2000 Volvo V70XC

ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.

PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.

PULLING OUT OF PHYSICAL THERAPY PARKING LOT UNTO SOUTH PARK AVE. IN HAMBURG NY 14075, ENGINE STALLED IN MIDDLE LANE. BARELY MADE IT ACROSSTO CURBSIDE AND STALLED AGAIN, PATROL CAR CAME AND ASSISTED ME WITH HIS FLASHING LIGHTS. VEHICLE STILL NOT IN RUNNING CONDITION. TRIED NEW PARTSWITH OUT SUCCESS.GOING TO MECHANIC. *TR

NHTSA ID

10627278

Incident

Jul 15, 2014

Mileage

79,000 mi

TL* THE CONTACT OWNS 2000 VOLVO V70XC. THE CONTACT STATED THAT WHILE DRIVING 60 MPH THE VEHICLE LOST ACCELERATION WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE IDLE AIR CONTROL CIRCUIT NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 190,000.

NHTSA ID

10626038

Incident

Aug 1, 2014

Mileage

190,000 mi

TL* THE CONTACT OWNS A 2000 VOLVO V70XC. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE BEGAN TO DECELERATE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. A TROUBLE CODE WAS DETECTED PERTAINING TO THE ELECTRONIC THROTTLE MODULE. THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 06V441000 (VEHICLE SPEED CONTROL) WHICH WAS EXPIRED. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED BY THE DEALER. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 135,000. THE VIN WAS NOT AVAILABLE.

NHTSA ID

10544302

Incident

Sep 17, 2013

Mileage

135,000 mi

CAR INTERMITTENTLY LOSES POWER AND SOMETIMES ETS LIGHT COMES ON. USUSALLY IN THE MIDDLE OF TRAFFIC. *TR

NHTSA ID

10395126

Incident

Mar 31, 2011

Mileage

114,400 mi

CHECK ENGINE LIGHT IS ON SERVICE LIGHT IS ON THROTTLE POSITION SENSOR AND OXYGEN SENSOR DEFECTS, TROUBLESHOOTING CODES: P1171,P1132,P0141. *TR

NHTSA ID

10389992

Incident

Mar 13, 2011

Mileage

190,000 mi

CHECK ENGINE LIGHT IS ON SERVICE LIGHT IS ON THROTTLE POSITION SENSOR AND OXYGEN SENSOR DEFECTS, TROUBLESHOOTING CODES: P1171,P1132,P0141. *TR

NHTSA ID

10389991

Incident

Mar 13, 2011

Mileage

190,000 mi

MY 2000 VOLVO XC70 DEVELOPED A DANGEROUS ENGINE CONDITION THAT NEEDS TO BE REPORTED AND CORRECTED. THE DASHBOARD INDICATED A RED ETS LIGHT WHICH ACCORDING TO THE OWNERS MANUAL NEEDS TO BE DIAGNOSED BY A CERTIFIED VOLVO MECHANIC. I TOOK THE CAR TO AN INDEPENDENT VOLVO GARAGE WHO IDENTIFIED THE PROBLEM AS A THROTTLE BODY MALFUNCTION IN THE INTAKE OF THE ENGINE. THE GARAGE MADE A TEMPORARY ($300) REPAIR AND RECOMMENDED THAT I VISIT A VOLVO DEALER AND WARNED THAT AN APPROPRIATE REPAIR WOULD COST AS MUCH AS $1,000 INCLUDING PARTS AND LABOR. ACCORDING TO THE VARIOUS VOLVO FORUMS, THIS IS A COMMON AND COSTLY PROBLEM WITH THESE VOLVOS. THE SYMPTOMS INCLUDE HESITATION WHEN ACCELERATING, FLUCTUATING IDLE RPM AND OUTRIGHT STALLING. THIS IS A DANGEROUS CONDITION. I HAVE PARKED THE CAR UNTIL I CAN BE REASONABLY ASSURED THAT THIS CAN BE SUITABLY REPAIRED PREFERABLY AT VOLVO EXPENSE. *TR

NHTSA ID

10370853

Incident

Dec 13, 2010

Mileage

143,889 mi

WHILE DRIVING OUR 2000 VOLVO V70 XC, THE THROTTLE BEGAN ACTING STRANGE, REQUIRING US TO PRESS MUCH MORE THAN USUAL ON THE THROTTLE TO AVOID THE ENGINE CUTTING OUT, WHILE PULLING OUT INTO TRAFFIC. THE CAR WAS TAKEN TO THE DEALER, WHO DIAGNOSED A FAULTY ELECTRONIC THROTTLE MODULE, AND I WAS TOLD IT WOULD BE COVERED UNDER AN EXTENDED WARRANTY. THE PART WAS ORDERED, AND IN EARLY JANUARY 2010, I RETURNED TO THE DEALER FOR INSTALLATION. THE CAR HAS BEEN GETTING WORSE, AND WE HAVE COME VERY CLOSE TO HAVING AN ACCIDENT DUE TO THE FAULTY DESIGN. WHEN THE CAR WAS BROUGHT TO THE DEALER FOR THE WARRANTY REPAIR, THEY INFORMED ME THAT THE CAR WAS 'WARRANTY EXCLUDED', AND WOULD NOT BE COVERED, DUE TO THE STATUS OF THE TITLE. MY RESEARCH HAS INDICATED THAT THIS IS AN EXTREMELY COMMON PROBLEM, WHICH THERE WAS A RECALL TO RECALIBRATE THE THROTTLE, BUT NO RECALL TO ADDRESS THE ACTUAL FAILURE. THIS SEEMS ODD THAT VOLVO WOULD NOT HONOR THE SPIRIT OF THE RECALL. *TR

NHTSA ID

10318180

Incident

Dec 4, 2009

Mileage

153,129 mi

This is a Technical Journal: 12V Battery Testing Method

COMPLIMENTARY UPGRADE C00009 DESCRIPTION.

Rubber cushion

The Deutronic DBL-1200 is an advanced battery maintainer/charger with the flexibility to be updated as products and repair methods evolve.

ICUP/Google Built-In Diagnostic Operations

VIDA QR Scanner Mobile App