2018 Volkswagen Golf

On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Vehicle brought in for Recall 20UF (fuel tank suction pump fire risk) on 04/15/2026. Upon pickup after approximately one week of dealer service, a strong chemical odor was present in the cabin that did not exist prior to service. Odor persists despite cabin air filter replacement with activated charcoal filter, professional carpet shampooing, and extended airing out over several weeks. Dealer dismissed concerns and suggested owner pay for cabin filter replacement which had no effect. VW's own Recall 20UF documentation acknowledges that fuel odor may be noticed by occupants when the recall condition exists. Requesting investigation into whether recall repair was fully completed and whether odor is related to incompletely resolved recall condition. A neighbor experienced identical odor issue after bringing their Tiguan to a different Westchester dealer for service.

NHTSA ID

11741116

Incident

Apr 15, 2026

SUPPLEMENTAL INFORMATION OF ODI COMPLAINT NUMBER 11740201. I am submitting critical supplemental information to my active safety complaint regarding a 2018 Volkswagen Golf SportWagen (1.8T engine). My primary safety issues are a severe drop in fuel efficiency (cut completely in half), heavy vehicle hesitation/jerking during acceleration, and a powerful raw gasoline smell inside the cabin immediately after fueling. These symptoms heavily align with the known physical failures covered under Volkswagen's Suction Jet Pump safety campaigns. I took my vehicle to the Volkswagen dealership today for a diagnostic inspection. The service manager initially dismissed my complaints, refused to physically check the EVAP charcoal canister or suction pump, and claimed that my 50% drop in fuel economy was merely due to my 'driving style.' However, upon forcing me to pay a $136 diagnostic fee to retrieve my keys, the official paperwork provided by the dealership directly contradicted the manager. The technician documented finding a physical fuel leak. Alarmingly, this is the exact same 'small fuel leak' that this specific dealership claimed to have fully repaired a few months ago. That previous visit occurred because my steering wheel completely locked up while driving, nearly causing a severe accident—an issue the dealership also dismissed at the time because it 'failed to throw an error code.' The dealership has demonstrated a reckless pattern of ignoring severe mechanical safety hazards—including steering failures and active, recurring fuel leaks—solely because the vehicle's computer does not register a digital fault code. I am trapped driving a vehicle that is actively leaking fuel, smelling of raw gas inside the passenger cabin, and suffering from dangerous acceleration hesitation due to an unresolved fuel-system defect. I request a formal investigation into this ongoing safety hazard and the dealer's failure to remedy it.

NHTSA ID

11740222

Incident

May 26, 2026

Took my car into VW in Johnson City TN because my millage has been dropping drastically. Went from about 420 miles to a tank, down to less than 300. There is hesitation and jerking when I accelerate as well as a gasoline odor in the cab of the vehicle after refueling. Service manager said there was no code thrown and when he took it for a drive her drove “conservatively” and the mpg was normal. They did not physically inspect the fuel pump jet and gaslit me saying it was how I’m driving. Refused to actually look at the problem and then threatened that if I wanted them to look they would charge me for the labor. They did not seem concerned that a safety hazard of smelling fuel in the cab and poor fuel efficiency was an issue.manager said he knew of the active extended recall but hid behind the no code from their scanner instead of listening to the customer who voiced concerns. They didn’t want to do the work if they had to pay for it.

NHTSA ID

11740201

Incident

May 26, 2026

Sunroof Glass Implosion While Driving (2018 Volkswagen Golf) While driving my 2018 Volkswagen Golf at normal highway speed, my sunroof suddenly and violently imploded without any warning or external impact. The sound was extremely loud—similar to a gunshot or an explosion—and initially I believed something had struck the vehicle or that a large object had landed on the sunroof.Glass shattered and fell into the interior of the vehicle, sending shards throughout the cabin. The incident was extremely frightening and caused me to momentarily lose focus while driving. I narrowly avoided a potential car accident due to the sudden noise, falling glass, and shock of the event. There were no visible objects, debris, or overpasses that could explain the breakage, and no other vehicles were involved. This appears to be a spontaneous sunroof glass failure. The incident poses a serious safety risk, as it could easily lead to a crash or cause injury to occupants. I am reporting this issue to raise awareness and request investigation, as spontaneous sunroof implosions while driving are dangerous and should not occur under normal driving conditions.

NHTSA ID

11704994

Incident

Dec 14, 2025

There is an issue with the gear shift cover trim. The piece that goes around the gear shift has a chrome coating that has been pealing off. Over multiple occasions that pealed off piece of metal has cut my finger causing bleeding. There seems to be a recall on the DSG GTI for this, but not the MT. I am having the same exact issue as the DSG and the replacement part is the exact same (likely same original part). The safety issue is that this has cut my finger multiple times with bleeding and can be quite painful. I called VW and was told my car was not part of the DSG recall 34J7/34L9, but clearly it has the same issue. Here is the case number from that call: VW Customer CARE [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11625316

Incident

Nov 14, 2024

Cannot fill gas tank. Recall issued February 2024 no remedy available still. 24V110

NHTSA ID

11602381

Incident

Jul 15, 2024

I have a recall for the jet pump in the fuel tank of my vehicle. I have had fuel leaking from my charcoal canister. The vehicle is at the dealership right now, and they have confirmed this. Yet they will not make a repair on it and have been without my vehicle for over a week now. I am stuck in limbo with no date when anything will be done. I am unable to drive my vehicle due to he leak as it is unsafe and a fire hazard. The vehicle will also cut off while driving and will not start, even though it says there is still fuel in it. This should be due to the leak, and the dealer will do nothing to fix my problem until they are notified by Volkswagen themselves. This is ridiculous as i am without a vehicle, which i am still paying a loan on and insurance every month. Yet i have called Volkswagen and have been offered no solution on this matter. I have been told to wait for the recall, but this issue has been known about since February. Am i just supposed to wait indefinitely for a solution while i can't work or drive anywhere, while i continue to pay for this vehicle? I need a solution and Volkswagen to fix my issue and to be help responsible.

NHTSA ID

11600571

Incident

Jun 29, 2024

There is a peeling plastic/metal chrome trim piece on the steering wheel that cause a finger laceration.

NHTSA ID

11570664

Incident

Feb 6, 2024

This is a notice for software changes with the ODIS diagnostic program to correct the communication during vehicle programming function: A software fix is needed to correct the issue: DA 0019 - Hotfix 12-V battery test(s) – No battery diagnosis - Inconclusive test result.

Oil Consumption Measurement and Electronic Oil Consumption Measurement

Lubricating engine components before reassembly.

Instruction, how to lubicate engine before initial start.

Inquiries

Volkswagen Engine Oil Standards