2019 Volkswagen Golf

On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

The Office of Defects Investigation (ODI) has completed its review of a defect petition received on 14 August 2019 requesting an investigation of an alleged defect of the manual transmissions in Model Year (MY) 2019 Volkswagen (VW) GTI, Golf GTI and Jetta GLI vehicles. The stalling incidents cited occurred without warning as the vehicle slows to a stop or prepares to make a turn across traffic with the clutch pressed in and the vehicle in neutral.The hazard posed by a vehicle stalling event is manifested in the inability of the vehicle to move with the flow of surrounding traffic. Two factors have a major impact on the potential hazard to the vehicle, its occupants and surrounding vehicles: the surrounding traffic speed and the subject vehicle's restart ability. In the case of the vehicles that are the subject of this petition, restart is immediate and the stalls occur when the vehicle is slowing to stop for a traffic signal, making a turn, or is completely stopped. These circumstances substantially reduce the risk of harm to the vehicle, its occupants and surrounding vehicles.As of March 2, 2020, out of the population of 11,333 subject vehicles, NHTSA has identified 214 consumer complaints in its database, with unique Vehicle Identification Numbers (VIN), citing engine stalling as vehicles are being brought to a stop and/or preparing to make a cross traffic turn. When combined with the warranty, field report and customer complaint data received from VW in response to the Information Request letter sent, NHTSA identified 413 unique VINs alleging low speed engine stalling.Volkswagen determined that the low speed / idle engine stall was the result of unwanted gases remaining in the cylinder caused by the intake valve camshaft not being in the correct position at idle. The intake camshaft is in an advanced position. This advanced position results in too much overlap with the position of the exhaust valve camshaft, allowing both the intake and exhaust valves to be open at the same time. The erroneous advanced position of the intake camshaft is a result of low oil pressure at idle and high oil temperatures, greater than or equal to 110?C/230?F combined with engine control algorithms in the Engine Control Module (ECM) that position the intake camshaft. Based on examination of returned engines, only engines manufactured at the Silao Mexico plant were affected due to a tolerance stack-up issue with the oil system of the engines.In December of 2019, VW initiated a Service Action (24FD) to remedy the stalling issue in the affected vehicles. The warranty for the affected vehicles was extended to December 31, 2025. The software in the Engine Control Module (ECM) will be updated with a new calibration value for the adaptation nodes of the regulation valve. This is a directed action with letters being sent to vehicle owners asking them to bring their vehicles to their dealership to have the software update installed in their vehicle. The letters were sent in December 2019.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Volkswagen in response to an information request and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that the stalling condition as alleged by the petitioner indicates the likelihood of a safety related defect that would warrant a formal investigation, therefore the petition is denied. Further specifics can be found in the Federal Register Notice.ODI complaint ID Numbers are listed on the attached sheet.

I am currently stationed in the United Kingdom and the VW dealership is stating that they are unable to complete the needed recall because it is an imported vehicle?! Not sure how something that important can just be shrugged off because I am in a different country.

NHTSA ID

11677470

Incident

Jul 30, 2025

The contact owns a 2019 Volkswagen Golf. The contact stated that while the vehicle was parked, the contact attempted to start the vehicle and the air bag warning light illuminated. The contact attempted to contact the dealer; however, the vehicle was not diagnosed. The contact stated that an independent mechanic was contacted, and the vehicle was scheduled to be taken to be diagnosed. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 75,038.

NHTSA ID

11653958

Incident

Apr 10, 2025

Mileage

75,038 mi

This has been an open recall for 5 years and the manufacturer will not fix it. This could lead to vehicle fires and injuries.. It is not acceptable that Volkswagen can just ignore these safety recalls!

NHTSA ID

11609117

Incident

Aug 17, 2024

When driving down the road doing about 35 mph with no car close in front of me my forward collision sensor went off without warning and initiated sharp braking which almost caused the car behind me to run into me. My car jolted like I’d been hit (I hadn’t) and the red warning light lit up the dashboard. The person behind me was able to brake in time and didn’t hit me. I don’t think my brake lights engaged. It was terrifying and incredibly unsafe and I’m lucky I wasn’t on a highway or there wasn’t anyone following too closely behind. Very, very dangerous situation.

NHTSA ID

11587310

Incident

May 6, 2024

When driving over train tracks the automatic emergency brakes engaged and the forward collision detection beeping alarm sounded. This has happened over 5 times since I have owned the car. Many times the forward collision alarm will go off without engaging the brakes, seemingly without cause. Only when passing over train tracks do the emergency brakes bring the vehicle to a stop or to an extreme slowdown. I have a video of the incident if you would like it, but no way to upload on this website. You can hear the emergency brake and alarm going off with nothing in front of my car.

NHTSA ID

11584895

Incident

Apr 24, 2024

Purchased vehicle brand new from Seacoast VW in Greenland, NH in March of 2020. In February of 2022 with just 12804 miles on this vehicle I had them check a problem with noisy rear brakes. I was informed that the rear brakes were delaminating and needed replacement for around $800. As this was beyond the 12 month warranty that this charge was not to be covered. After much negotiation I agreed to pay 20% of the parts & labor charge and they would pick up the remaining 80% as a one time goodwill because I was a loyal VW customer. The excuse that was given to me at that time is that I didn't drive enough miles & rust on the rotor caused the delamination. Jump forward to April 2024 I again was told my rear brakes were delaminating and would not pass the NH state safety inspection. The service consultant was very surprised that they had already replaced the rear brakes in 2022! I was again told this was because I did not drive enough. I then called VW Customer Care phone number that the dealer provided to see if VW would provide some financial relief. The woman who answered the phone was very polite and understood my frustration that brakes would fail after only 12000 miles but after checking with her supervisor informed me that VW would not help with this Safety problem. I then asked her if I was the only one who has experienced this problem And she emphatically stated that I was not the only complaint for this problem and even suggested that I keep all of my records for possible reimbursement in a future recall due to the significant number of complaints that VW has had with this problem. This is a severe safety problem that VW is trying to sweep under the rug and needs to be investigated so VW bears the cost of this and not the many customers that have so far had to bear the expense that is an actual design flaw!

NHTSA ID

11581354

Incident

Apr 5, 2024

The contact owns a 2019 VW Golf. The contact received notification of NHTSA Campaign Number: 23V604000(Electrical System) however, the part to do the recall repair was unavailable. The local dealer was contacted and it was confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced the failure. The VIN tool confirms parts not available.

NHTSA ID

11562500

Incident

Dec 29, 2023

Driving on the interstate with no cars near me and my sunroof exploded and showered me with glass. VW is claiming that it was hit and it was not. The car is my daily driver, and I inspect it daily. The plastic insert was cracked (also an issue with this model)and mentioned by me on a previous service visit at Baxter Volkswagen of Omaha, but it was not investigated by Baxter and then the service advisor gave no explanation as to why it was not looked at. A month a half later the sunroof exploded.

NHTSA ID

11549494

Incident

Sep 26, 2023

This is a notice for software changes with the ODIS diagnostic program to correct the communication during vehicle programming function: A software fix is needed to correct the issue: DA 0019 - Hotfix 12-V battery test(s) – No battery diagnosis - Inconclusive test result.

Oil Consumption Measurement and Electronic Oil Consumption Measurement

Lubricating engine components before reassembly.

Instruction, how to lubicate engine before initial start.

Inquiries

Volkswagen Engine Oil Standards