2013 Volkswagen Golf

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.

i was driving down the freeway on the way to work at 75 mph when all of a sudden my EPC went off in my 2013 volkswagon gti my entire car shut down (manual transmission) i lost all steering ability while on the freeway going 75 mph i couldn't get over to the shoulder due to loss of brakes due to entire car shutting down .i was almost smashed by a semi due to inability to steer my vehicle to total loss of power . i got the vehicle towed to a service shop they tell me that my timing chain had stretched and timing chain tensioner has failed, which caused significant damage to my engine . i bought the vehicle used and have taken meticulous car on it since i have owned it 3k oil changes ,proper oil ,proper, premium gas as notated milage based maintenance. the service center then notifies me that there was a class action lawsuit about failing timing chains and tensioners but when i called my local volkswagon dealership they told me it only covers up to125,000 miles but what i don't understand is that this issue almost cost me my life this is a known issue hence a class action lawsuit but to actually take care of the situation they refuse to do so i do enjoy the vehicle but i almost lost my life

NHTSA ID

11506679

Incident

Feb 10, 2023

The low beam headlamp burned out. I replaced the bulb successfully, but then the headlamp needed adjustment to be aimed properly with the new bulb. I found instructions online to aim the headlamp. There are three adjustment points, covering both low and high beams, according to the online document. I will try to attach photo of this document. The three adjustments are labeled as: L1, L2H2, and L3. On my VW, there is no adjustment available for location shown as L3. I even drilled into the plastic headlamp housing looking for the hidden adjustment point, but there was none. As a consequence, I am unable to aim that headlamp properly: either the low beam is pointing too high or the high beam is pointing too low. I believe this presents a safety issue at night. To me, it is unbelievable that VW eliminated the L3 adjustment on this vehicle. As I said, the position of the L3 adjustment point was molded over at the factory, there was no opening for adjustment. That's why I drilled into the area, and still found no adjustment point. I have no idea how many other VW vehicles are impacted by this shortcoming, the owners will not find out until the headlamp burns out and there is no way to adjust the replacement lamp. This is a latent defect in design/manufacture.

NHTSA ID

11500133

Incident

Dec 1, 2022

The contact owns a 2013 Volkswagen Golf. The contact stated that the front passenger’s side seat overheated and burned the occupant. The burn injuries were minor and there was no medical attention sought. The contact mentioned that the front passenger side fan was failing as well. The vehicle was taken to the dealer but no failure was determined. The vehicle was taken to another dealer and the contact was informed that the rear passenger’s side door had mildew and mold and that there was a leak that caused electrical damage inside the vehicle. The vehicle was not repaired. The manufacturer was contacted and stated that the vehicle was out of warranty. The failure mileage was 40,000.

NHTSA ID

11481068

Incident

Nov 19, 2019

Mileage

40,000 mi

The steering wheel clock spring was replaced on my vehicle as part of a recall in May 2016 by a local VW dealer. Within the last month I've received an "Error: Airbag" notification on my dash. My mechanic scanned the Air Bag Control Module for codes and there was 1 in memory: B1000 Igniter for Driver's Air Bag, Resistance Too Large". I understand that the defective Air bag clock spring replacement part is unavailable as it has been nationally on back order for the past year, and 7,000 vehicles are waiting for the part. This issue has affected everything controlled through the steering wheel, including my horn, making the otherwise perfectly good car unsafe and perhaps illegal to drive. Both the dealership and VW of American Customer Care have been unable to offer me an interim solution (at least offering a horn).

NHTSA ID

11471720

Incident

May 21, 2022

Car shut off while driving on the freeway at a high rate of speed. EPS and Check Engine light came on. Luckily was able to pull over without hurting anyone. Local repair shop said it is the timing chain system.

NHTSA ID

11450468

Incident

Sep 1, 2021

Misfiring after cold starts. After driving the car in freezing temperatures, problem sometimes happens when the car is allowed to sit and water in the intercooler melts. It may start fine, but then starts misfiring when pulling into traffic and creates dangerous merges. Misfire goes away in the first 30 seconds to 2 minutes or so of starting the vehicle. Several dealer complaints but they have so far refused to install their own TSB repair under warranty. The most recent dealer visit had them replace the anti-shudder valve. The problem reoccurred two days later.

NHTSA ID

11447672

Incident

Jan 16, 2022

TL* THE CONTACT OWNS A 2013 VOLKSWAGEN GOLF. THE CONTACT STATED WHILE DRIVING 40 MPH, HE SHIFTED INTO THIRD GEAR AND THE VEHICLE SPUTTERED AND SHUT-OFF WITH THE BATTERY WARNING LIGHT ILLUMINATED. THE VEHICLE FAILED TO RESTART. THE CONTACT STATED A TOW TRUCK TRIED TO BOOST THE BATTERY AND IT FAILED. THE CONTACT STATED THAT THE VEHICLE WAS TOWED TO HIS RESIDENCE. THE CONTACT REPAIRED THE BATTERY HOWEVER, THE FAILURE PERSISTED. THE VEHICLE STILL FAILED TO RESTART. THE LOCAL DEALER WAS CONTACTED BUT OFFERED NO ASSISTANCE. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 91,000.

NHTSA ID

11400370

Incident

Mar 7, 2021

Mileage

91,000 mi

FRONT DRIVER SIDE COIL SPRING BROKE. BACKING OUT OF DRIVEWAY.

NHTSA ID

11348926

Incident

Aug 12, 2020

Mileage

80,000 mi

This is a notice for software changes with the ODIS diagnostic program to correct the communication during vehicle programming function: A software fix is needed to correct the issue: DA 0019 - Hotfix 12-V battery test(s) – No battery diagnosis - Inconclusive test result.

Oil Consumption Measurement and Electronic Oil Consumption Measurement

Instruction, how to lubicate engine before initial start.

Lubricating engine components before reassembly.

Inquiries

Volkswagen Engine Oil Standards