenger airbag sensor went faulty, was hoping Volkswagen could replace it since it is a safety system.

NHTSA ID

11580702

Incident

Jan 3, 2024

The contact owns a 2013 Volkswagen Jetta. The contact stated while driving approximately 70 MPH, the vehicle started losing motive power with the check engine warning light illuminated. The contact depressed the accelerator pedal and the vehicle failed to respond as needed. The contact continued driving to his destination however, the vehicle failed to accelerate above 30 MPH. The contact stated that the failure was intermittent but had become a recurring failure. The contact had taken the vehicle to a local dealer where a diagnostic test was performed; however, the results had not been shared with the contact. The vehicle was not repaired. The manufacturer was not informed of the failure. The contact researched online and became aware of a failure of the high-pressure fuel pump. The contact related the failure to the high-pressure fuel pump. The failure mileage was approximately 120,000.

NHTSA ID

11561116

Incident

Nov 27, 2023

Mileage

120,000 mi

Walked out to the garage where the vehicle had been shut off for a number of minutes to conduct another day’s personal investigation (can’t leave it outside when it rains unfortunately - moonroof leaks). This time: exterior lights on & found the interior lights in what looked to be an odd cycling. Video can be provided, no pictures taken. The price for honesty? Dealers: $500. I can live with that, someone should at some point, do the right thing by others & disclose its problems. The car is a LEMON & by all other standards-has no reason to be. I’m done filing reports, 3 in 30 days & I’m done driving the vehicle after 101 days of personal research. Behind the wheel of this VIN which additionally is covered till 2028 & has also failed previously (Nov ‘22 clock spring) is too much of a safety concern; & the cost to repair exceeds the worth of the car. Value in a sense is relative, and I don’t have much to say about that subject. Additional findings and details can be provided. Also, toxins & emissions are a concern.

NHTSA ID

11555385

Incident

Nov 16, 2023

The Service Act/Recall for the glow plug was NOT reported to Experian by Volkswagen when it was repaired on 12-11-2014 AND it was incorrectly installed by the VW Dealership in Tulsa who serviced it. It was not disclosed to me and we paid over $1400 this year for an "incorrect" glow-plug, same exact part number. Please update the NHTSA ID # 11553299 to include the Glow Plug. The vehicle is now showing the previously recalled codes for the VW Recalls pertaining to 23U3 and 24CV and 4 more codes since we last spoke. We were sold the vehicle without being disclosed the recall repair on our Experian report. Further, the vehicle is getting worse each day. The vehicle is a lemon & VW will not address the safety of it. They do NOT care about the lives of those who are their customers, something needs to change.

NHTSA ID

11554262

Incident

Mar 1, 2023

This is a notice for software changes with the ODIS diagnostic program to correct the communication during vehicle programming function: A software fix is needed to correct the issue: DA 0019 - Hotfix 12-V battery test(s) – No battery diagnosis - Inconclusive test result.

Oil Consumption Measurement and Electronic Oil Consumption Measurement

Instruction, how to lubicate engine before initial start.

Lubricating engine components before reassembly.

Inquiries

Volkswagen Engine Oil Standards