1995 Cadillac Deville

ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.

THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.

There is no summary currently available

As I was pulling off from a stop sign, passenger and driver airbags deployed unexpectedly with no reason causing the front windshield to shatter and leaving the steering wheel busted open along side passenger dash. Also leaving me with burns, scratches on my chin and small shards of glass in my face and forearms.

NHTSA ID

11523367

Incident

May 11, 2023

The contact owns a 1995 Cadillac Deville. The contact stated while driving 35 MPH, the vehicle experienced unintended acceleration and inadvertently shifted into cruise control and then seized in full idle. The accelerator pedal depressed independently. The high battery voltage and oxygen sensor warning lights were illuminated. The dealer was made aware of the failure and diagnosed that the vehicle needed an idle control motor replacement. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 61,000.

NHTSA ID

11429867

Incident

Aug 20, 2021

Mileage

61,000 mi

THE FUEL LINE MADE OF HEAVY PLASTIC CRACKED AND CAUSED ALL THE FUEL TO LEAK FROM THE CAR NEAR THE ENGINE AS I WAS DRIVING NEAR MY HOME. I AM LUCKY THE CAR DID NOT CATCH FIRE BEFORE I REALIZED IT WAS LEAKING AS I DROVE DOWN THE ROAD.

NHTSA ID

11408128

Incident

Apr 13, 2021

Mileage

115,000 mi

TL* THE CONTACT OWNS A 1995 CADILLAC DEVILLE. WHILE DRIVING APPROXIMATELY 55 MPH, A LARGE AMOUND OF SMOKE APPEARED FROM THE FRONT DRIVER SIDE. THE CONTACT PULLED THE VEHICLE OVER, OPENED THE HOOD, AND NOTICED FLAMES. THE CONTACT EXTINGUISHED THE FIRE AND THE VEHICLE WAS TOWED TO THE RESIDENCE. THE VEHICLE WAS DIAGNOSED THAT THERE WAS A FUEL RAIL LEAKAGE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 04V110000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS APPROXIMATELY 124,000.

NHTSA ID

10881618

Incident

Jun 28, 2016

Mileage

124,000 mi

STRONG ODOR OF FUEL UNDER DRIVER SIDE IN BETWEEN DRIVER AND PASSENGER DOOR ...FUEL PUMP SLOWLY WENT OUT ..REPLACED FUEL PUMP ODDER BECAME WORSE NOW HAVING TO REMOVE THE FUEL TANK AND CHECK ALL FITTINGS AND HOSES FOR A LEAK CRACK SPLIT...??? *TR

NHTSA ID

10564601

Incident

Oct 1, 2013

Mileage

84,000 mi

WHILE DRIVING UP AN INCLINE ON HOT DAY WITH AC ON I GOT MESSAGE NO CHARGE, AND "ENGINE HOT SHUTDOWN SOON", & AC COMPRESSOR OFF! (A NO BRAINER WITH BELT SHREDDED!!) AS WELL AS STEERING GOING NUMB. WHEN I LOOKED UNDER THE HOOD THE SERPENTINE BELT HAD SLIPPED OFF THE PULLEYS & SHREDDED. UPON CLOSER INSPECTION IT WAS DETERMINED THAT THE POWER STEERING PUMP "ADAPTER" HAS A LEAK THAT DRIPS OIL DIRECTLY ONTO THE BELT & PULLEYS WHICH ARE SMOOTH WITH NOTHING TO STOP BELT FROM SLIDING OFF SHOULD A LEAK OCCURS. I HAVE BEEN UNABLE TO FIND "POWER STEERING PUMP ADAPTER" IN SALVAGE YARD & ITS OUT OF PRODUCTION AT GM & NOT IN STOCK AT MY LOCAL DEALER. *TR

NHTSA ID

10546954

Incident

Jul 3, 2013

Mileage

148,500 mi

I OBSERVED A LIQUID PUDDLE ABOUT MIDWAY BETWEEN THE FRONT AND REAR DOORS, ON THE DRIVER SIDE OF THE CAR. UPON FURTHER EXAMINATION I CONCLUDED THE LIQUID WAS GASOLINE. I FELT WHERE I THOUGHT THE LEAK WAS COMING FROM AND FELT TUBING. I FELT THE A TUBE LINE AND IT CRUMBLED IN MY HAND. UPON FURTHER VISUAL INSPECTION, I OBSERVED OTHER AREAS (ALONG THE DRIVERS DOOR) THAT WERE ALSO LEAKING GASOLINE. MUCH OF THE GAS LINE IS CRUMBLING PLASTIC, CAUSING GASOLINE TO LEAK UNDER THE CAR. *TR

NHTSA ID

10428704

Incident

Sep 30, 2011

Mileage

58,000 mi

TL* THE CONTACT OWNS A 1995 CADILLAC DEVILLE. THE CONTACT STATED THAT GASOLINE WAS LEAKING FROM UNDER THE VEHICLE. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 04V110000 (FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 55,000.

NHTSA ID

10428266

Incident

Oct 3, 2011

Mileage

55,000 mi

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.  E version update is to add administrative details.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.