2005 BMW 525I

BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.

IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).

I am encountering persistent issues with my 2005 BMW 525i. Despite having replaced several critical components, including the ignition coils, spark plugs, mass air flow sensor, and throttle body sensors, the vehicle continues to experience performance problems, specifically failing to advance beyond the fourth cylinder when driving uphill. After conducting numerous diagnostic tests, I have concluded that there may be an air leak in the intake manifold. Additionally, after prolonged use under these conditions, the positive battery cable from the trunk has shown signs of overheating, evidenced by smoke, which I suspect is related to repeated uphill driving. While the vehicle performs adequately on flat surfaces, it exhibits hesitation and jerking once it surpasses the fourth cylinder.

NHTSA ID

11621558

Incident

Feb 12, 2024

The tail-lights have gone out creating safty issue and number of warning lights to come up on the dashboard. Dealership stated that the wiring harness around ground wire has melted. They stated that this is same issue that is mentioned under NHTSA Campaign Number: 13V407000. The service advisor said that his issue would be fixed by same service bulletin SIB 630613, however my date range is not included in the recall. I would like to report an issue to open a case and extend the recall to include all E60 models from 2004 to 2010. Would you please open an investigation into this matter and contact me for additional information and photos.

NHTSA ID

11588889

Incident

May 14, 2024

I PURCHASED THIS BMW 525I USED FROM A PERSON THAT OBTAINED IT FROM A WHOLESALE DEALER, IT HAD SOME MINOR FRONTEND DAMAGE FROM A FENDER BENDER (BROKEN GRILL, DING TO HOOD) SHOWING 107900 MILES. EVERYTHING ELSE CHECKED OUT. I FEW MONTHS LATER I NOTICED A SLIGHT CHANGE IN TRANSMISSION SOUND, BUT IT MIGHT HAVE BEEN DUE TO THE COLD TEMPERATURES HERE IN WISCONSIN. A COUPLE OF DAYS LATER WHILE JUST FINISHING GOING UP A SLIGHT STRAIGHT INCLINE AT AROUND 45MPH THE TRANSMISSION DROPPED DOWN INTO LIMP DOWN MODE AND A TEMPORARY NOTICE CAME UP ON THE COMPUTER SCREEN INDICATING A TRANSMISSION PROBLEM. STOPPING AND RESTARTING THE ENGINE CLEARED THE PROBLEM, THE NEXT DAY NEAR THE SAME SPOT IT OCCURRED AGAIN. I ASSUMED THE TRANSMISSION MIGHT BE LOW ON FLUID BUT LOOKING ONLINE BMW INDICATED THIS IS A NO SERVICE TRANSMISSION BUT THAT IT IS POSSIBLE TO CHECK THE FLUID LEVEL BY ACCESSING A PLUG UNDER THE CAR. WHEN A SERVICE TECH CHECKED HE SAID THE FLUID LEVEL WAS NORMAL BUT SMELLED BURNT. HE RECOMMENDED AGAINST ANY SERVICE IN THAT IT LIKELY WOULD RESULT IN FASTER COMPLETE FAILURE. THE PROBLEM HAS NOT REOCCURRED AND NO CODES SHOW IN THE SYSTEM FILE, IN THAT BMW INSISTED ON NO PROVIDING A METHOD TO CHECK THE TRANSMISSION FLUID, THEY ASSUMED THE LIABILITY FOR FAILURE IF REGULAR MAINTAINANCE (TRANSMISSION FLUSH) COULD HAVE PREVENTED THIS FAILURE.

NHTSA ID

11174764

Incident

Dec 28, 2018

Mileage

112,000 mi

MY CAR HAS A GAS SMELL EVEN IN THE INSIDE SMELLS LIKE GAS

NHTSA ID

11151790

Incident

Apr 20, 2018

AFTER HAVING AN INDEPENDENT MECHANIC SCAN MY VEHICLE WITH AN ADVANCED SCAN TOOL, THE ERROR THAT CAME UP WAS FOR THE "PASSENGER SEAT OCCUPANCY SENSOR". THIS FAULT HAS CAUSED BOTH THE AIRBAG AND SEATBELT LIGHT TO REMAN ILLUMINATED CONTINUOUSLY. THE FIRST TIME IT HAPPENED, I HAD THE CODE RESET. BUT AFTER A PERSON SAT IN THE PASSENGER SEAT, THE ERROR CODE CAME BACK WITH THE SAME FAULT CODE.

NHTSA ID

11061337

Incident

Oct 1, 2017

Mileage

82,000 mi

FRONT PASSENGER SEAT OCCUPANCY SENSOR HAS FAILED. REAR LEFT HAND BRAKE/BACKUP LIGHT IS PROBLEMATIC AND INTERMITTENTLY WORKS, USUALLY ONLY SHOWS UP ON CAR'S DASHBOARD WHILE IN REVERSE, BUT SOMETIMES WILL STAY ON-SCREEN DURING DRIVING. FRONT ASHTRAY OUTLET/CIGARETTE LIGHTER DOESN'T WORK.

NHTSA ID

10970386

Incident

Jan 1, 2017

Mileage

140,000 mi

PASSENGER RESTRAINT SYSTEM FAULT.

NHTSA ID

10968236

Incident

Feb 2, 2017

SUNROOF DRAIN CLOGGED INTO TRUNK CAUSING FIRE IN BATTERY COMPARTMENT AND SPARE TIRE AREA. VEHICLE WAS STATIONARY IN SHOP AFTER NOT BEING RUN FOR HOURS.

NHTSA ID

10948007

Incident

Dec 12, 2016

Mileage

114,000 mi

The basic conditions for initializing the power windows are not met.

The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.

Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (- 0x33E) missing, receiver DME, transmitter TFE

Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle. Depending on the vehicle’s equipment and settings, no acoustic or optical confirmation (folding the mirrors/blinking confirmation) is noticeable. Additionally, the red anti-theft alarm LED in the interior mirror does not briefly flash every 2 seconds, indicating the alarm is armed.

Diagnosis of Compound Brake System Complaints in M Vehicles: 1. Visible cracks are caused by high thermal stresses during rapid heating and cooling of the brake discs. Braking from high speed with cold brake components (less than 212 degrees F) increases the likelihood of cracks to form.

Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle "discharged battery" complaints. In order to properly repair the vehicle the first time in the workshop, it is very important that the diagnostic test plans are performed to completion, with all results taken into consideration. Without performing the energy diagnosis test plan, the root cause of the discharged battery cannot be identified. This increases the chances of a repeat repair.