2010 Audi A3

By letter dated October 3, 2011, Volkswagen Group of America, Inc. (VW) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address a defect in approximately 168,275 model year (MY) 2009-2012 Volkswagen Jetta, Jetta Sportwagen, Golf, and Audi A3 vehicles equipped with the 2.0L TDI Common Rail Clean Diesel engine (NHTSA Recall No. 11V-490).The recalled Jetta and Jetta Sportwagen vehicles were built from May 2008 through September 2011, the Golf vehicles were built from May 2009 through September 2011, and the Audi A3 vehicles were built from September 2009 through September 2011.According to Volkswagen, in U.S. applications of the above cited TDI vehicles including engine codes CJAA and CBEA, the fuel injection pulses could coincide with the natural frequency of the injector line #2 in specific load and RPM conditions.This resonance creates additional stress on the fuel line which a small number of parts (based on the statistic spread of line strength) cannot withstand over its lifetime.As a contributing factor, VW indicated that a supplier used tube material with scratch marks from a grinding process during certain production periods.Lines manufactured in these periods were installed in vehicles produced in the following 10 months:December 2008, January-February 2009, October 2009, March-April 2010 and September-December 2010.Injector lines using this material exhibit a significantly higher failure rate.Dealers will replace injector line #2 in all vehicles built in these months.In addition, as a precautionary measure, all recalled vehicles will have vibration dampers installed on all four fuel injector lines.Analysis of NHTSA complaints, VW complaints, VW field reports and warranty claims found allegations of injector line leakage in 443 subject vehicles.The leaking line was not identified in 62 of the vehicles.For the 381 that did provide information about which injector lines were leaking and/or replaced, 358 (94%) involved an injector line #2 leak/repair.Almost three-quarters of the injector line #2 leak/repair incident vehicles were built in the 10 months identified by VW, which accounted for approximately one-quarter of the recalled vehicles.The failure rate for injector line #2 in vehicles built in the 10 months affected by the supplier line scratching issue is 6.0 incidents per thousand vehicles (IPTV).The failure rate for injector line #2 in other production months of recalled vehicles is 0.8 IPTV.The leak/repair rates for the other injector lines are all well under 1 IPTV.The action taken by Volkswagen is sufficient to resolve the issues raised by this investigation. The agency will continue to monitor this issue and reserves the right to take further action if warranted by the circumstances. Accordingly, this investigation is closed.

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

The Office of Defects Investigation (ODI) and Volkswagen (VW) have received a total of 160 complaints and field reports alleging incidents of engine stall and/or loss of power that appear to be related to high pressure fuel pump (HPFP) failures in certain model year (MY) 2009 through 2010 Volkswagen Jetta and MY 2010 Volkswagen Golf and Audi A3 vehicles equipped with TDI clean diesel engines.Approximately half of the reports indicate that the failure resulted in an engine stall incident, with many of these alleging stall incidents at highway speeds in traffic with no restart.There has been one minor crash alleged to have resulted from HPFP failure in the subject vehicles.In response to ODI's information request for PE10-034, VW indicated that it had found no defect related to motor vehicle safety with relation to the TDI Clean Diesel fuel system at issue in this investigation and attributed problems with HPFP failure to operation with gasoline contaminated diesel fuel.Volkswagen stated that even a small amount of gasoline in the diesel fuel may disrupt the necessary lubrication required and may cause the HPFP to fail.In response to concerns that fuel contamination was the major cause of HPFP and related fuel system failures, VW issued a Technical Service Bulletin in May 2010 (VW TB V011011 2023624 and Audi TB A011008 2023360-1), with instructions to inspect the diesel fuel for vehicles requiring fuel system service that have symptoms associated with HPFP failure.The bulletin states that fuel system damage incurred by use of fuel not complying to ASTM-D-975 Grade 2 S15 (B5 or less biodiesel content) standards will not be covered under warranty. Volkswagen also provided information about 121 mis-fueling incidents reportedly acknowledged by consumers or dealers and test results for about 50 diesel fuel samples taken from complaint vehicles in late-August through early-October 2010.The mis-fueling incidents include about 20 reports involving incorrect fueling by dealer sales or service personnel and generally report symptoms such as rough running, stalling and/or no start within a few miles of refueling the vehicle with gasoline.Volkswagen indicated that the testing of fuel samples from complaint vehicles found that nearly 90 percent contained high amounts of gasoline.Volkswagen implemented design changes for the HPFP in May 2008, September 2009 and November 2010 to improve the robustness of the pump when used with poor quality fuel.ODI analysis of HPFP failures identified from all sources shows failure rates of 0.53% for MY 2009 vehicles and 0.11% for MY 2010 vehicles.This investigation has been upgraded to an Engineering Analysis (EA11-003) to continue to investigate the issues with mis-fueling and HPFP design identified during the Preliminary Evaluation.

THE SUBJECT VEHICLES ARE EQUIPPED WITH DIRECT SHIFT GEARBOX (DSG) TRANSMISSIONS, WHICH FEATURE A 6-SPEED AUTOMATIC GEARBOX WITH TWO WET RUNNING CLUTCHES (DUAL CLUTCH) IN WHICH THE CLUTCH MECHANISM AND GEAR CHANGES ARE ELECTROHYDRAULICALLY OPERATED BY A MECHATRONIC CONTROL UNIT.THE DSG MECHATRONIC CONTROLLER INCLUDES EXTENSIVE SELF DIAGNOSTIC FUNCTIONS AND STRATEGIES TO ENSURE SAFE OPERATION AND PREVENT SYSTEM/COMPONENT DAMAGE IN THE EVENT OF COMPONENT FAILURES OR HARSH OPERATING CONDITIONS.THE BASIC HIERARCHY OF FAULT MODES INCLUDES SOME THAT ONLY RESULT IN THE STORAGE OF A DIAGNOSTIC TROUBLE CODE (DTC) AND CAUSE NO LOSS OF FUNCTION, SOME THAT STORE A DTC AND REDUCE VEHICLE OPERATION TO A LIMP HOME MODE, AND SOME THAT STORE A DTC AND CAUSE AN INTERRUPTION OF MOTIVE POWER (I.E., OPEN CLUTCH).THE DRIVER IS ALERTED TO THE LATTER TWO MODES BY THE DASH GEAR POSITION INDICATOR (PRNDS) FLASHING. ONE OF THE CONDITIONS THAT RESULTS IN INTERRUPTION OF MOTIVE POWER IS EXCESS GEARBOX TEMPERATURE.THE SYSTEM INITIALLY RESPONDS TO INCREASED GEARBOX TEMPERATURE BY RAMPING DOWN ENGINE TORQUE.IF THE TEMPERATURE KEEPS RISING THE MECHATRONIC UNIT RESPONDS BY OPENING THE CLUTCH.IN A DEFECT INFORMATION REPORT SUBMITTED TO NHTSA ON AUGUST 20, 2009, VOLKSWAGEN DESCRIBED A POTENTIAL DEFECT IN THE WIRING HARNESSES OF THE DSG GEARBOX TEMPERATURE SENSORS USED IN APPROXIMATELY 16,000 MODEL YEAR (MY) 2009 AND 2010 VOLKSWAGEN (EOS, JETTA AND GTI) AND AUDI (A3 AND TT/TT ROADSTER) VEHICLES EQUIPPED WITH DSG TRANSMISSIONS AND BUILT FROM SEPTEMBER 2008 THROUGH AUGUST 2009 (NHTSA RECALL NO. 09V-333, VOLKSWAGEN RECALL NO. 37E3/S7 AND AUDI RECALL NO 37E4/J7). VOLKSWAGEN PROVIDED THIS DESCRIPTION OF THE DEFECT, THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DSG MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED BY THE CONNECTOR SUPPLIER DURING A LIMITED PRODUCTION PERIOD.WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL.IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH.IN ADDITION, THE DEPRESS BRAKE PEDAL INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES.IN HEAVY TRAFFIC, THE ABRUPT SHIFT TO NEUTRAL COULD LEAD TO A CRASH WITHOUT WARNING.VOLKSWAGEN ESTIMATED THAT LESS THAN ONE PERCENT OF THE RECALLED VEHICLES MAY CONTAIN THE DEFECT CONDITION. ODI IDENTIFIED 40 COMPLAINTS THAT APPEAR TO BE RELATED TO THE TEMPERATURE SENSOR DEFECT CONDITION DESCRIBED BY VOLKSWAGEN.VOLKSWAGEN RECEIVED 139 COMPLAINTS RELATED TO THE CONDITION, WITH 7 INVOLVING VEHICLES REPORTED TO ODI, RESULTING A 172 TOTAL COMPLAINTS TO ODI AND VOLKSWAGEN.ALL OF THESE COMPLAINTS INVOLVE THE MY 2009 AN 2010 VEHICLES SUBJECT TO RECALL 09V-333. ODI ALSO IDENTIFIED COMPLAINTS OF HARSH/JERKY SHIFTING IN SOME VOLKSWAGEN VEHICLES WITH DSG.VOLKSWAGEN ATTRIBUTED THIS CONDITION, WHICH TYPICALLY OCCURS AT VERY LOW SPEEDS, TO EXCESSIVE WEAR IN THE BUSHINGS OF THE TWO SOLENOID VALVES IN THE MECHATRONIC UNIT THAT CONTROL CLUTCH OPERATION.VOLKSWAGEN DOES NOT BELIEVE THAT THE THIS CONDITION IS A SAFETY DEFECT BECAUSE THE CHANGES IN SHIFT QUALITY DEVELOP GRADUALLY OVER TIME, DO NOT CAUSE A LOSS OF MOTIVE POWER AND HAVE NOT RESULTED IN ANY FATALITIES, INJURIES OR SERIOUS CRASHES (THERE WERE THREE REPORTED PROPERTY DAMAGE INCIDENTS RESULTING IN MINOR BODY DAMAGE IN VERY LOW SPEED, PARKING MANEUVERS).VOLKSWAGEN ADDRESSED THIS PROBLEM IN THE FIELD WITH A CUSTOMER SERVICE PROGRAM THAT INCLUDES THE REPLACEMENT OF POTENTIALLY AFFECTED MECHATRONIC UNITS AS WELL

225/45zr1794w purchased at discount tire. TPMS system failed after tire installation. I told the technician and he reset the system. Five miles later TPMS indicator came on. Malfunction TPMS. I monitor the tire pressure periodically and the tires seemed fine. While driving on Florida 528 to the airport i heard a rumbling and pulled over immediately. The tire sidewall was cut almost all the way around the tire. I assume from low pressure or tire malfunction. The tire is only a few months old. I am going to visit discount tire today and see what they say/do. I commute 150 miles a day at highway speeds. Fortunately I was able to pull over and not damage my rim. I removed the tire and put the spare on. I was flying to Columbia south America and nearly missed my flight. I have not found any reason the tire lost air pressure. Because this tire was nearly new it should have held air. Had discount tire fully corrected the TPMS system i may have been able to save the tire and not experienced the horrid experience of changing the tire on the highway 70 mph speed limit however the actual speeds are from 80mph up. Fortunately i work for the Orlando international Airport and had a colleague park my car to avoid missing the flight. Had four road hugger ties on my Audi now 3 and a spare. I'm not sure what the outcome will be but a brand new tire should not have deflated an had discount tire performed as professional technicians i most likely would not be contacting your organization. Thank your [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ID

11509065

Incident

Feb 16, 2023

THE CAR SHUTS OFF WHEN DRIVING. ALL POWER STEERING, ELECTRICAL, POWER BRAKES, ENGINE...EVERYTHING. HAS SHUT OFF DRIVING ON FREEWAY GOING 70MPH

NHTSA ID

11372399

Incident

Jun 15, 2020

Mileage

100,000 mi

THIS 2010 AUDI A3 TDI EQUIPPED WITH AN S TRONIC DIRECT-SHIFT GEARBOX WILL RANDOMLY SHIFT INTO NEUTRAL OR LIMP MODE AND IT IS NOT POSSIBLE TO PROCEED WITH NORMAL VEHICLE OPERATION AFTER THIS OCCURS WITHOUT FIRST PLACING THE VEHICLE IN PARK, TURNING OFF THE IGNITION AND THEN RESTARTING THE VEHICLE. THESE SYMPTOMS ARE INDICATIVE OF A KNOWN DEFECT FOR THIS MODELS POWER TRAIN AND THERE ARE NUMEROUS TESTIMONIES ON THE WEB FROM AUDI AND VW OWNERS WHOSE 2009/2010 VEHICLES ARE EXHIBITING THE SAME SYMPTOMS, YET WHO ARE BEING TOLD THAT THE AUDI RECALL #'S 37E3/S7 & 37E5/J7 (NHTSA CAMPAIGN #09V333000) DO NOT APPLY TO THEIR VEHICLES DUE TO THEIR HAVING BEEN BUILT OUTSIDE THE BUILD DATE PARAMETERS OF THE RECALL. IT IS OBVIOUS FROM THE NUMEROUS COMPLAINTS FROM AUDI AND VW OWNERS THAT THE DEFECTIVE TRANSMISSION TEMPERATURE SENSOR HARNESSES WERE INSTALLED IN VEHICLES OUTSIDE OF THE RECALL PARAMETERS AND AUDI AND VW ARE NOT WILLING TO AUTHORIZE DEALERS TO REPROGRAM THE TRANSMISSION CONTROL MODULE OF THESE VEHICLES WITH UPDATED SOFTWARE TO CORRECT THE PROBLEM. I EVEN INQUIRED AS TO WHAT MY COST WOULD BE TO HAVE THIS UPDATED SOFTWARE INSTALLED (EVEN THOUGH IT IS PROVIDED FREE FOR AUDI AND VW VEHICLES WITHIN THE BUILD DATE PARAMETERS) BECAUSE IT IS A SAFETY ISSUE AND WAS TOLD THAT THE REPROGRAMMING DOES NOT APPLY TO MY VEHICLE, THOUGH IT EXHIBITS EXACTLY THE SYMPTOMS DESCRIBED IN THE RECALL.

NHTSA ID

11307861

Incident

Feb 6, 2020

RELATED TO RECALL 45F5 ABS CONTROL MODULE. THIS VEHICLE HAS A FAILED ABS CONTROL MODULE THAT DEACTIVATES ABS BRAKING SYSTEMS, ELECTRONIC STABILITY CONTROL, AND HEADLIGHT RANGE CONTROL. THIS SPECIFIC VIN IS NOT INCLUDED IN THE AFFECTED RANGE PER THE RECALL STATED ABOVE ALTHOUGH IT DEMONSTRATES THE SAME KNOWN SAFETY ISSUES.

NHTSA ID

11256473

Incident

Jan 1, 2017

Mileage

80,000 mi

I HAVE AN AUDI A3 MANUFACTURED IN 2009 PRESENTING SEVERE ISSUES WITH THE ABS CONTROL MODULE. AUDI HAS A RECALL FOR SEVERAL AUDI AND VW MODELS MANUFACTURED THE SAME YEAR, RECALL NUMBER 16V913000. AUDI OF AMERICA WAS NOTIFIED HOWEVER DECLINED RESPONSIBILITY ALLEGEDLY BECAUSE MY VEHICLE WAS NOT IN THE SPECIFIED VIN RANGE. ALTHOUGH MY VEHICLE IS PRESENTING THE SAME SYMPTOMS AS THOSE ON THE RECALL AUDI IS UNWILLING TO ACCEPT RESPONSIBILITY. THE EXPERIENCE WAS VERY UNNERVING AS THE CAR SUDDENLY STOPPED WHILE DRIVING AND SUDDENLY ACCELERATED. FORTUNATELY THE CARS FOLLOWING BEHIND WERE ABLE TO STOP ON TIME AVOIDING A SERIOUS ACCIDENT. ASIDE FROM LOSING CONTROL OF THE VEHICLE, THE STEERING LOSES POSITION AND THE SPEEDOMETER STOPS WORKING. FURTHERMORE THE PART NEEDED FOR THE REPAIR HAS BEEN SUPERSEDED, THIS IS VERY SUSPICIOUS AS TO WHY THERE WILL BE A NEW PART NUMBER TO REPLACE THE ORIGINAL IF ALLEGEDLY THERE'S NO PROBLEMS WITH MINE...?

NHTSA ID

11142215

Incident

Oct 10, 2018

Mileage

81,000 mi

TL* TAKATA RECALL. THE CONTACT OWNS A 2010 AUDI A3. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 16V383000 (AIR BAGS). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR AS THE RECALL NOTICE WAS RECEIVED OVER A YEAR AGO. THE DEALER (OURISMAN CHEVROLET OF ROCKVILLE, 807 ROCKVILLE PIKE, ROCKVILLE, MD 20852, (301) 637-6496) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS CONTACTED SEVERAL TIMES AND WAS UNABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT RECENTLY RECEIVED A POSTCARD FROM THE AUDI MANUFACTURER, ALERTING HER THAT THEY HAD THE PARTS. ONCE THE CONTACT ARRIVED AT OURISMAN CHEVROLET OF ROCKVILLE, SHE WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

11141431

Incident

Jan 30, 2018

TL* TAKATA RECALL. THE CONTACT OWNS A 2010 AUDI A3. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V079000 (AIR BAGS). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED (AUDI MARIN, 700 FRANCISCO BLVD W, SAN RAFAEL, CA 94901, 415-460-4100) AND WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS NOT CONTACTED. THE CONTACT STATED THAT THE WAIT TIME FOR THE PARTS WAS TOO LONG. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

11140418

Incident

Feb 10, 2016

TAKATA RECALL-THE DEALERSHIP HAS NOT HAD ANY REPLACEMENT FOR THE LAST YEAR AND A HALF, THAT WOULD REPLACE THE BAD AIRBAG.

NHTSA ID

11123847

Incident

Jun 12, 2017

This bulletin provides information when there is a film/visible rings on the clear glass cover of the headlight when the dipped beam is switched on.

This bulletin provides information about professional noise analysis with the VAS 611 015 PICO-NVH tool

This bulletin provides information when the parking assistance gives false warnings.

This bulletin provides information when the parking assistance gives false warnings.

This bulletin provides information regarding UV leak additive for finding oil leaks.

This bulletin provides information about vibrations and rotational steering vibrations.