2017 Volkswagen Golf

On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Driving my 2017Golf the check engine light came on. The light was steady. I called my dealer and got it in for service. They report to me that the Thermostat housing needs to be replaced and oxygen sensors need replacing also. I just had the manifold replaced 6 weeks ago. I found on line that this is a common problem . Why isn’t this a Recall Repair?

NHTSA ID

11735790

Incident

Apr 28, 2026

My vehicle is subject to Safety Recall 20UF (Suction Jet Pump failure / Fire Risk). I have attempted to contact Pacific Volkswagen in Hawthorne, CA to schedule this safety-critical repair. On two separate occasions, upon mentioning that the call was regarding the 20UF recall, the dealership staff disconnected the call. This repeated 'recall avoidance' at Pacific Volkswagen is preventing me from remedying a known fire risk, and the dealership is effectively refusing to facilitate a federally mandated safety repair. I am concerned that the dealer is prioritizing paid service over safety-critical warranty work.

NHTSA ID

11712343

Incident

Jan 21, 2026

The contact owns a 2017 Volkswagen Golf. The contact stated that while the vehicle was parked and occupied, while attempting to depress the accelerator pedal, the vehicle independently accelerated and crashed into a parking lot barrier. The contact stated that none of the air bags deployed. There was no injury sustained. No medical attention was required. A police report was not filed. The contact stated that the vehicle was not diagnosed by a dealer or independent mechanic. The vehicle was towed to an Auto Body Shop. The manufacturer was not notified of the failure. The vehicle was not deemed a total loss. The contact related the failure to an article read online on Edmonds Auto Reviews. The approximate failure mileage was 96,000.

NHTSA ID

11696778

Incident

Apr 15, 2023

Mileage

96,000 mi

I have been having rear cameras for quite some time. The first time I took it to the dealer they could not find any issues and told me to take pictures. I did, plenty of them. Monday 10-27 2025 I took it in again for the gas tank issue and camera issue. Being disabled due to serious spine issues I had to minimize waiting time. The dealer preformed a radio update per 91-19-02 & MIB2 composition & discovered media info system malfunctions. I am currently under VW extended warranty 10 year 100000 mi but they charged me $225.00 for the update. This is exactly the same issue for recall #91SB. Apparently the issue goes back further than the recall, I believe that these issues were swept under the rug. Any help would be appreciated. [XXX] VW [XXX] [XXX] [XXX] [XXX] I believe that the recall is the tip of a very large problem INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11696492

Incident

Oct 27, 2025

In December 2021, my fuel gauge read empty, so I stopped at a gas station near the Honolulu Airport and VW Honolulu dealership. As I was pumping the gasoline, it began overflowing from the top of the tank, although I had just started pumping. I immediately removed the pump which is when gas began leaking out of the bottom of the tank, like a faucet. Luckily, I was right by the dealership, and was able to make it there without anything dangerous happening. After assessing my vehicle, the VW technicians said there was an internal issue with a faulty fuel tank. They said this issue was not something that I caused. Attached are the invoices and notes provided by the technicians. I paid $3,877 to get the problem fixed.

NHTSA ID

11689572

Incident

Dec 10, 2021

The component that failed, according to Volkswagen, is the rollover valve in the gas tank. This issue caused large amounts of gasoline to leak and pool from behind the rear passenger wheel well, creating a significant fire hazard and risk of harm. The vehicle was inspected by a Volkswagen service center as part of the repair process, whereupon the Volkswagen service center documented that the issue was caused by a faulty rollover valve in the gas tank. There were no warning lamps, messages, or other symptoms prior to the failure.

NHTSA ID

11622253

Incident

Aug 10, 2022

I had a suction jet pump recall due on the car. I took it to the dealer to fix. Mind you, I have never had an issue with this car ever. Now about a week later from the car being in the shop I get an engine malfunction light that comes on due to the evap system. Vw dealership of cool springs has not worked with me on this at all and it is frustrating to say the least.

NHTSA ID

11616046

Incident

Sep 20, 2024

The water pump in these vehicles are known defects, with class actions resulting. My water pump has failed at less than 70k miles. This results in engine overheating and possible failure. Luckily I was able to get the car off the road.

NHTSA ID

11612975

Incident

Sep 2, 2024

This is a notice for software changes with the ODIS diagnostic program to correct the communication during vehicle programming function: A software fix is needed to correct the issue: DA 0019 - Hotfix 12-V battery test(s) – No battery diagnosis - Inconclusive test result.

Oil Consumption Measurement and Electronic Oil Consumption Measurement

Lubricating engine components before reassembly.

Instruction, how to lubicate engine before initial start.

Inquiries

Volkswagen Engine Oil Standards