1999 Volkswagen Golf

THIS INVESTIGATION WAS OPENED ON NOVEMBER 29, 2004, BASED ON FIVE CONSUMER REPORTS ALLEGING FUEL LEAKING FROM THE FUEL PUMP.BY LETTER OF APRIL 14, 2004, VOLKSWAGEN OF AMERICA (VOLKSWAGEN) NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 35,000 GOLF AND GTI VEHICLES MANUFACTURED IN WOLFSBURG GERMANY FOR THE NORTH AMERICAN MARKET.THE RECALLED VEHICLES ARE IN MODEL YEARS 1999 AND 2000 AND ARE EQUIPPED WITH GASOLINE ENGINES.VOLKSWAGEN HAS IDENTIFIED A CONDITION IN WHICH THE FUEL SUPPLY LINE FROM THE FUEL DELIVERY MODULE (PUMP) TO THE FUEL FILTER MAY COME UNDER TENSION. IN THIS CONDITION THE FUEL PUMP SUPPLY NIPPLE CAN CRACK, RESULTING IN A GASOLINE LEAK.VOLKSWAGEN DEALERS WILL INSPECT FOR TENSION ON THE FUEL LINE AND CRACKS IN THE FUEL PUMP SUPPLY NIPPLE.IF TENSION IS FOUND IN THE LINE, IT WILL BE REPLACED WITH A REVISED LINE.IF THE FUEL PUMP SUPPLY NIPPLE IS CRACKED, THE LINE AND THE PUMP WILL BE REPLACED.PLEASE SEE SAFETY RECALL 05V154 FOR DETAILS.

WHITE METAL USED IN FRONT AND READ WINDSHIELD WIPERS AND ALSO REAR HATCH DOOR LATCH FLAKE APART AND CRUMBLE MAKING WIPERS AND LATCH UNUSABLE. REPLACED FRONT WIPER ASSEMBLY JUNE 2012, REAR WIPER DOES NOT WORK, SAME WITH REAR DOOR LATCH. FRONT WIPERS STOPPED WORKING SUDDENLY WHILE IN A SUMMER DOWNPOUR CAUSING A MAJOR SAFETY PROBLEM.

NHTSA ID

10934964

Incident

Jun 6, 2012

Mileage

71,000 mi

WINDOW REGULATOR SWITCHES AND INTERIOR LIGHTS STARTED TO MALFUNCTION EARLY IN THE LIFE OF THE CAR, STARTING ABOUT 2003. MY PASSENGER WINDOW FELL INTO THE DOOR ONCE, AND THE SAME HAPPENED FOR MY DRIVER SIDE WINDOW TWICE. THE WINDOW SWITCHES ARE FLAKY AND REQUIRE INTENSE CONCENTRATION TO TAP THEM JUST RIGHT TO MAKE THE WINDOW GO IN THE DIRECTION THAT YOU WANT. IF YOU TAP TOO STRONGLY OR TOO LONG, THE WINDOWS REVERSE DIRECTION. THIS IS EXTREMELY DISTRACTING AND DANGEROUS WHEN YOU ARE TRYING TO FOCUS ON THE ROAD. DEALERSHIP AND LOCAL MECHANICS REPLACED REGULATOR SWITCHES AND MOTORS SEVERAL TIMES, YEARS AGO. I WAS TIRED OF REPLACING THEM, SO NOW I TRY TO USE THE WINDOWS AS LITTLE AS POSSIBLE. I KEEP A FLASHLIGHT PERMANENTLY ON THE PASSENGER SEAT TO COMPENSATE FOR 12 YEARS OF DARKNESS IN THE CABIN. ALARM SYSTEM OCCASIONALLY CHIRPS FOR NO REASON, AS IF DETECTING AN INTRUDER, AND SOMETIMES WILL NOT GENERATE THE BEEP BEEP WHEN I HIT THE ENGAGE BUTTON ON MY KEY FOB. ALARM SOMETIMES GOES OFF WHEN I START THE CAR, AS IF I'M CARJACKING MY OWN CAR. I SUSPECT THE 1999 BATCH OF VOLKSWAGEN CARS HAD SERIOUS GROUNDING OR ELECTRICAL ISSUES. CAR CONTINUES TO RUN FINE (CURRENT MILEAGE IS 392,000) DESPITE THE ELECTRICAL DEMONS, BUT WITH REDUCED SAFETY AND INCREASED DISTRACTIONS.

NHTSA ID

10762027

Incident

Sep 1, 2003

Mileage

100,000 mi

INSTRUMENT CLUSTER FIRE IN 1999 VW GOLF TDI: 2003-01-14, MILEAGE 88290, LIGHTS AND GAUGES ON INSTRUMENT CLUSTER WERE ACTING FLAKY AND NOT WORKING PROPERLY. SOME LIGHTS WERE DIM AND SOME WERE BURNT OUT. 2003-02-05, I BOUGHT NEW INSTRUMENT CLUSTER. PLAN WAS TO HAVE DEALERSHIP REPLACE FAULTY ONE WITH NEW ONE ON 2003-02-10. A FEW DAYS AFTER I BOUGHT NEW ONE, THE CARS EXISTING ONE SUDDENLY EMITTED SPARKS WHILE I WAS DRIVING IN A SNOW STORM, AND CAUGHT ON FIRE! THICK, ACRID SMOKE BILLOWED FROM UNDERNEATH THE DASHBOARD, FORCING ME OUT OF THE CAR. I PUT OUT THE FIRE WITH MY JACKET AND SOME SNOW. 2003-02-10, DEALERSHIP REPLACED INSTRUMENT CLUSTER. DURING THE FIRST HEAVY SNOWFALL AFTER THAT, CAR STARTED BUCKING AT LOW RPMS AND WHEN ATTEMPTING TO SHIFT GEARS. SPEEDOMETER STARTED FLUCTUATING WILDLY, SHOWING ME GOING ANYWHERE FROM 0 TO 120 MPH. TEMPERATURE GAUGE STARTED FLUCTUATING BETWEEN 0 AND DANGER ZONE, AND TEMPERATURE ALARM SOUNDED WHENEVER THE GAUGE JUMPED INTO THE DANGER ZONE. FUEL GAUGE DROPPED TO EMPTY. ODOMETER FROZE UP. 2003-04-04, MILEAGE 90906, TECHNICIAN AT DEALERSHIP FOUND 300 KILO-OHM RESISTANCE IN WIRING HARNESS GROUNDS. THE FOUR MAIN GROUND WIRE ENDS WERE HORRIBLY CORRODED. AS A RESULT, THERE WAS NO POWER GOING TO THE ENGINE COOLANT TEMPERATURE SENSOR, VEHICLE SPEED SENSOR, OR COOLANT BOTTLE SENSOR. TECHNICIAN LEFT THE EXISTING WIRING HARNESS IN PLACE, SINCE MOST OF THE HARNESS WIRES WERE WORKING FINE. HE DISCONNECTED AND CAPPED THE ENDS OF THE FOUR CORRODED WIRES. HE THEN RAN NEW WIRES TO THE AFFECTED SENSORS (CREATING AN OVERLAY HARNESS), CRIMPED NEW CONNECTORS ON THE ENDS, AND USED HEAT SHRINK ON THE CRIMPS. I HAVEN'T HAD ANY INSTRUMENT CLUSTER FIRES SINCE THEN; HOWEVER, I HAVE REPLACED THE ECT SENSOR 7 TIMES DURING THE 15 YEARS I HAVE OWNED THIS CAR, POSSIBLY BECAUSE OF LINGERING GROUNDING ISSUES. CURRENT MILEAGE IS ABOUT 392,000.

NHTSA ID

10762026

Incident

Feb 7, 2003

Mileage

90,000 mi

THIS STARTED TO OCCUR ABOUT 2009, ABOUT 6 YEARS AGO. WHEN I PUSHED UP THE REAR SEATS, I DISCOVERED THAT THE CENTER SEAT BELT WAS TIGHT AND WOULD NOT RELEASE. I COULDN'T EVEN PUSH THE REAR SEAT BACK DOWN BECAUSE THE SEAT BELT WAS SO EXTREMELY TIGHT. WITHIN A YEAR OR TWO LATER, ALL OF THE REAR SEAT BELTS LOCKED UP. THE REAR SEATS ARE NOW UNSAFE FOR PASSENGERS.

NHTSA ID

10762025

Incident

Sep 1, 2009

Mileage

215,000 mi

TL*THE CONTACT OWNS A 1999 VOLKSWAGEN GOLF. THE CONTACT STATED THAT THE VALVE IN THE FUEL CAUSES THE VEHICLE TO STALL WITHOUT WARNING. THE VALVE BECOMES CLOGGED WITH THE FUEL. HE HAS RESEARCHED SEVERAL COMPLAINTS REGARDING THIS FAILURE AND STATED THAT VOLKSWAGEN IS AWARE, BUT DOES NOTHING TO RECTIFY THE ISSUE. ON SEPARATE OCCASIONS, THE CONTACT HAS BEEN STRANDED IN COLD WEATHER AND FACED NEAR DEATH EXPERIENCES DUE TO THE STALLING. THE VEHICLE HAS NOT YET BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 126,900.

NHTSA ID

10256580

Incident

Jan 11, 2009

Mileage

126,900 mi

TL*THE CONTACT OWNS A 1999 VOLKSWAGEN GOLF. THE VEHICLE HAS A RECALL NOTICE FOR THE O RING DEFECT. THE DEFECT CAUSES THE VEHICLE TO OVERHEAT, RESULTING IN ENGINE FAILURE. THE CONTACT STATED THAT THE VEHICLE RECEIVED THE 44K TREATMENT TO RECTIFY THE FAILURE AND NOW THE ENTIRE EXHAUST SYSTEM NEEDS TO BE REPLACED. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE CATALYTIC CONVERTER IS ALSO DEFECTIVE AND CAUSES THE MOTOR AND OTHER COMPONENTS TO OVERHEAT. THE CONTACT STATED THAT A LARGE QUANTITY OF SMOKE COMES FROM THE VEHICLE AND HE DOES NOT DRIVE IT DUE TO SAFETY CONCERNS. HE IS ALSO UNABLE TO SWITCH GEARS BECAUSE THE CLUTCH IS BURNED OUT. THE RECALL NUMBER, VIN, AND ENGINE SIZE WERE UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 72,000.

NHTSA ID

10212219

Incident

Dec 2, 2007

Mileage

72,000 mi

WINDSHIELD WIPER FAILURE. *TR

NHTSA ID

10209679

Incident

Oct 19, 2007

Mileage

86,000 mi

TL*THE CONTACT OWNS A 1999 VOLKSWAGEN GOLF. THE VEHICLE HAS DOUGLAS & LOMASON (19570R14) TIRES. WHILE DRIVING 65 MPH, THE CONTACT HEARD A LOUD NOISE COMING FROM THE VEHICLE. HE PULLED OVER, NOTICED A FLAT TIRE, AND REPLACED IT WITH A SPARE. THE DEALER STATED THAT THE CASE SEPARATED. THE FAILURE WAS DUPLICATED WITH BOTH FRONT TIRES AND THE REAR DRIVER SIDE TIRE. THE FAILURE MILEAGE WAS 124,000 AND CURRENT MILEAGE WAS 125,000.

NHTSA ID

10203636

Incident

Jul 1, 2007

Mileage

124,000 mi

Update to Volkswagen engine oil standards

Volkswagen Engine oil quality standards, update to attachments.

Engine oil quality standards, update to attachments.

Update model year applicability to include 2023.

Battery testing and charging using special tools VAS6161 & GRX3000VAS Charger. Updated to include additional model year applicability.

Update engine oil quality standard lists (attachments)