2009 BMW K1300 GT

ODI began investigating this issue after owners of model year (MY) 2004-2011 R-series BMW motorcycles reported incidents of pressurized fuel leakage from the fuel pump flange.Some owners first became aware of the problem when their pant leg was fuel-soaked.Prior to opening our initial investigation on November 16, 2012, BMW had concluded that the small number of warranty claims and owner reports did not indicate the existence of a safety defect trend.However, during the course of responding to our information requests, BMW re-examined its data and decided to conduct a recall (13V-617) of the subject motorcycles.In conducting recall 13V-617, BMW voluntarily expanded the scope of affected vehicles from ODI'soriginal scope, MY2005-2008 R-series motorcycles, to include the primary and auxiliary fuel pumps on all MY 2005-2011 R-series, MY 2005-2011 K12&13 models, MY 2010-2011 RR models, and the MY 2012 K1600 motorcycles.The total number of motorcycles subject to this recalled is 50,184.The 55 reports cited in this investigation can be viewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following complaint identification numbers:10485789,10449393,10521322,10475150,10435325,10493015,10471642, 10448216,10488899,10356156,10433733,10442023,10492342,10435968, 10492961,10504324,10485882,10433013,10453738,10474390,10417320, 10485276,10444876,10508150,10485807,10492118,10491835,10425962, 10430734,10488652,10485274,10493320,10522421,10399423,10443840, 10448325,10490417,10485452,10433589,10467136,10420291,10503806, 10532145,10523763,10523626,10425514,10354202,10437222,10444742, 10454834,10532172,10487624,10435984,10452476, 10485337

THE SUBJECT MOTORCYCLES MAY STALL DUE TO RESTRICTED AIRFLOW WITHIN THE AIR INTAKE SYSTEM DURING LOW RPM ENGINE OPERATION, TYPICALLY WHILE SHIFTING AND/OR DECELERATING.BMW IS RECALLING THE SUBJECT MOTORCYCLES (09V-471) TO UPDATE THE ENGINE MANAGMENT SOFTWARE.ADDITIONALLY, BMW WILL INCLUDE MODEL YEAR 2010 K300S/GT MODELS.WITH THAT RECALL, SUBMITTED IN LIEU OF RESPONDING TO OUR INFORMATION REQUEST, THIS PE IS CLOSED.

I purchased this 2009 BMW K1300GT used from a dealer 3 weeks ago. He only let me do a short test drive around the block and it ran fine. I purchased it and began riding it daily to and from work, 48 miles round trip. There are 6 lights and 4 Stop sighs on my route. If I do a slow roll through a stop it comes close to stalling. If there are several cars ahead of me at a stop sign, or I hit a red light and have to wait awhile or sit through three lights at traffic hour, it stalls while I'm waiting. This has happened many times. Yesterday during traffic hour I was at a red light that cycled three times until I got through it. The bike stalled five times there. One time it stalled at a red light. Just before it turned green it stalled again, turning my rear lights off. There was a full size truck rolling up behind me very fast. Since it stalled out and the lights were off, it appeared to him that I was moving. At the last second he slammed on his brakes, I started the bike and quickly rode onto the shoulder and he drove by me still skidding. I would have been killed! The dealer never said a word about this well known and highly documented issue with this year, make and model of this BMW motorcycle.

NHTSA ID

11459305

Incident

Apr 1, 2022

ENGINE STALLS AND / OR LOSES POWER IN HOT WEATHER. I HAVE HAD NUMEROUS STALLING EPISODES WITH THIS BIKE. IT WILL STALL AFTER BEING IN STEADY CRUISE FOR 30 MINUTES AT 4000 RPM. IT ALSO STALLS REPEATEDLY IN VERY HOT WEATHER (95-100 DEGREES) AND WILL NOT RESTART(SITTING STATIONARY AT A TRAFFIC LIGHT WHEN TRYING TO START OFF AFTER LIGHT CHANGES). IF IT DOES RESTART IN THESE CONDITIONS, IT DOESN'T RESPOND TO THROTTLE OPENING AND WILL ONLY REV TO 2000-3000 RPM AND WILL BOG DOWN IF THROTTLE IS OPENED FURTHER. I HAVE HAD INSTANCES WHERE THE ENGINE WON'T STAY RUNNING AFTER START( ENGINE STARTS AND RUNS FOR APPROXIMATELY 10-15 SECONDS AND THEN DIES).

NHTSA ID

11337528

Incident

Jun 10, 2020

Mileage

31,100 mi

STALLS WHEN CLUTCH IS ENGAGED AND ENGINE SHOULD COME TO IDLE. THE TYPICAL SITUATION IS WHEN PREPARING TO STOP FOR AN INTERSECTION OR OTHER ROAD CONDITION THAT WOULD CALL FOR THE ENGINE TO BE TEMPORARILY DISENGAGED FROM THE TRANSMISSION. THIS HAPPENS ON EVERY RIDE. THE DEALER SERVICE DEPARTMENT OPINED "THEY ALL DO THAT".

NHTSA ID

10983006

Incident

Apr 27, 2017

Mileage

64,000 mi

TL* THE CONTACT OWNS A 2009 BMW K 1300 GT MOTORCYCLE. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT ATTEMPTED TO SHIFT FROM THE SECOND TO THIRD GEAR, BUT THE GEAR SHIFT FRACTURED. THE CONTACT PULLED OVER AND SUBSEQUENTLY TOWED THE MOTORCYCLE TO A LOCAL DEALER. THE TECHNICIAN STATED THAT THE FAILURE WAS UNUSUAL AND WAS UNABLE TO DIAGNOSED THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 27,700.

NHTSA ID

10920491

Incident

Oct 26, 2016

Mileage

27,700 mi

ENGINE STOPS INTERMITTENTLY WHILE DRIVING STOP AND GO IN CITY TRAFFIC UNDER 10 TO 15 MILES PER HOUR. THE PROBLEM STARTED IN 2010. BMW HAS NOT BEEN ABLE TO CORRECT THE PROBLEM AFTER 4 ATTEMPTS. THE ENGINE STILL STOPS. I KEEP COMPLAINING TO BMW. TOLD TO GET LOST.

NHTSA ID

10898138

Incident

Jun 15, 2016

Mileage

40,000 mi

TL* THE CONTACT OWNS A 2009 BMW K1 300 GT. WHILE DRIVING 15 MPH, THE VEHICLE STALLED. THE MOTORCYCLE WAS REPAIRED THREE TIMES PER NHTSA CAMPAIGN NUMBER: 09V471000 (ENGINE AND ENGINE COOLING); HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000.

NHTSA ID

10887826

Incident

Jan 23, 2010

Mileage

40,000 mi

THE ENGINE STOPS WHILE DRIVING. THE PROBLEM HAS BEEN REPORTED TO BMW DEALERS 5 TIMES IN THE PAST 5 YEARS. I BARELY DROVE THE BIKE IN 2014. 1/23/2010 6.510 KM REPORTED TO BMW OF OKLAHOMA WORK DONE PROGRAMMING CONTROL UNIT OF ENGINE MANAGEMENT SYSTEM. REPAIR DONE UNDER WARRANTY. 7/29/2011 33.234 KM REPORTED TO BMW ASHEVILLE SAME REPAIR AS FIRST TIME. 6/22/2013 65.734 KM REPORTED TO BMW ASHEVILLE SAME REPAIR AGAIN 7/8/2015 38493 MILES REPORTED TO BMW MONTREAL. RECOMMENDED REPLACE BOTH STEPPER (IDLE) MOTOR AND AIRBOX AT A COST OF OVER $1,000 7/9/2015 39000 MILES REPORTED TO BMW MECHANICSBURG, PA. SAME RECOMMENDATION AS BMW OF MONTREAL. I WAS TOLD THAT THE DEALER HAS SEEN THIS PROBLEM ON SIMILAR BIKES AND THAT THEIR RECOMMENDATION WAS THE SOLUTION. IN ADDITION, THEY STATED THAT THE PRIOR MODEL TO MINE THE K1200 HAD THE SAME PROBLEM AND THAT BMW HAD ISSUED A MECHANICAL ALERT AT THE TIME BUT NO ALERT HAD BEEN ISSUED FOR MY BIKE. I CALLED BMW USA TO COMPLAIN. I WAS DISMISSED WITH A RESPONSE THAT THE BIKE HAD PASSED THE WARRANTY PERIOD - NOT ACCEPTABLE. THE BIKE HAS HAD THE SAME PROBLEM FROM DAY ONE. BMW IS IGNORING THE PROBLEM WITH A SERIOUS SAFETY CONCERN. THE BIKE HAS A SERIOUS PROBLEM: A MOTORCYCLE ENGINE SHOULD NOT STOP WHILE IT IS BEING DRIVEN. WHEN DRIVING UNDER 15 MPH IN CITY TRAFFIC, THE ENGINE HAD A TENDENCY TO STOP. THE ENGINE STALLING HAPPENED INTERMITTENTLY AND THE ENGINE WOULD START RIGHT UP AFTERWARDS. UPDATED 08/10/16.*JB *JS *TR

NHTSA ID

10734979

Incident

Jan 23, 2010

Mileage

6,510 mi

DOWNSHIFTING THE MOTORCYCLE STALLS FREQUENTLY UPON SLOWING AND PULLING IN THE CLUTCH. USUALLY THIS OCCURS AT DECELERATION IN SECOND OR FIRST GEAR. ONE CAN SEE THE RPM DIP BELOW THE NORMAL IDLE SPEED AND THEN THE BIKE STALLS. THIS IS QUITE DANGEROUS AS IT OCCURS IN NORMAL RIDING CONDITIONS AND OCCURS MULTIPLE TIMES IN ONE RIDE. RECENTLY IT OCCURRED IN HEAVY TRAFFIC AND ONLY MY QUICK ACTION AVOIDED AN ACCIDENT. I TRIED EVERYTHING THE DEALER RECOMMENDED, FUEL ADDITIVES ETC.. NOTHING WORKS - ALMOST TOO DANGEROUS TO RIDE. *TR

NHTSA ID

10631640

Incident

Jun 4, 2013

Mileage

3,500 mi

The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.

BMW Motorrad USA has become aware of a potential durability issue with the film type fuel level sender “Fuel Strip” equipped on certain model year 2005 to 2013 R and K series motorcycles.

One of the following situations can occur when connecting to BN2000 motorcycles: 1. The installed control units cannot be found when reading out with ISTA. 2. Control units initially communicate after connecting to the vehicle, but communication later stops.

Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle "discharged battery" complaints. In order to properly repair the vehicle the first time in the workshop, it is very important that the diagnostic test plans are performed to completion, with all results taken into consideration. Without performing the energy diagnosis test plan, the root cause of the discharged battery cannot be identified. This increases the chances of a repeat repair.

Oil leak at theseal between the cylinder head cover and cylinder head on the right in the direction of travel. Due to retrofit of chain gauide which prevents skipping of the timing chain.

Bluetooth issues between Navigators, mobile phones, communication and audio systems.