2003 Volkswagen Jetta Heating & air conditioning Problems

BACK IN 2007 RECALL FOR HEATED SEATS IN VOLKSWAGEN'S. ISSUED RECALL FIXED BOTH DRIVERS AND PASSENGERS SEATS AS NEW ONES WERE ORDERED AND SHIPPED IN FROM OVERSEAS, DUE TO BOTH CATCHING FIRE AND BURNING HOLES IN SEATS ONE SEAT BEING THE DRIVERS BURNT A HOLE IN MY JEANS AND BURNED MYSELF. AS OF 3/5/12 DRIVERS SIDE SEAT IS GETTING SO HOT IT HAS BURNT THE MATERIAL ON THE SEAT AGAIN AS IT STARTED SMOKING. QUICKLY TURNED IT OFF. PROBLEM THOUGHT WAS FIXED AS RECALL IN 2007, NOT FIXED APPARENTLY.

NHTSA ID

10450962

Incident

Mar 5, 2012

Mileage

112,000 mi

I AM THE OWNER OF A 2003 VW JETTA. I WAS RECENTLY BURNED(11/2010) BY THE SEAT HEATER WHILE DRIVING AND THE CAR SEAT SMELLED LIKE IT WAS GOING TO START ON FIRE. MY CAR HAD A RECALL NOT LONG AFTER I BOUGHT IT FOR THE SEAT HEATERS. IT IS OBVIOUSLY A MALFUNCTION IN THE SEAT HEATER THAT VW HAS HAD NUMEROUS PROBLEMS WITH BASED ON THE RECALL AND THE PLETHORA OF COMPLAINTS ON THE INTERNET. I CAN NO LONGER USE THE HEATING UNIT. I TOOK IT TO PATRICK MOTORS IN AUBURN, MA WHERE I BOUGHT THE CAR. THEY SAID IT WAS OUT OF WARRANTY AND THEY WOULD CHARGE ME TO LOOK AT IT TO SEE WHAT THE PROBLEM WAS AND THEN MAYBE ASK VWOA IF THEY WOULD HELP. I WAS NOT WILLING TO PAY MORE MONEY FOR SOMETHING THAT IS OBVIOUSLY A MANUFACTURING PROBLEM AND HAS BEEN DOCUMENTED AS PROBLEMATIC. *TR

NHTSA ID

10369355

Incident

Nov 5, 2010

Mileage

110,000 mi

I USE MY HEATED SEATS ALMOST DAILY IN THE WINTER MONTHS. I USED IT THIS MORNING FOR ABOUT 20 MINUTES AS I DROVE FROM HOME TO THE GYM, THEN ANOTHER 10 MINUTES AS I DROVE FROM THE GYM TO THE STORE. WHEN I GOT INTO MY CAR AFTER THE STORE, IT WAS STILL ON THE SAME SETTING (5), I HAD DRIVEN ABOUT 50 YARDS IN THE PARKING LOT, WHEN I FELT A SHARP PAIN IN MY LEFT UPPER LEG/BUTT. I MOVED SLIGHTLY, THEN BEGAN TO SMELL SMOKE. I FELT AROUND WITH MY HAND AND FELT THE "HOT" WIRE AND THE HOLE IN MY SEAT. IT TOOK ME A MOMENT TO REALIZE WHAT IT WAS, AND THEN I IMMEDIATELY TURNED DOWN THE HEATED SEAT TO OFF, THEREBY PREVENTING FURTHER DAMAGE AND PAIN. LUCKILY THERE WAS LIMITED DAMAGE TO MY CLOTHING AND I WAS NOT SERIOUSLY INJURED, BUT HAD I BEEN DRIVING ON THE HIGHWAY, OR NOT BEEN ABLE TO FIGURE OUT WHAT WAS CAUSING THE PAIN SO QUICKLY, THERE COULD HAVE BEEN MORE SEVERE CONSEQUENCES INCLUDING INJURY. *TR

NHTSA ID

10247476

Incident

Nov 2, 2008

Mileage

61,000 mi

I HAVE A 2003 VW JETTA GLI VR-6. THE AIR CONDITIONER STOPPED WORKING AFTER IT WAS NICE AND COLD FOR ABOUT 5 MINUTES. HOT AIR WAS BLOWING OUT OF THE VENTS. ENGINE (COOLANT) LIGHT CAME ON AFTER ABOUT A 10 MINUTE DRIVE. THE ENGINE (COOLANT) GAUGE WAS ALMOST IN THE RED 260 DEGREES. I SWITCHED OFF THE AIR, AND THE GAUGE WENT DOWN A LITTLE, BUT DIDN'T REALLY COOL OFF. THE GUY AT THE DEALERSHIP EXPLAINED IF THE ENGINE STARTS OVERHEATING, THE FAIL SAFE FOR THE CAR IS TO AUTOMATICALLY TURN THE A/C OFF IN ORDER TO SAVE ITSELF FROM OVERHEATING TO THE POINT WHERE DAMAGE WOULD OCCUR. AFTER ALL DAY DIAGNOSTICS, THE DEALERSHIP SAYS THE FUSE BOX IS MELTED DUE TO AN ELECTRICAL PROBLEM. THIS, CONVENIENTLY, IS NOT COVERED BY MY GOLD PLUS EXTENDED WARRANTY THAT I SPENT LOTS OF MONEY ON. REPAIRS SO FAR WILL COST ~$800. THEY HAVE TO FIX THAT BEFORE THEY CAN TEST TO SEE IF THE ALTERNATOR IS DAMAGED. BOTH THE DEALERSHIP AND THE WARRANTY REP SAY THIS IS A VERY COMMON PROBLEM WITH VOLKSWAGEN CARS. IF IT IS COMMON IT SHOULD BE RECALLED!! *TR

NHTSA ID

10232221

Incident

Jun 23, 2008

Mileage

56,000 mi

THE HEATED SEATS IM MY 2003 VW JETTA STARTED TO CATCH ON FIRE. *TR

NHTSA ID

10222735

Incident

Mar 28, 2008

Mileage

55,000 mi

DRIVERS SIDE HEAT SEATER FAILED ABOUT 2 MONTHS AGO. IT GOT HOTTER THAN NORMAL WHEN ON SETTING #3, I TURNED IT OFF, AND FROM THAT POINT ON IT DIDN'T WORK. TWO DAYS AGO, I HAD THE DRIVERS SIDE SEAT HEATER REPLACED AT THE KAISERSLAUTERN, GERMANY VW DEALERSHIP. WHILE DRIVING HOME FROM WORK, THE SEAT BECAME EXTREMELY HOT WHILE ONLY ON SETTING #2. IT WAS SO HOT, THAT I SMELLED SOMETHING BURNING, AND COULD NOT SIT DOWN WHILE DRIVING BECAUSE OF THE EXTREME PAIN TO MY BUTTOCKS. I REACHED DOWN WITH MY HAND TO CONFIRM THE HEAT AND ALSO BURNED MY HAND. NOTE THAT I WAS ONLY RUNNING THE SEAT HEATER ON LEVEL 2 OF 5 FOR APPROXIMATELY 5 MINUTES. UPON INSPECTION OF THE SEAT, THERE IS NOW A HARDENED PLASTIC FEELING AREA WHERE THE LEATHER ON THE SEAT WAS THE HOTTEST. HAD I NOT IMMEDIATELY TURNED OFF THE HEATER, IT IS VERY LIKELY THAT THE ENTIRE SEAT WOULD HAVE CAUGHT ON FLAMES. ADDITIONALLY, SINCE THIS OCCURRED WHILE DRIVING AND I WAS UNABLE TO PROPERLY SIT IN THE SEAT, AN ACCIDENT COULD MOST CERTAINLY HAVE OCCURRED ON THE SPOT. I IMMEDIATELY SPOKE WITH THE DEALERSHIP AND THEY SAID THEY WILL REPLACE THE HEATER BUT NOT THE SEAT. THEY SAY THE DAMAGE TO THE SEAT IS NOT EXTREME ENOUGH TO REPLACE THE ENTIRE THING. HOWEVER, I FEEL IT IS THEIR OBLIGATION TO REPLACE IT BECAUSE THE DAMAGE WAS CAUSED BY THEIR INSTALLATION OF A FACTORY ITEM THAT HAS ALREADY FAILED ONCE. *TR

NHTSA ID

10219168

Incident

Feb 26, 2008

Mileage

54,500 mi

HAD THE DRIVER'S SIDE HEAT SEATER ON. FELT A SHOCKING SENSATION AND SMELLED SMOKE. PULLED OVER, TURNED OFF HEAT SEATER AND EXITED CAR. THERE IS A HOLE BURNED IN THE SEAT AND IT TOOK OVER 5 MINUTES FOR IT TO STOP SMOKING. *TR

NHTSA ID

10218843

Incident

Feb 22, 2008

1. 2003 JETTA WAGON PASSENGER HEATED SEAT GOT EXTREMLY HOT AND THEN QUIT WORKING. *TR

NHTSA ID

10209232

Incident

Nov 5, 2007

Mileage

66,375 mi

TL*THE CONTACT OWNS A 2003 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THERE WAS A RECALL ON THE HEATING SWITCH FOR THE SEATS IN HER DAUGHTER'S VEHICLE. THE FAILURE WAS REPLACED WITH A NEW SWITCH, BUT THE SWITCH FAILED A FEW MONTHS LATER. THE SWITCH BURNED THROUGH THE LEATHER SEAT AND WOULD NOT SHUT OFF. THE FAILURE OCCURRED WHILE DRIVING 55 MPH. THE CONTACT'S DAUGHTER SUSTAINED BLISTERS, A SCAR, AND MINOR BURNS. A POLICE REPORT WAS FILED. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 60,000 AND FAILURE MILEAGE WAS 50,000.

NHTSA ID

10198982

Incident

Dec 27, 2005

Mileage

50,000 mi

DRIVER'S ELECTRIC SEAT HEATER ELEMENT IN 2003 JETTA CAUGHT FIRE BURNING HOLE IN LEATHER SEAT AND BURNING DRIVER. *JB

NHTSA ID

10184183

Incident

Feb 14, 2007

Mileage

71,000 mi

TL*- THE CONTACT STATED THAT THE 2003 VOLKSWAGEN JETTA STATION WAGON, CAUGHT ON FIRE. THE CONTACT STATED THAT WHILE DRIVING 20-25 MPH THE DRIVER'S SIDE SEAT CAUGHT ON FIRE WHILE THE SEAT HEATER WAS OPERATING. THE SEAT SUSTAINED A HOLE THE DIAMETER OF A PENCIL. THE SEAT BURNED PASSENGER BUTTOCKS, BUT DIDN'T CATCH HIS CLOTHING ON FIRE. *AK

NHTSA ID

10180969

Incident

Jan 29, 2007

Mileage

78,499 mi

SINCE I HAVE HAD MY JETTA THE SEAT WARMERS HAVE BEEN HOT. I CONTACTED THE DEALERSHIP WHO ADVISED THAT IS HOW THEY WORK. SINCE THEN MY SEAT WARMER HAS BURNED A HOLE IN THE CLOTH SEAT AND HAS BURNED ME. IT ALSO CREATES SPARKS WHEN TURNED ON. *JB

NHTSA ID

10177767

Incident

Oct 6, 2006

Mileage

60,000 mi

DRIVER TURNED ON THE SEAT HEATER ON A COLD EVENING AFTER STARTING THE CAR. THE DRIVER-SIDE SEAT HEATER BEGINS TO OVERHEAT AND SMOKE WITH THREE MINUTES. THE DRIVER ALMOST HIT A PARKED CAR WHILE ATTEMPTING TO AVOID BEING BURNED BY THE SEAT. THE DRIVERS NO LONGER USE THE SEAT HEATER ON THE DRIVER SIDE, AT A LOSS OF $300. *NM

NHTSA ID

10175610

Incident

Nov 23, 2006

Mileage

49,200 mi

WHILE DRIVING DRIVER SMELLED AND COULD SEE SMOKE AND REALIZED DRIVERS SEAT WAS ON FIRE. DRIVER MANAGED TO PULL OVER AND PUT OUT FIRE ON SEAT. VOLKSWAGEN OF AMERICA DID NOTHING - TOLD OWNER THEY HAD NOTHING TO SAY. DEALER REPLACED SEAT. *JB

NHTSA ID

10156887

Incident

Jan 8, 2006

Mileage

59,000 mi

THE HEATED SEAT ON THE DRIVER SIDE OF MY 2003 VOLKSWAGEN JETTA 4DR SEDAN BURNED A HOLE THROUGH THE SEAT AND THROUGH MY WIFE'S JACKET. *NM

NHTSA ID

10150655

Incident

Feb 18, 2006

Mileage

35,281 mi

DT*: THE CONTACT STATED THE SEAT WARMER OVERHEATED AND STARTED SMOKING. ALTHOUGH A SMALL HOLE FORMED IN THE SEAT CUSHION THERE WAS NOT VISIBLE EVIDENCE OF A FIRE OTHER THAN SMOKE. *AK

NHTSA ID

10146885

Incident

Dec 1, 2005

Mileage

52,000 mi

I HAVE HAD THIS CAR SINCE 10/31/02. I PURCHASED IT NEW. I BOUGHT IT FOR MY TEENAGERS TO DRIVE AS THEY BEGIN SINCE IT IS A SAFE CAR. LAST WEEKEND, (12/17/05) I WAS PERSONALLY DRIVING THE CAR, AND THE SEAT WARMER ON THE DRIVER'S SIDE GOT SO HOT THAT IT ACTUALLY BURNED A HOLE IN THE SEAT, AND THE CAR SMELLED TERRIBLE FOR SEVERAL DAYS AFTER. I THINK THAT HAVING TO FEAR AN ELECTRICAL FIRE IN MY CAR IS OUTRAGEOUS. *NM

NHTSA ID

10146161

Incident

Dec 17, 2005

Mileage

63,590 mi

I OWN A 2003 VW JETTA 1.8T WITH FRONT HEATED SEATS. DRIVERS SIDE SEAT CAUGHT FIRE DUE TO A SHORT IN THE SEATS HEATER 2 DAYS AGO ON 12/13/2005 AFTER THE HEATER WAS ON FOR LESS THAN 2 MINUTES. BURNING A SMALL HOLE TROUGH THE SEAT TO THE BOTTOM AREA OF MY LEFT SIDE (BUTTOCK) I HAVE COME TO FIND SINCE THIS HAPPENED, MY NHTSA HAS BEEN INVESTIGATING 2002, 2003 VW JETTAS FOR SEAT FIRES WITH THIS EXACT PROBLEM FOR OVER A YEAR NOW. WHY, AS THE ORIGINAL REGISTER OWNER OF THIS MODEL WAS I NOT INFORMED OF THIS INVESTIGATION AND THE POSSIBILITY OF A FIRE INSIDE MY CAR, WHILE ME, MY WIFE AND MY 5 YEAR GIRL ARE IN IT! THE PROBLEM WITH THE ABOVE IS THAT IT WAS NOT A POSSIBILITY, IT JUST WAS A MATTER OF TIME AND IN MY CASE, THE TIME WAS DECEMBER 13TH AT APPROXIMATELY 7PM AT NIGHT. THIS CAR HAS BEEN A PROBLEM SINCE THE FIRST 3,000 MILES, WITH WATER PUMPS AND DOOR LATCHES, FIRMWARE UPDATES, VIOLENT SHAKING OF THE VEHICLE IN COLD WEATHER STARTS, ELECTRICAL PROBLEMS RANGING FROM ENTIRELY IMMOBILIZING AND STRANDING ME TO THE CAR PARTIALLY BEING IMMOBILIZED THE VW JETTA TO AUTOMATIC TRANSMISSION SHIFTER ISSUES WHICH INCLUDE THE CARS SHIFTER BEING ABLE TO BE MOVED WHEN THE KEY IS NOT EVEN IN THE IGNITION TO A POSITION IN THE SHIFTER SELECTOR BECAUSE A CABLE WAS NEVER CONNECTED TO PREVENT THAT, THAT SHOULD ALSO BE A NHTSA SAFETY ISSUE TOO ON THIS CAR. BUT FIRST I WANT YOU FOR THE LOVE OF GOD CONTACT THE OWNERS OF THESE CARS BEFORE REAL TRAGEDY HAPPENS IF THAT ALL READY HAS NOT HAPPENED. I HAVE JUST TALKED VOLKSWAGEN CUSTOMER CARE ADVOCATE AT VW AMERICA, THEY HAVE NOT WARNED THEIR CUSTOMERS OF THIS, WHO WILL. AGAIN SINCE THIS HAS HAPPENED I SEE MANY PEOPLE ON THE INTERNET HAVE EXPERIENCED THE SAME THING. PLEASE NOTIFY THE OWNERS FIRST, THEN CONTACT ME SECOND. PLEASE! *NM

NHTSA ID

10145275

Incident

Dec 13, 2005

Mileage

36,150 mi

THE SEAT ON MY 2003 VW JETTA CAUGHT FIRE TODAY. AS A RESULT, THERE IS A NICKEL-SIZE BURN IN MY SEAT AND MY PANTS. *JB

NHTSA ID

10142597

Incident

Nov 14, 2005

AT APPROXIMATELY 5:15 AM THIS MORNING I STARTED MY CAR AND TURNED ON THE DRIVER'S SIDE HEATED SEAT. AFTER WAITING APPROXIMATELY 2 MINUTES FOR THE RPMS TO DROP BELOW 1000, I PLACED THE VEHICLE IN DRIVE AND BEGAN HEADING FOR WORK. I IMMEDIATELY SMELLED SOMETHING BURNING. I TRAVELED LESS THAN AN 1/8 OF A MILE TO A STOP SIGN. AFTER STOPPING THE VEHICLE AND PLACING IT IN PARK, I OPENED THE DRIVER'S SIDE DOOR, PULLED THE HOOD LATCH, AND QUICKLY STEPPED OUT OF THE VEHICLE. I LEFT THE CAR RUNNING AND THE DRIVER'S SIDE DOOR OPEN WHILE I OPENED THE HOOD TO INSPECT FOR THE SOURCE OF THE BURNING SMELL. AFTER APPROXIMATELY 2 MINUTES OF INSPECTION I DETERMINED THAT THERE WAS NOTHING BURNING IN THE ENGINE COMPARTMENT. I CLOSED THE HOOD AND WHILE STANDING AT THE FRONT OF THE VEHICLE I NOTICED SMOKE COMING FROM THE DRIVER'S SEAT. I IMMEDIATELY RAN TO THE DRIVER'S SIDE DOOR AND DISCOVERED A SMALL FIRE IN THE FRONT SEAT. I TURNED THE VEHICLE OFF, TURNED THE DRIVER'S SIDE HEATED SEAT OFF, AND MANAGED TO EXTINGUISH THE FIRE. THIS HAS BEEN A VERY TRAUMATIC EVENT. REFLECTING ON THE TYPICAL USAGE OF THE HEATED SEATS BY MYSELF, OR WORSE YET MY WIFE, THE OUTCOME COULD HAVE BEEN CATASTROPHIC. THE SEAT WAS LITERALLY ON FIRE IN LESS THAN FIVE MINUTES. I CAN NOT IMAGINE WHAT THE OUTCOME MIGHT HAVE BEEN IF THIS HAD OCCURRED DURING RUSH HOUR TRAFFIC. IF I HAD NOT EXITED THE VEHICLE TO INSPECT THE ENGINE COMPARTMENT, I WOULD HAVE SUFFERED BURNS. AFTER TALKING TO CUSTOMER SERVICE I WAS INFORMED THAT THERE WAS A RECALL ON THE SEATS. I HAVE HAD MY VEHICLE SERVICED AT THE VOLKSWAGEN DEALER THAT I PURCHASE THE VEHICLE FROM SINCE DAY ONE AND THEY NEVER DID ANY RECALL WORK ON THE SEATS. I SEARCHED YOUR SIGHT FOR RECALL INFORMATION ON MY VEHICLE AND THERE WAS NO DATA. I WANTED YOU TO BE INFORMED. I WOULD HATE TO FIND OUT THAT SOMEONE WAS BURNED IN THERE VEHICLE DURING NORMAL OPERATION. *JB

NHTSA ID

10142471

Incident

Nov 11, 2005

Mileage

38,000 mi

I OWN A 2003 JETTA TDI WAGON AND MY FRONT SEAT HEATER HAS BURNED THROUGH THE SEAT. *NM

NHTSA ID

10140645

Incident

Oct 17, 2005

ON EARLY MORNING START-UP, THE SEAT HEATER WAS TURNED ON. WITHIN ABOUT 1 MINUTE IT BEGAN TO SMOLDER, MELTING THE SEAT FOAM CUSHION AND BURNING A HOLE IN THE UPHOLSTERY FABRIC AND MY TROUSERS. HAD I NOT QUICKLY TURNED OFF THE HEATER, IT MAY HAVE STARTED A FIRE. I CONTACTED VW OF AMERICA. THEY TOOK MY INFORMATION AND REPAIRED IT AT THEIR EXPENSE THROUGH MY LOCAL VW DEALERSHIP. *JB

NHTSA ID

10118351

Incident

Jan 23, 2005

Mileage

80,500 mi

WHILE DRIVING/PARKING DRIVER'S SEAT HEATER BURNED A HOLE IN THE SEAT WHEN IN USE. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

NHTSA ID

10117522

Incident

Apr 4, 2005

Mileage

40,000 mi

ON MARCH 24,I TURNED MY SEAT WARMER TO LEVEL 2,ALL OF A SUDDEN I FELT A BURNING SENSATION. I KEPT DRIVING THINKING MAYBE I WAS BIT BY A BUG OR SOMETHING. ABOUT A MINUTE LATER,I SAW AND SMELLED ALOT OF SMOKE. I HAD TO PULL OVER AND WHEN I LOOKED DOWN AT MY SEAT,IT WAS DARK AND RAINY SO I TURNED ON MY DOME LIGHT,THERE WAS A DIME SIZE HOLE IN MY SEAT. I HAD TURNED OFF THE SEAT WARMER WHEN I REALIZED WHAT HAD HAPPENED. I GOT HOME AND THERE WAS A BURN ON THE BACK OF MY LEFT LEG. WE CONTACTED THE DEALERSHIP AND THEY FIXED OUR CAR IN ABOUT 10 DAYS. THERE HAD BEEN AN ELECTRICAL SHORT AND THEY REPLALCED THE SEAT AND FIXED THE ELECTRICAL.*AK

NHTSA ID

10116451

Incident

Mar 24, 2005

Mileage

26,850 mi

THIS MORNING, 4/5/05, I TURNED ON MY HEATED LEATHER SEATS IN MY 2003 JETTA GLS AND IN A MATTER OF ABOUT A MINUTE, I FELT SOMETHING EXTREMELY HOT ON MY LEG. I IMMEDIATELY LIFTED MYSELF UP FROM THE SEAT BUT IT WAS TOO LATE. I LOOKED DOWN AND THERE WAS A HOLE BURNT INTO MY LEATHER SEAT, SMOKE COMING FROM THE SEAT AND A BURN IN MY PANTS...NOT TO MENTION MY SKIN. WHAT I FIND DISTURBING IS NOT THAT IT HAPPENED BUT THE FACT THAT I TOOK MY CAR IN LAST THURSDAY AND WAS NOT TOLD ABOUT THE PROBLEM EVEN THOUGH A RECALL HAD ALREADY BEEN ISSUED. IF VW HAD BEEN PROACTIVE, I WOULD NOT HAVE HAD THIS INJURY AND PROPERTY DAMAGE.*AK

NHTSA ID

10116389

Incident

Apr 5, 2005

Mileage

46,000 mi