RoadVitals

1996 BMW M3

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
1
Latest Jan 24, 2000
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
1
Latest Aug 19, 1997
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains 1 NHTSA owner-reported complaint for the 1996 BMW M3, most frequently naming the fuel system category. 1 safety recall has been issued covering this model year; and 9 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Fuel system1100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

1 campaign cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
97V131000

VEHICLE SPEED CONTROL

Aug 19, 1997
410,000 units potentially affected
The defect: THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
The risk: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
The remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
BAYERISCHE MOTOREN WERKEView on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

Fuel system
Filed Jan 24, 2000

I OWN A 1996 BMW M3. FOUR TIMES SINCE IT WAS NEW THE FUEL GAUGE HAS FAILED, AND EACH TIME FUEL SENDERS WERE REPLACED TO GET IT WORKING AGAIN. AS YOU'LL SEE, THE PROBLEM IS WIDESPREAD AMONG BMWS, BUT ONLY IN CALIFORNIA, AND BMW CAN'T OR WON'T SOLVE THE PROBLEM. MY DEALERSHIP'S SERVICE MANAGER (LARRY GORDON) TOLD ME THAT THE PROBLEM IS WELL KNOWN TO BMW DEALERSHIP SERVICE MANAGERS, BECAUSE THEY HAVE COMPLAINED TO BMW ABOUT IT REPEATEDLY, BUT THAT BMW WILL NOT ADDRESS THE PROBLEM. HE SAID THERE IS AGREEMENT THAT THE PROBLEM ONLY AFFECTS CARS IN CALIFORNIA, AND THAT IT IS CAUSED BY SOMETHING IN CALIFORNIA'S FUEL THAT CAUSES THE REPLACED PARTS TO FAIL VERY PREMATURELY. HE SAID BMW WILL NOT SOLVE THE PROBLEM BECAUSE IT ONLY AFFECTS CARS IN CALIFORNIA, AND THAT HE SUSPECTS THAT OTHER COMPONENTS COULD ALSO BE ADVERSELY AFFECTED BY OUR FUEL. LAST WEEK MATT SILVERSTEIN (BMW CUSTOMER SERVICE, 1-800-831-1117, EXT. 35421) TOLD ME, AFTER CHECKING HIS COMPUTER, THAT MY COMPLAINT WAS FULLY RESOLVED BY MY DEALER -- BMW OF SAN DIEGO. WHEN I SAID THAT WAS NOT TRUE -- THAT I WAS DEFINITELY NOT SATISFIED, HE TOLD ME THAT CUSTOMERS MAY ONLY GET COMPLAINTS RESOLVED THROUGH THEIR DEALER, WHO IN TURN COULD CONTACT THEIR ZONE REP. I TOLD HIM THAT MY DEALER HAD GOTTEN NOWHERE WITH BMW IN RESOLVING THIS -- THAT AS FAR AS HE AND OTHER SERVICE MANAGERS KNEW, IT WAS DUE TO AN INCOMPATIBILITY WITH CERTAIN BMW PARTS AND CALIFORNIA'S FUEL. HE REFUSED TO HELP ME. I THEN CONTACTED THE CLARK HOWARD CONSUMER WEBSITE BY E-MAIL. SOMEONE RESPONDED WITH THIS MESSAGE: "SENDING UNIT (AN ELECTROMECHANICAL DEVICE LOCATED INSIDE THE FUEL TANK) IS A POTENTIAL SAFETY DEFECT. REPORT THEM TO THE NHTSA." CAN YOU HELP ME? *AK

NHTSA ID
717802
Incident
Jun 16, 1998

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

B340714

SERVICE BRAKES, HYDRAULIC

Functional noises (squealing/honking) when braking shortly before the vehicle comes to a stop. CAUSE Material-

SIB-33-01-02

SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY

BMW: A GRINDING NOISE IS COMING FROM THE DIFFERENTIAL DURING SLOW CORNERING. WHEN TURNING A SLIP/STICK EFFECT IS CREATED ON THE LINING AND STEEL DISCS INCORPORATED IN THE DIFFERENTIAL CLUTCH CAUSES A GRINDING NOISE. *RM

SI-B11-07-09

ENGINE AND ENGINE COOLING; ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS

BMW: THERMOSTAT HOUSING INSPECTION. THE RETAINING SPRINGS OF THE THERMOSTAT HOUSING QUICK RELEASE COUPLINGS FOR THE COOLANT HOSES MAY NOT BE LOCKED CORRECTLY. THIS SITUATION MAY RESULT IN A COOLANT LEAK. MODELS AFFECTED ARE M3 SEDAN (E90), COUPE (92), AND CONVERTIBLE (393). NO MODEL YEARS LISTED. *PE

120299

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

CUSTOMER MAY COMPLAIN OF ENGINE RUNNING ROUGH ON COLD START. *TT

12 10 97

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

SUBJECT ON VOLUNTARY EXHAUST EMISSION SERVICE ACTION NO. 98E-A01. *YC *JN

36 01 98

TIRES

SUBJECT PERTAINING TO MICHELIN PILOT SX MXX3 TIRES IN 235/40 ZR 17 AND 225/45 ZR 17 SIZES. *YC

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

BMW M3 by model year
YearComplaintsRecallsInvestigationsIssue Index
2026000—
2025200—
2024000—
2023110—
2022100—
2021330—
2018800—
2017320—
2016530—
2015430—
2014010—
2013132153.8
2012631—
2011314149.2
2010154151.3
2009455149.6
2008825155.2
2007031—
2006145249.5
2005123447.2
2004313459.0
2003545262.7
2002405257.0
2001144046.1
2000020—
1999111155.0
1998141042.5
1997192049.9
1996Viewing110—
1995124054.6
1994010—
1993011—
1992011—
1991011—
1990010—
1989010—
1988210—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.