2013 BMW 335I

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

My vehicle has a defect with electric water pump, shorted by its factory connector due to unprotected electrical plug on water pump. BMW issued a recall to cover the defect but refusing to pay for repairs performed. Recall 24V-608 water pump electrical connector. Recall information includes same parts with defects which includes mine, exactly same part and same procedure for repairs. 2013 BMW 335i Drive, F30 (3 series sedan) This company must be held responsible for the repairs, can't cover half of the models then leave other half for the expense of owners. Same parts used and same procedures to address the defects, why is not my vehicle not included in this recall ???

NHTSA ID

11751957

Incident

Jan 12, 2026

The water pump runs all of the time and drains the battery completely overnight. The water pump runs even after the car is shut off. It seems like the water pump is shorted. The water pump connector appears to have the same issue as many other recalled BMWs but for some reason my VIN has not been included in the recall. The photo is of the stream of coolant being pumped by the water pump while the car is turned off. I cannot drive the car. It is sitting with the battery disconnected. I have called the dealer and they said my car is not part of the recall, but it should be.

NHTSA ID

11718597

Incident

Dec 20, 2025

The car died without warning on highway. Lost control because of no power. Car was towed. no codes found. Car died again on highway, lost control no power to brakes and steering. Car was hit trying to got off into breakdown lane. High pressure fuel pump no good.

NHTSA ID

11718453

Incident

Feb 6, 2026

The contact owns a 2013 BMW 335i. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The contact stated that the following day, while attempting to start the vehicle, the vehicle failed to start. The contact stated that after several attempts, the vehicle started. The vehicle was taken to an independent mechanic, where it was diagnosed with battery failure. The contact was informed that the battery needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the independent mechanic, and the battery was replaced for the second time. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the independent mechanic and the battery was replaced a third time, but the failure reoccurred. The vehicle was taken back to the independent mechanic, where it was diagnosed with coolant pump failure. The contact was informed that the coolant pump had an electrical shortage and needed to be replaced. The vehicle was not repaired. The dealer was not made aware of the failure. The manufacturer was made aware of the failure. The contact referenced NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the VIN was not associated with the recall. The failure mileage was approximately 140,000.

NHTSA ID

11710003

Incident

Jan 6, 2026

Mileage

140,000 mi

I haven’t even had my bmw 335i 2013 with 84000 miles on it yet for more than 8 months but somehow for some reason my electronic power steering rack has gone out twice in the span of 5 months.this is a issue. Everytime I’m getting on or off on ramps and taking the turns and curves at 35-40 mph then when you go to let your wheel slide through your hands so you can continue going straight is supposed to be smooth and effortless I shouldn’t have to worry about my life everytime I drive a car because the [XXX] wheel wants to snap back to the center angle at Mach 7 speed. The steering wheel feels loose when I’m driving straight and is heavy when I turn. Even going over bumps it will just start to pull to that side the bump was on its hard to even switch lanes cause I have to fight with my steering wheel. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11690282

Incident

Sep 18, 2025

There is TSB by BMW where they know there is an issue with there Fan.. according to them the fan is a 650w fan which causes a condition where the transmission gets a code. The car all of a sudden gets a dramatic power loss with no warning or check engine light.. i almost got into an accident when my car with no warning lost power… I called bmw of America and they are telling me I’m responsible to bring in the car and pay for the repair

NHTSA ID

11623639

Incident

Nov 4, 2024

All BMWs have a defect with passenger seat occupancy mat; airbag will not deploy in accident for passenger because passenger seat restraint system is defective in passenger seat (they call it passenger occupancy mat)- it is a life threatening issue found in my model of car and several other models. Issue Recall and save lives

NHTSA ID

11590939

Incident

May 27, 2024

Out of nowhere, on 6/24, the warning light came on saying that there is an issue with the passenger restraint system. It stays on when there is no one in the seat and then, even if someone is in the seat, it will turn off. I have not had an accident or had the car flooded to warrant a system malfunction like that. I have read that this has happened to other owners of this model and it is a faulty mat sensor that costs over $1000 to repair.

NHTSA ID

11529077

Incident

Jun 24, 2023

The basic conditions for initializing the power windows are not met.

The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.

Upon opening and closing the tailgate, a creaking/groaning sound can be heard from tailgate actuator.

After programming the head unit (HU-H2), activating the FSC (German word Freischaltcode) Enabling Codes repeatedly fails.

The 3G network in the US has been shut down. This means that only the 4G network will be available. In the 4G network, voice calls will be transferred via the Voice over LTE (VoLTE) function. For this purpose, the SIM card must perform an IMS registration in the mobile communication network. Due to a production error, the telematics control units were delivered without an IMS configuration. The Connected Drive voice services (Concierge Call, BMW Assistance, and emergency call voice) can no longer be used regionally in the US in vehicle with telematics control units ATM-1 and TCB-4G. Voice control of the vehicle and all other telephone (paired mobile devices) functions are not affected. Emergency call location data is unaffected.

Exterior rear lights do not work.