2014 Volkswagen Golf

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.

My vehicle has (2) serpentine belts, and (2) Belt Tensioners. (1) Tensioner is for the belt that engages the Water Pump, Alternator, Power Steering and then has (3) Idler Pulleys. The other one is the AC Tensioner, that belt routes from the AC Compressor to the Crank and the AC Tensioner. The AC Compressor is a dual belt pulley. So the AC Tensioner is suppling the power for the Accessory Belt to spin, and operate the cooling system, charging system, and power steering. Recently the Accessory Belt ripped, and since the belts and the tensioners have yet to be serviced, I planned on doing both tensioners and belts. Upon replacing the components with new ones, the AC tensioner rubs against the Accessory Belt, which will def cause the belt to rip. Further investigating, I saw the original AC Tensioner has a cut out on the side of the housing made, so that the Accessory Belt will not rub against it and spin freely. I called VW Service, O Reillys, Auto Zone, Advanced Auto, and none of the tensioners have the cut out, they all have the same tensioner that is being sold. So what do I do now? Vehicle is not drivable, and without the correct part, this vehicle is unable to safely drive. Once that belt rips, cooling system won’t work, charging system and power steering. My vehicle has almost 200K and is mechanically sound, I maintain the maintenance on this vehicle to a T. Yet I am unable to purchase a part that is needed to ensure this vehicle continues to operate safely, due to a complete engineering design mistake. In which it seems to be completely covered up, because how many people will really service the tensioner. Well I did, and I would like my vehicle to run again, seeing as how the manufacturer decided to make this shortcut, and cross there fingers and hope no issues arose

NHTSA ID

11541789

Incident

Aug 29, 2023

While driving on the freeway the car stopped accelerating and would only rev when gas pedal was pressed. I coasted to the fast lane shoulder and put on hazard lights. CHP had to stop freeway traffic to push me to the side of the freeway. Car eventually restarted and let me put into gear. I drove to Auto repair store and they scanned car. Code U0103 came back: No communication with gear shift module.

NHTSA ID

11465862

Incident

May 23, 2022

I'M HAVING ISSUES WITH A P0106 CODE. IT CONTINUOUSLY COMES OFF AND ON. I HAVE HAD THE MANIFOLD ABSOLUTE PRESSURE SENSOR REPLACED, I HAVE HAD THE INTAKE CLEANED AND RELATABLE PARTS. THE CHECK ENGINE LIGHT WILL COME ON AT RANDOM TIMES, AND WILL JUST GO AWAY ON IT'S OWN. I HAVE READ THAT MULTIPLE PEOPLE HAVE HAD TO UPDATE THE ECM WHICH HAS THEN FIXED THE ISSUE. I DON'T BELIEVE THIS SHOULD BE AN EXPENSE TO THE OWNER OF THE VEHICLE FOR AN UPDATE THAT SHOULD HAVE BEEN DONE IN THE FIRST PLACE.

NHTSA ID

11353090

Incident

Aug 1, 2020

Mileage

127,000 mi

THE SLAVE CYLINDER WENT BAD ITS PORING FLUID OUT IT COMPLETELY FAILED WHEN THE VEHICLE WAS PARKED IT HAS EXACTLY 34,272 MILES IT SHOULD NOT HAVE FAILED AT THAT MILEAGE AND AGE I KNOW OF 3 OTHER PEOPLE AROUND THAT HAVE HAD THE SAME THING HAPPEN THIS NEEDS TO BE LOOKED INTO BECAUSE ITS STARTING TO LOOK LIKE A MANUFACTURING PROBLEM. THIS COULD HAVE BEEN FATAL IF IT HAD WENT OUT COMPLETELY ON THE HIGHWAY SINCE AN INEXPERIENCED DRIVER WOULDN'T KNOW WHAT TO DO SINCE YOU CANT CHANGE GEARS

NHTSA ID

11254699

Incident

Apr 30, 2019

Mileage

34,272 mi

TL* THE CONTACT OWNS A 2014 VOLKSWAGEN GOLF. THE CONTACT STATED THAT THE ABS WARNING LIGHT ILLUMINATED. THE VEHICLE WAS THEN TAKEN TO A LOCAL DEALER (CHARLES MAUND VOLKSWAGEN LOCATED AT 6900 BURNET RD, AUSTIN, TX 78757, PHONE NUMBER: (512) 458-1111) WHERE IT WAS DIAGNOSED THAT THE WHEEL SPEED SENSOR FAILED AND NEEDED TO BE REPLACED. THE FAILURE WAS REPAIRED BUT A LITTLE OVER A YEAR LATER, THE ABS WARNING LIGHT ILLUMINATED AGAIN. THE VEHICLE WAS TAKEN BACK TO THE SAME LOCAL DEALER WHERE IT WAS DIAGNOSED THAT THE WHEEL SPEED SENSOR FAILED AND NEEDED TO BE REPLACED. THE PART WAS REPLACED BUT ANOTHER YEAR LATER, THE ABS WARNING LIGHT ILLUMINATED A THIRD TIME. THE VEHICLE WAS TAKEN BACK TO THE SAME DEALER WHERE THE WHEEL SPEED SENSOR WAS REPLACED. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY AT 40 MPH, A DEER JUMPED IN FRONT OF THE VEHICLE AND THE BRAKE PEDAL WAS DEPRESSED IN ORDER TO AVOID HITTING THE DEER. AS A RESULT, THE VEHICLE SKIDDED AND THE ABS FAILED TO ACTIVATE. IT WAS UNKNOWN WHAT THE CONTACT CRASHED INTO. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES SUSTAINED. THE VEHICLE WAS ABLE TO BE DRIVEN AFTER THE CRASH. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 16,085.

NHTSA ID

11231957

Incident

Jun 15, 2016

Mileage

16,085 mi

TAKATA RECALL A VW DEALER SERVICE INVOICE STATES THEY COMPLETED THE RECALL ON THIS CAR, BUT YOUR WEBSITE SAYS IT IS INCOMPLETE, ACCORDING TO MY VIN. VW OF AMERICA SENT ME RECALL NOTICES IN MARCH & APRIL OF 2018. COMMUNITY VW, SANTA MARIA, CA 93456 [805 348-3221] INVOICE DATE: 12/19/17 CUSTOMER NUMBER: 50792 TECHNICIAN NUMBER: 34657 I WOULD LIKE TO VERIFY THAT THE WORK WAS ACTUALLY DONE. IS THERE AN IDENTIFYING MARK, LABEL OR NUMBER THAT I CAN SEE SOMEWHERE ON THE AIRBAG? THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

11122097

Incident

Dec 19, 2017

Mileage

32,730 mi

TL* TAKATA RECALL. THE CONTACT OWNS A 2014 VOLKSWAGEN GOLF. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V078000 (AIR BAGS); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. JENNINGS VOLKSWAGEN, LOCATED AT 201 WAUKEGAN ROAD, GLENVIEW, IL, WAS CONTACTED AND REFUSED TO PERFORM THE REPAIR UNLESS THE CONTACT PAID FOR THE REPAIR. THE DEALER STATED THAT NHTSA APPROVED THEIR REMEDY AS PERMANENT. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS NOT PROVIDED.

NHTSA ID

11019620

Incident

Aug 23, 2017

"KEY GETS STUCK IN IGNITION AND I CANNOT TURN OFF THE ENGINE.

NHTSA ID

11011794

Incident

Jun 15, 2017

Mileage

60,000 mi

This is a notice for software changes with the ODIS diagnostic program to correct the communication during vehicle programming function: A software fix is needed to correct the issue: DA 0019 - Hotfix 12-V battery test(s) – No battery diagnosis - Inconclusive test result.

Oil Consumption Measurement and Electronic Oil Consumption Measurement

Instruction, how to lubicate engine before initial start.

Lubricating engine components before reassembly.

Inquiries

Volkswagen Engine Oil Standards