2022 BMW X7

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

Component Failing: Telematics Control Unit (TCU) / SOS Emergency Call System This vehicle is experiencing an intermittent, total failure of the factory-installed SOS/Emergency Call System due to a known manufacturing defect. BMW has documented this issue in Technical Service Bulletin SIB 65 12 22, admitting that an improper factory paint and sealing process causes the roof-mounted shark fin antenna to separate from the vehicle body. As a direct result of this assembly defect, rainwater has leaked past the roofline and into the vehicle's interior cabin, flooding and short-circuiting the Telematics Control Unit (TCU). Consequently, the critical life-safety SOS system is failing to operate correctly. In the event of a severe crash or medical emergency, the vehicle's automated collision notification system will fail to contact first responders or transmit the vehicle’s GPS location. The manufacturer has acknowledged the defect to me but refuses to cover the repair outside of the narrow 50,000-mile warranty window, nor have they expanded their regional California legal settlements to protect drivers nationwide. Because this factory defect directly compromises a critical federal safety communications component, I request that the NHTSA open an official investigation into BMW model years 2017–2023 to mandate a nationwide safety recall.

NHTSA ID

11737594

Incident

Feb 11, 2026

The front passenger side door is unable to open from inside or outside the vehicle. The door actuator failed, and this has been confirmed by the dealer. This is an obvious safety issue as it prevents egress in an emergency. According to Internet forums, this seems to be a known issue across BMW platforms.

NHTSA ID

11730369

Incident

Apr 6, 2026

Transfer case and front and rear differentials have failed - bmw claims lifetime fluid which is clearly not accurate

NHTSA ID

11699292

Incident

Oct 8, 2025

Description of the Problem: At ~57,000 miles, the front differential on my 2025 BMW X7 M50i failed and was replaced by an authorized dealer in March 2025. The issue was believed resolved, but in October 2025 the vehicle was returned to Advantage BMW because of a question about when the vehicle showing shuttering, vibration, and binding during low-speed turns. The car has been at the BMW dealership since 10/15/2025, where it was diagnosed with a transfer-case failure. Both failures occurred without any warning lights, messages, or diagnostic alerts. The symptoms were only mechanical noise (front differential) and driveline vibration (transfer case). The dealer confirmed that BMW issued Service Bulletin SIB 27 02 20, describing similar transfer-case/driveline malfunctions. The failed components are available for inspection. This issue poses a safety hazard, as the xDrive AWD system controls traction and stability. Sudden drivetrain failure without warning can cause loss of power distribution between axles and loss of control during acceleration, turning, or highway driving. Multiple owners have reported identical failures on the BimmerPost G07 X7 forum (https://g07.bimmerpost.com/forums/showthread.php?t=2011112), indicating a broader defect pattern. Summary: Two major drivetrain components—the front differential and transfer case—have failed on my 2025 BMW X7 M50i under 60,000 miles with no warning indicators. The vehicle has been out of service since 10/15/2025. Given BMW’s acknowledgment in SIB 27 02 20 and widespread owner reports, this represents a potential safety-related defect requiring investigation.

NHTSA ID

11696292

Incident

Mar 20, 2025

I am filing this complaint regarding a persistent safety issue with the rear cross traffic alert (RCTA) system in my 2022 BMW X7. The system consistently fails to detect approaching vehicles, pedestrians, and cyclists unless they are within approximately two feet of the rear of the vehicle. This extremely limited detection range renders the system effectively useless for its intended purpose of preventing collisions while reversing, especially in environments such as parking lots, residential streets, and school zones. On multiple occasions, both my wife and I have experienced near accidents while reversing, including incidents involving moving vehicles and pedestrians—some of whom were small children at our child’s daycare. In all of these cases, the RCTA system failed to provide any warning or alert. This lack of detection poses a serious safety hazard not only to my family but also to those in the vicinity of the vehicle. Given that rear cross traffic alert systems are a key safety feature designed to reduce backover accidents, especially in scenarios where the driver’s visibility is compromised, I believe this constitutes a serious design or calibration flaw. I am concerned that this issue may not be isolated to my vehicle alone, and I urge the NHTSA to investigate this matter further to determine whether a recall or software update is necessary to correct the defect.

NHTSA ID

11669833

Incident

May 14, 2025

The vehicle had a spill in the cup holder. The cup holder has holes and does not hold liquid. This spilled into the electronics underneath and around it. The car suddenly could not be put into park. It would roll when attempting to do so. The electronics control park and the emergency brake from the same electronic panel. Preventing save disabling of the vehicle required chalking to prevent movement.

NHTSA ID

11665951

Incident

May 18, 2025

On [XXX], at [XXX], while driving at 65 mph on [XXX] between Chesapeake and Virginia Beach, VA, the front panoramic sunroof of my 2022 BMW X7 xDrive40i spontaneously shattered without warning. The sunroof and interior sunshade were fully closed, with no prior damage or warning signs. The glass exploded with a loud gunshot-like noise, causing glass to fall into the cabin. My wife, who was driving, was startled and jerked the wheel, nearly causing an accident. Conditions were clear, and no debris or impact occurred. The fracture showed outward bowing and horizontal cracks, typical of spontaneous tensile failure in tempered glass. No impact point was found. BMW acknowledged they have “seen this before” but denied my warranty claim, blaming impact with no proof. The tow truck driver also stated his company has towed at least two other BMW X7s recently with the same failure. I have found multiple similar complaints already documented in the NHTSA database, confirming this is not an isolated case. I am submitting detailed photographs and respectfully request a formal investigation into the safety and integrity of BMW’s panoramic sunroof design and materials. I am also filing a complaint with the Virginia Attorney General’s Office to ensure this issue is reviewed at both federal and state levels. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11659208

Incident

May 5, 2025

When backing out of my driveway while moving in reverse - I get absolutely zero audio warning of cross traffic vehicles or people. I’ve had two near misses where the vehicle/person was in my blind spot and the car never indicated anyone was close

NHTSA ID

11628776

Incident

Nov 6, 2024

The EVAP systems purge (vent) valve limited warranty for defects in materials and / or workmanship has been extended to 15 years / 150,000 miles as determined from the original first in-service / delivery date.

A check control message (CCM) for the restraint system (Air bag) appears. In the instrument cluster, the redair bag warning light lights up permanently. One of the following fault codes is stored in the ACSM (air bag control unit): 930949 - Knee airbag, driver: Short circuit to negative terminal 93094F - Knee airbag, front passenger: Short circuit to negative terminal 93094C - Knee airbag driver's side: Resistance too great 930952 - Knee airbag, front passenger: Resistance too great

The EVAP systems purge (vent) valve limited warranty for defects in materials or workmanship has been extended to 15 years / 150,000 miles as determined from the original in-service date.

The center console and front cup holder get noticeably too warm to the touch on long journeys with the interior "Heating on".

The Radiator Grilles Lower Active Air Flap Assembly limited warranty for defects in materials and/or workmanship has been extended to 15 years / 150,000 miles as determined from the original first in-service / delivery date.

Residues from the production process may be present on the Frontal Light Electronics circuit board. This could result in the failure of a lighting function (e.g. daytime driving lights, low-beam headlight, turn indicators) on the affected side in the front area. In the event of a fault, you will be informed by a Check Control message. The front light module will be replaced.