2017 Audi A3

On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

RECALL CAMPAIGN 20YF; DESCRIPTION- SUCTION JET PUMP I was not made aware of the recall until fuel began gushing out of my passenger side rear. The Audi dealership was aware of the recall in July of 2025 when I had routine maintenance at the service department, however it was not addressed. Fast forward to the fuel leak in April 2026, I was informed by the repair reps that the leak was due to a failed charcoal canister. I attempted several times to notify my advisor and manager that the recall addresses that the suction pump defect can cause fuel to flow into the EVAP system causing leaks through the charcoal canister. I was told that this was impossible and repair costs would not be waived. I also reached out to the Audi consumer line and was told that only the dealership could have fees waived even though the representative agreed that my issue was due to the failed suction pump.

NHTSA ID

11743858

Incident

Apr 27, 2026

While driving at highway speeds, a warning light appeared as well as an alert indicating the car was limited to no more than 4000rpm. After coming to a stop, a strong smell of gasoline was noticed in the passenger compartment. Continued driving home uneventfully but the strong smell of gas persisted. The next day I drove the car to a mechanic. Their inspection notes the following: The technician verified the customer concern of a fuel smell. He performed a fault scan, finding codes for low fuel pressure. He inspected the vehicle, finding a major fuel leak under the intake manifold, most likely from a cracked fuel rail. The system is supposed to operate at 125 bar of fuel pressure, but is currently at 9-11 bar. The high pressure fuel pump is operating at 100% duty cycle, which means it has overheated and been damaged. Metal shavings from the fuel pump then ends up inside of the injectors, ruining them. The low pressure fuel pump may be ok, but it is unclear at this time. **RECOMMEND REPLACING FUEL RAIL, HIGH PRESSURE FUEL PUMP, INJECTORS WITH SEALS, AND PRESSURE SENSOR **MAY NEED LOW PRESSURE FUEL PUMP They also noted that the leaking fuel could cause a fire hazard. The fact that this fuel leak happened at only 98,750 miles and that the car continued to be drivable with fuel spraying all over the engine compartment is extremely concerning.

NHTSA ID

11719288

Incident

Feb 13, 2026

In August 2025, my 2017 Audi A3 (VIN [XXX] ) experienced repeated stalling, strong gasoline odors inside the cabin, and a check engine light immediately after Audi completed recall-related service. The safety issue was later confirmed by the dealership to be caused by a failed suction jet pump (NHTSA Recall 24V110), which allowed fuel to enter the EVAP system and leak into the rear seat area and cabin. The leak was so severe that the rear seat and flooring had to be replaced due to fuel saturation. Before the problem was properly identified, I was repeatedly told the issue was “just the gas cap,” despite reporting fuel smell, rapid fuel loss after filling the tank, and the check engine light. During this time, I unknowingly drove a vehicle with a significant fire hazard. The cabin fumes caused physical symptoms and unsafe driving conditions. I was not notified of this recall at the time I purchased the vehicle in March 2022, nor was I notified of a second recall affecting the passenger occupant detection system (69BY), despite having purchased a one-year maintenance warranty. I only became aware of the recalls after experiencing the hazardous symptoms described above. The problem was confirmed and reproduced by the Audi dealership. Fuel odor, fuel loss, and warning lights first appeared within 24 hours after the initial service visit, and the safety defect was later linked to the recall-related component failure. This defect presented a serious risk of fire and exposure to gasoline fumes to both myself and other road users. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11703596

Incident

Aug 1, 2025

The Vehicle Electrical System Control Module J519 had a fault that prevented using many vehicle functions - no interior lights, no heated seats, dashboard and navigation screen too dim to read in daylight.

NHTSA ID

11638367

Incident

Dec 12, 2024

Car throws P2884 and the internal combustion motor will not start. The issue is gone into detail here: [XXX] recommendation is swapping out mechatronic unit for the upgraded unit. Since the unit is prone to failure this really should be a recall. It happens on all cars 2016/2017 years right around 60k miles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11637424

Incident

Jan 20, 2025

Passenger airbags, and emergency braking have been failing, i would have to be aware in advance if my vehicle needs to be checked, my safety and my passengers safety is in danger because incase i need to brake quickly but dont have the reaction time to do so i will crash since emergency brake doesnt work, and my passengers would be at high risk because of failing airbags, im unsure if the problem has been reproduced or confirmed by a dealer or independent service center, the problem has not yet been inspected there were other symptoms like my sensors going off or the car telling me some assists were malfunctioning in heavy rain or when the car is dirty

NHTSA ID

11631547

Incident

Dec 12, 2024

The Audi San Juan -Texas Address: 1001 East Expressway 83 ,San Juan, Tx. 78589 .Do not want repair my car for a recall WATER PUMP and in the future can cause fire .Audi A3 2017

NHTSA ID

11617608

Incident

Sep 16, 2024

The car started having issues around February 2024. The car first started misfiring and dying at stops which was a safety issue. When parked I noticed that there was an excessive amount of fuel that started coming out of the charcoal canister, another problem that could have resulted in the car catching on fire. The car could not be filled up with more fuel as there was pressurized fuel coming out through the fuel filler neck when the cap was removed. The problem was determined to be related to the currently active recall. I waited for 5 months for there to be a fix for the recall without being able to use the vehicle. I finally got tired of waiting and had my mechanic repair it. The fuel tank and charcoal canister were replaced and the old parts are available for inspection by interested authorities upon request. The car is now fully functional again after replacement of those components.

NHTSA ID

11603049

Incident

Feb 5, 2024

This bulletin provides a statement regarding the bottleneck of supply for VW approved oil types VW 504.00 and VW 507.00.

This bulletin provides information when there are creaking/squeakignnoises from the front end on uneven roads.

This service information TSB provides warranty coverage information for vehicles with a broken sunroof panel.

This bulletin provides information when there is a film/visible rings on the clear glass cover of the headlight when the dipped beam is switched on.

This bulletin provides informatoinw hent here are scratches or a coating on the cover of the instrument cluster, or particles inside of the housing.

This bulletin provides information when there is increased oil consumption; >0.5ltr/1000 km.