2006 BMW M3

The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field failures was found in vehicles produced by these five additional manufacturers.Nonetheless, at ODI's insistence, all 10 vehicle manufacturers initiated a regional recall within approximately two weeks of the opening of the investigation.The regions recalled initially included Florida, Puerto Rico, Hawaii, and the U.S. Virgin Islands, areas with high absolute humidity and climatic conditions believed to be a significant factor in the inflator ruptures.As part of the recall actions, inflators removed from remedied vehicles are to be returned to Takata for testing.Takata's initial test results on passenger inflators from remedied vehicles indicated a much higher than anticipated rupture frequency for inflators returned from Florida.Accordingly ODI requested all 10 manufacturers expand the regional recalls for passenger inflators to include other geographic areas where high absolute humidity conditions exist, including the Gulf States and other coastal areas.Takata's testing of the passenger inflators to date continues to indicate this geographic area as having the highest risk, with no ruptures occurring from inflators returned from outside the expanded recall regions.During PE14-016 four additional passenger inflator field events occurred, all in vehicles from the same expanded geographic region.Also during PE14-016 four additional driver inflator field events occurred including two in vehicles from regions not known for high absolute humidity, specifically California and North Carolina.Accordingly, ODI requested all five of the affected vehicle manufacturers currently using the subject Takata driver inflators expand to nationwide recalls.Significantly, neither of the affected vehicle manufacturers or Takata provided any explanation to account for these two driver air bag inflator ruptures outside the area of high absolute humidity.Takata testing of returned driver inflators indicates a lower rupture frequency as compared to passenger inflator testing.All test ruptures reported by Takata to date have occurred on inflators returned from high absolute humidity areas.The investigation now includes all manufacturers and vehicles known to be affected at this time.ODI's investigation will focus on, among other things, root cause analysis, other potential defect consequences, identification of affected vehicles scope, and adequacy of the remedy.The five ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10537899, 10568848, 10585224, 10605877, 10651492

The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field failures was found in vehicles produced by these five additional manufacturers.Nonetheless, at ODI's insistence, all 10 vehicle manufacturers initiated a regional recall within approximately two weeks of the opening of the investigation.The regions recalled initially included Florida, Puerto Rico, Hawaii, and the U.S. Virgin Islands, areas with consistently high absolute humidity and climatic conditions believed to be a significant factor in the inflator ruptures.As part of the recall actions, inflators removed from remedied vehicles are to be returned to Takata for testing.Takata's initial test results on passenger inflators from remedied vehicles indicated a much higher than anticipated rupture frequency for inflators returned from Florida.Accordingly, ODI requested all 10 manufacturers expand the regional recalls for passenger inflators to include other geographic areas where high absolute humidity conditions exist, including the Gulf States and other coastal areas.Takata's testing of the passenger inflators to date continues to indicate this geographic area as having the highest risk, with no ruptures occurring from inflators returned from outside the expanded recall regions.During PE14-016, four additional passenger inflator field events occurred, all in vehicles from the same expanded geographic region.Also during PE14-016, four additional driver inflator field events occurred including two in vehicles from regions not known for high absolute humidity, specifically California and North Carolina.Accordingly, ODI requested all five of the affected vehicle manufacturers currently using the subject Takata driver inflators expand to nationwide recalls.Significantly, neither of the affected vehicle manufacturers or Takata provided any explanation to account for these two driver air bag inflator ruptures outside the area of high absolute humidity.Takata testing of returned driver inflators indicates a lower rupture frequency as compared to passenger inflator testing.All test ruptures reported by Takata to date have occurred on inflators returned from high absolute humidity areas.The PE is now closed/upgraded to an Engineering Evaluation (EA15-001) to include all manufacturersand vehicles known to be affected at this time.ODI's EA investigation will focus on, among other things, root cause analysis, other potential defect consequences, identification of affected vehicles scope, and adequacy of the remedy.The recalls related to this PE are: 14V343, 14V344, 14V348, 14V351, 14V353, 14V655, 14V700, 14V701, 14V752, 14V763, 14V770, 14V773, 14V787, 14V802 and 14V817.The number of vehicles affected are an estimate since some vehicles may have both the driver and passenger side inflators recalled. The five ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10537899, 10568848, 10585224, 10605877, 10651492

FIRESTONE FIREHAWK INDY 500 TIRE FAILED ON SIDEWALL

NHTSA ID

11415304

Incident

May 1, 2021

Mileage

65,000 mi

THE SMG TRANSMISSION INTERMITTENTLY COMES OUT OF GEAR IN ANY SITUATION AND IS VERY DANGEROUS WHEN IN HEAVY TRAFFIC AND/OR ON A HIGHWAY AND LOOSE ALL POWER. I HAVE HAD SEVERAL CLOSE CALL ACCIDENTS AT HIGH SPEEDS. I HAVE READ MANY ARTICLES STATING THE SAME ISSUE WITH MANY OWNERS FOR THIS TYPE OF TRANSMISSION WITH A POSSIBLE DEFECTIVE HEAT SENSOR ON THE HYDRAULIC PUMP. BMW REFUSES TO RECOGNIZE THIS IS A FACTORY DEFECT AND FORCING OWNERS TO PAY OUT OF POCKET $3000 TO $4000 FOR A PUMP REPLACEMENT WITHOUT A GUARANTEE OF FIXING THE ISSUE. I AM STUCK WITH AN UNSAFE CAR AND CANNOT SELL IT THIS WAY.

NHTSA ID

11084684

Incident

Nov 15, 2017

Mileage

104,000 mi

YESTERDAY (01/06/17) - WHILE DRIVING IN MOTION, 2 SIDE AIRBAGS SPONTANEOUSLY EXPLODED, THROWING LOOSE PLASTIC MATERIAL INTO THE CABIN AND INTO MY FACE. CABIN FILLED WITH SMOKE AND BURNING SMELL. I PULLED THE CAR TO THE SIDE OF THE ROAD AND TURNED OFF ENGINE FOR SMOKE TO DISAPPEAR. I AM GOING TO TAKE MY CAR TO BMW DEALER TOMORROW MORNING FOR EVALUATION

NHTSA ID

11060996

Incident

Jan 6, 2018

Mileage

131,000 mi

THIS LETTER IS IN REFERENCE TO TWO MICHELIN PILOT SPORT A/S 3+ 255/35ZR19 96Y TIRES WHICH BOTH FAILED WITHIN 1,130 MILES OF EACH OTHER FROM IDENTICAL FAILURES. THESE TWO FAILURES WERE ON THE INTERIOR SIDEWALL OF THE TIRES. THESE TWO TIRES WERE PURCHASED AND INSTALLED ON THE SAME DAY, SEPTEMBER 15, 2016, BY A DEALER. THE CAR HAD 104,775 MILES ON IT AT THE END OF THIS SERVICE. ON TUESDAY, NOVEMBER 21, WHILE DRIVING TO OHIO FOR THANKSGIVING HOLIDAY I EXPERIENCED A COMPLETE FAILURE OF THE DRIVERS SIDE REAR TIRE (ONE OF THE ABOVE PILOT SPORT TIRES) AT HIGHWAY SPEED AT 121,801 MILES. THE TIRE SEPARATED FROM THE INTERIOR SIDEWALL COMPLETELY. ON DECEMBER 8, 2017, AT 122,934 MILES THE OTHER MICHELIN PILOT SPORT TIRE FROM THE ABOVE SET ALSO FAILED. WHILE IN THE PARKING LOT I HEARD THE PASSENGER REAR TIRE VENTING AIR AND IT QUICKLY WENT FLAT. THE INTERIOR SIDEWALL HARD A LARGE CRACK CIRCLING ALMOST HALF THE TIRE. THESE TWO FAILURES OCCURRED ONLY 1,130 MILES APART IN THE SAME PART OF THE TIRE. THESE TWO TIRES HAD 17,026 AND 18,159 MILES RESPECTIVELY, FAR UNDER THE WARRANTED LIFE AND THE TYPICAL LIFE. THE SECOND FAILURE WAS ACKNOWLEDGED BY MICHELIN IN A CASE I OPENED BASED ON AN EVALUATION OF THE TIRE BY A MICHELIN AUTHORIZED DEALER. MICHELIN HAS NOT ACKNOWLEDGE THE FIRST FAILURE BECAUSE I NO LONGER HAVE THE TIRE.

NHTSA ID

11056768

Incident

Nov 21, 2017

Mileage

121,801 mi

TL* THE CONTACT OWNS A 2006 BMW M3. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 14V428000 AND 15V318000 (AIR BAGS). THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED THE LOCAL DEALER (ADVANCED VALENCIA BMW, 23435 VALENCIA BOULEVARD, VALENCIA, CA 91355) AND WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND DID NOT ASSIST. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

11035873

Incident

Jul 14, 2014

TAKATA RECALL: YOUR SITE IMPROPERLY SHOWS NO RECALLS WHEN VIN USED, AND CONFUSES 2006 M3 (E46) WITH THE 2006 3 SERIES SUCCESSOR (E90?), EVEN THOUGH THE RECALL NOTICE RCRIT-14V428-8638 SHOWS "MODEL YEAR 2000-2006 BMW 3 SERIES (E46) - INCL-M"

NHTSA ID

11000038

Incident

Jun 19, 2017

Mileage

40,488 mi

DRIVING APPROXIMATELY 20-30MPH ON LOCAL STREET IN A STRAIGHT DIRECTION. DRIVER-SIDE, SIDE AIRBAG DEPLOYED WITHOUT WARNING. NO PRIOR INSTRUMENT LIGHTS WERE ON. NEVER HAD ANY AIRBAG LIGHTS ON IN THE HISTORY OF OWNING THE VEHICLE. REPLACED PASSENGER SIDE AIRBAG AS PART OF RECALL IN 2014. AWAITING DEALERSHIP TO REPLACE DRIVER-SIDE AIRBAG ALSO AS PART OF RECALL IN 2015. *TR

NHTSA ID

10920125

Incident

Oct 30, 2016

Mileage

75,000 mi

TL* TAKATA RECALL. THE CONTACT OWNS A 2006 BMW M3. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 14V428000 (AIR BAGS) AND 15V318000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

10903053

Incident

Sep 1, 2016

Brake Disc Return

The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.

Functional noises (squealing/honking) when braking shortly before the vehicle comes to a stop. CAUSE Material-

Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column.

Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle "discharged battery" complaints. In order to properly repair the vehicle the first time in the workshop, it is very important that the diagnostic test plans are performed to completion, with all results taken into consideration. Without performing the energy diagnosis test plan, the root cause of the discharged battery cannot be identified. This increases the chances of a repeat repair.

Diagnosis of Compound Brake System Complaints in M Vehicles: