2003 Buick Rendezvous

GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.

CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.

The gas gage has been off since I bought it in September 2018. I run out of gas right before 1/4 of a tank and when I fill it it goes about 1/4 over the full line. The passenger seat side airbag went off closing the door May 2019.

NHTSA ID

11456749

Incident

May 8, 2019

After filling the fuel tank there is a strong gas odor that is present until the tank is almost empty. When walking around the vehicle or loading/unloading the vehicle, the strong gas odor is always present. This vehicle was at a dealership and they took it to the local personal auction company where i bid on it and bought it along with household items.

NHTSA ID

11452035

Incident

Jan 18, 2021

I purchased this vehicle in 2013, and a few years later, I began smelling gas. After doing my due diligence, I found out that there is a recall for this issue, because the check inlet valve at the top of the tank where the filler neck connects to the tank is cracked. Great, NO, only CERTAIN Rendezvous were covered, and even though mine has the exact same issue, they refuse to cover it and replace the tank. Well, apparently, there were SO MANY complaints by other Rendezvous owners that were also not "included" in the recall, the recall was expanded to ALL Rendezvous', BUT with the stipulation that it had to have less than 150,000 miles on it, which by THAT TIME, my car WAS over that mileage. So now I'm still driving with gas leaking out of my car, A KNOWN AND ADMITTEDLY UNSAFE DEFECT, because just to purchase that gas tank is over $1,000, not including the labor to drop the tank and replace it, approximately 3-4 hours labor. My disability check cannot afford that, so I have been FORCED to continue driving an unsafe car because they are refusing to repair THEIR DEFECT. And I'm not the only one. I've seen NUMEROUS videos of mechanic's shops BEGGING GM to cover this. And I take my grandchildren to school in this car. At least if the car does blow up one day because they wont' fix THEIR OWN SAFETY issue, I'll have ONE more record of trying to get it fixed and the request being ignored. I'm putting all this information in a file that will go to my daughter and attorney, as well as anyone else's attorney that is injured or killed because of not being repaired. All I was is to drive a car with gas not leaking out of my tank as I drive. I cover ALL the other repairs that it needs. I don't think this is too much to ask, especially since it won't cost the dealership anywhere near $1500 to fix, and any price would be far less than it will cost GM in a wrongful death suit.

NHTSA ID

11434946

Incident

May 12, 2015

HAVE BEEN TOLD BY SEVERAL DIFFERENT MECHANICS THAT FUEL IS LEAKING WHERE THE FUEL FILLER NECK CONNECTS TO THE PLASTIC GAS TANK AT THE CHECK INLET VALVE. I'VE SEEN MANY, MANY COMPLAINTS OF THIS SAME ISSUE FROM OTHER RENDEZVOUS OWNERS, AS WELL AS THE SAME PROBLEM OF GM AND/OR BUICK REFUSING TO REPAIR THE VEHICLE, EVEN THOUGH IT IS A SAFETY ISSUE, (POSSIBLE FUEL IGNITION OUTSIDE OF THE ENGINE USUALLY IS). I LIVE OFF A VERY MODEST DISABILITY CHECK AND A NEW TANK IS OVER $1,000, NOT INCLUDING ANOTHER 4-5 HOURS OF LABOR. THAT'S MORE THAN I GET IN A MONTH. GM NEEDS TO STEP UP AND HONOR THE RECALL AND FIX THESE VEHICLES. IT'S COMPLETE BS THAT THEY ARE LIMITING IT TO VEHICLES WITH LESS THAN 150,000 MILES ON THEM. AND MY VEHICLE HAD LESS THAN THAT THE FIRST TIME I CONTACTED GM ABOUT THIS, BUT THAT WAS BEFORE THEY SO GRACIOUSLY EXTENDED THE WARRANTY TO ALL RENDEZVOUS' WITH THIS ISSUE, BUT ADDING THE MILEAGE RESTRICTION EFFECTIVELY ELIMINATING ANY OTHER VEHICLES ACTUALLY QUALIFYING TO BE REPAIRED. I BOUGHT THIS VEHICLE IN 2013, AND IT HAS ALWAYS BEEN LEGALLY REGISTERED, BUT I NEVER RECEIVED ANY COMMUNICATIONS FROM GM ABOUT THIS RECALL. THAT, AND THE REFUSAL TO REPAIR A RECALL SAFETY ISSUE, IS, OR SHOULD BE CRIMINALLY NEGLIGENT.I REALLY FEEL LIKE A CLASS ACTION LAWSUIT IS WHAT WILL HAVE TO HAPPEN. MAYBE SINCE I HAVE SO MUCH TIME ON MY HANDS, THAT IS SOMETHING I SHOULD LOOK INTO.

NHTSA ID

11415455

Incident

Feb 7, 2017

Mileage

135,724 mi

OUR RENDEVOUZ PLASTIC FUEL TANK STARTED SEEPING FUEL AT THE FILLER NECK YESTERDAY. AFTER DOING SOME READING, I SAW THERE WAS A RECALL AND THEN A SPECIAL COVERAGE ADJUSTMENT. THE ONE LISTED ON JULY 21, 2008 SAID THE TANK WOULD BE REPLACED REGARDLESS OF AGE AND MILEAGE. THEN, GM CHANGED THEIR MIND ON AUGUST 8, 2008 AND LIMITED MILEAGE AND AGE TO 150,000 MILES AND 10 YEARS. I AM VERY DISTURBED ABOUT THIS AND THINK THAT THIS TANK NEEDS REPLACED FOR SAFETY REASONS AT MINIMUM. THE FUEL TANK IS NOT AVAILABLE FROM ANY AFTERMARKET SOURCE AND PURCHASING IT FROM GM IS $1590. I CANNOT BELIEVE THAT PURCHASING A USED TANK WOULD BE SAFE DUE TO THE ISSUE GM HAS MENTIONED.

NHTSA ID

11374105

Incident

Nov 10, 2020

Mileage

123,000 mi

GAS TANK LEAKS SOMETIMES... WHEN IN MOTION AND WHEN STATIONARY

NHTSA ID

11341092

Incident

Jun 30, 2020

Mileage

182,000 mi

FUEL DRIPPING FROM TANK DUE TO CRACK AROUND INLET

NHTSA ID

11322357

Incident

Mar 25, 2020

Mileage

126,000 mi

STRONG SMELL OF GAS OUTSIDE THE RENDEZOUS AT FIRST AFTER FILLING CAR WHICH SEEM TO OCCUR ONLY WHEN NEWLY FILLED. NOW THE STRONG SMELL OUTSIDE OF CAR IS CONTINUOUS AND FUEL IS LEAKING. THIS IS A SUBJECT OF RECALL BUT DATE OF RECALL IS TOO OLD FOR GM TO HONOR THE RECALL. HAVE BEEN TOLD THAT THE FUEL TANK HAS TO BE REPLACED.

NHTSA ID

11299258

Incident

Oct 6, 2019

Mileage

136,000 mi

This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to call General Motors Technical Assistance Center for further assistance.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.

This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.