2013 Audi S6

On March 29, 2021, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE 21-009) after the agency received 58 reports alleging engine stalling in 2013-2016MY Audi vehicle models A8, S6, S7, S8 & RS7 equipped with the 4.0L, twin-turbocharged engine. Complainants reported the vehicles would stall with no warning while driving at highway or city traffic speeds. Several of the complainants alleged an inability to restart. The complaints alleged the major contributing factor to the engine stalling was the failure of the turbochargers. The complaints cited the turbocharger failure was a result of oil starvation due to a clogged oil strainer in the turbocharger oil supply line.The location of the oil strainer in the turbocharger oil supply line is in the inner valley of the engine. It is not easily accessible, making servicing the component difficult. The oil strainer removes particles and carbon deposits from the oil before lubricating the turbochargers. Over time, if the debris is not removed from the oil strainer, it becomes clogged and prevents oil from flowing to the turbochargers. This causes the turbine bushings to run dry and overheat resulting in turbine shaft failure due to thermal stress.On April 04, 2022, PE21-009 was upgraded to an Engineering Analysis (EA22-001) to further assess the scope, frequency, and potential safety related consequences of the alleged defect. Volkswagen filed recall 22V-178 to replace the 30?m mesh oil strainer with a 90?m mesh oil strainer in the subject vehicles. VW introduced the larger mesh oil strainer into production in March of 2017 effecting the 2017-2018MY vehicles.ODI reviewed information from VW for vehicles that had the larger mesh installed in production. The data received showed, since the new oil strainer size of 90?m went into production for the 2017-2018MY, there has not been any reported incidents of turbocharger failures due to oil starvation or other failures that could be related to the larger screen mesh. In view of the recall being conducted by VW and lack of any detrimental side effect to the turbocharger caused by the larger mesh, ODI is closing this Engineering Analysis (EA). The agency reserves the right to take additional action if warranted by future circumstances.11502847,11506565,11494663,11488813,11486393,11480926,11479882,11476289,11466761 11464663,11463254,11460580,11460496,11458973,11458804,11457556,11454753,11452668 11452589,11452584,11452383,11452175,11452111,11451724,11451724,11450995,11450988 11449661,11447092,11443657,11442867,11440536,11440052,11439959,11438691,11436461 11435619,11433925,11433733,11432336,11431661,11431421,11429704,11429584,11428128 11426929,11424203,11423603,11423337,11422431,11421084,11420626,11420342,11419693 11418884,11418437,11418433,11418135,11417635,11417351,11416095,11414578,11414235 11414064,11413359,11413285,11413214,11407510,11407450,11406897,11406821,11406637 11406460,11406416,11406291,11406287,11406277,11406273,11406263,11406256,11406251 11406229,11406222,11406208,11406204,11406197,11406182,11406015,11404665,11404426 11404348,11403823,11403430,11403268,11402684,11399435,11397821,11396241,11394763 11391037

On March 29, 2021, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE) 21-009 after the agency received 58 reports alleging engine stalling in 2013-2016MY Audi vehicle models A8, S6, S7, S8 & RS7. The subject vehicles are equipped with 4.0L, twin-turbocharged engine. Complainants reported that the vehicles stall suddenly with no warning while driving on the highway or in city traffic. Several of the complainants alleged an inability to restart. The complaints allege the major contributing factor to the engine stalling is the failure of the turbochargers. The complaints further allege the turbocharger failure is a result of oil starvation due to a clogged oil strainer.The location of the oil strainer in the turbocharger oil supply line is in the inner valley of the engine. It is not easily accessible, making regular service difficult. The oil strainer removes dirty particles and carbon deposits from the oil before flowing to lubricate the Turbochargers. Overtime if the debris are not removed from the oil strainer, it clogs the strainer and prevents free flow of oil to the turbochargers and makes the turbine bushings to run dry and overheat which causes the turbine shaft to break due to thermal stress. In VW's response to ODI's Information Request letter, VW provided approximately 611 warranty claims with unique VINs, 70 Field Reports and 45 Consumer complaints. These reports allege engine stalling due to turbocharger failure similar to the NHTSA reports described above. To date, NHTSA has received approximately 98 allegations of stall due to turbocharger failures. The total of 824 reports shown in the table above eliminates duplicate reports received by both ODI and the manufacturer.This Preliminary Evaluation is being upgraded to an Engineering Analysis (EA) to further assess the scope, frequency, and potential safety related consequences of the alleged defect of engine stalling due to turbocharger failureThe ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers:11452589, 11452584, 11452383, 11450995, 11450988, 11449661, 11447092, 11442867 11440536, 11440052, 11439959, 11438691, 11436461, 11435619, 11431661, 11429704 11429584, 11426929, 11424203, 11423603, 11423337, 11421084, 11420626, 11420342 11418884, 11418437, 11418433, 11417635, 11417351, 11416095, 11414235, 11413359 11413214, 11413285, 11413133, 11407510, 11407450, 11407289, 11406821, 11406416 11406291, 11406277, 11406273, 11406256, 11406251, 11406229, 11406222, 11406204 11406197, 11406182, 11404665, 11404426, 11404348, 11403430, 11403268, 11399435 11397821, 11396241, 11394763, 11391037, 11388662, 11387166, 11377446, 11363283 11354107, 11344193, 11342497, 11342360, 11340302, 11325065, 11324163, 11322168, 11321144, 11318477, 11306754, 11279429, 11268109, 11256706, 11252723, 11246579 11234853, 11234714, 11231582, 11231013, 11230589, 11229484, 11222281, 11218822 11218749, 11217604, 11209168, 11209142, 11197149, 11191243, 11175842, 11170776 11164032, 11152418.

I was driving my Audi when I got transmission malfunction light on along with suspension fault and epc light and check engine light all together and the car wouldn’t go faster than 20 mph. Causing someone to rear end me and them fleeing . So not only was my car hit because of this but I had no driver to hold responsible for the damage

NHTSA ID

11715436

Incident

Jan 4, 2026

Was just driving down the highway at normal speed and my car lost all power, every like came up on the dash and disabled my power steering causing me to almost crash. Took it to the shop mechanic tells me the turbos failed due to oil screen and it will cost me $8,000 Not sure why they failed I have amazing service records on my car. This needs to be a recall.

NHTSA ID

11645758

Incident

Nov 2, 2024

the 2013 Audi 4.0T generation have a massive issue where the engine start leaking from the bottom of the crankcase where the block connects to it and to fix all these issues audi is asking a rebuild of the entire engine this issue is very common on the 2013 2014 2015 S6 S7 S8 with the 4.0T worldwide problem

NHTSA ID

11619889

Incident

Oct 11, 2024

All 2013 Audi S have a transmission issues where it cause the transmission to stop shifting or skips gears or clutch slips and Audi has not done anything about them This repair is expensive and millions of people experience this problem and Audi still won’t fix it

NHTSA ID

11530266

Incident

Jun 29, 2023

I noticed my car wouldn’t engage in reverse when shifted so I took it in for a transmission flush and it was performed and 2 days later I got a light on dash saying transmission overheating . And the car completely lost power while on freeway and went from 60 to 20 miles per hour and will not shift past first gear . So I took it back in to dealer paid diagnostic fee and then was told my transmission was bad and had to be replaced and was quoted a price of 15683$

NHTSA ID

11494663

Incident

Jul 21, 2020

The contact owns a 2013 Audi S6. The contact stated upon test driving the vehicle after an oil change, the independent mechanic diagnosed that the oil strainer was clogged and the turbine wheel was desegregated. The oil strainer and gasket, the PCV head gasket, and two turbochargers were replaced. Additionally, three consecutive oil changes were completed in order to flush the metal fragments from the turbocharger oil strainer. The vehicle was repaired. The contact later received notification of NHTSA Campaign Number: 22V178000 (Engine And Engine Cooling) which he associated with the failure. The dealer was not notified of the failure. The manufacturer was notified of the failure. The contact submitted a claim for reimbursement as the vehicle had been repaired prior to the safety recall but the manufacturer denied the claim. The failure mileage was approximately 55,000.

NHTSA ID

11478567

Incident

Sep 3, 2019

Mileage

55,000 mi

The Mfg defrayed some of the cost of replacing the two turbos but I was charged $5,607.06 on the repair on 9/24/20. The cause of the repair was do the mfg defect and they should pay 100% of the repair. The vehicle only had 42,040 miles at the time of the turbo failure.

NHTSA ID

11458804

Incident

Sep 24, 2020

Recently learned that my car broke down on my spouse in an extremely unsafe location due to turbo failure(s) probably caused by the turbo oil inlet screen. She was on a busy street when the car shut off on her putting her in an extremely unsafe situation to move the car and wait for tow truck service. The car is still with the Audi dealership for repairs but has been confirmed that this is the likely incident and fixing it will likely prevent further issues. This car has only been to Audi certified technicians at dealerships for the entire time I've owned the car and I was never notified that this is a common occurrence in these models with the turbo. Numerous online forums are dedicated to discuss the common occurrence when researching this particular issue going back a few years, mostly astounding a recall hasn't been issued. There was no warning lamp for the issue to warn us of the impending failure.

NHTSA ID

11447092

Incident

Jan 7, 2022

This bulletin provides a statement regarding the bottleneck of supply for VW approved oil types VW 504.00 and VW 507.00.

This bulletin provides information when there is a film/visible rings on the clear glass cover of the headlight when the dipped beam is switched on.

This bulletin provides information when there are noises from the area around the instrument cluster.

This bulletin provides informaiton when the transmission warning message appears in the cluster; P074100 stored in the TCM.

This bulletin provides informationwhen noises/vibration are detected from front of vehicle in dynamic mode.

This bulletin provides informaiton when the engine is not running smoothly, misfiring.