1997 Cadillac Deville

ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.

THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.

GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.

There is no summary currently available

[  ] I had purchased my car used. I found that there was a recall on this model. I went online and ran the vin # and confirmed that. I called the dealership and explained they looked it up and confirmed it needed to have the original plastic fuel rail replaced with a new stainless steel fuel rail. They informed me that they had to order the parts from Michigan an it would be 2 weeks for the parts to get here and then we could set up an appointment to bring the car in. over 2 weeks later they called and we set up the appointment I had started the car the morning of the appointment for it to go to the dealership. I  needed to grab something from in the house so I turned it off to go back in my house. I was answering a text on my phone and as I looked up to get out of the car there were flames coming out from between the fender and the hood. I rushed to the front of the car to put the flames out.. I just got the car a d couldn't afford to let turn to the ground. I took off my hoodie and used it to UT out the flames while doing so the hood came down and hit me in the back of my head,I burned my left hand pretty badly and burnt off my arm hair. I have had a ringing in my ears since I was hit in the head. I called the dealer and told them what happened and I would have to get it towed in. They said okay it took three days to get a tow truck because we had a snow storm. The tow companies were booked. I got the car to the dealer and exspected them to start the job.  The parts were ordered and there. It had been over 3 weeks now that had gone by since I first talked to the dealership and they ordered the parts I waS waiting for. Now the car has been there for over a 2 weeks and  not  even been touched .  I was finally told by the service department  to call customer service about the recall. I called the # i was give spoke to someone and explained everything. After I was told they didn't know why I called. The dealership should just handle the repair. I called service and re

NHTSA ID

11447570

Incident

Nov 25, 2021

DOGGIE DIEOBLO

NHTSA ID

11082303

Incident

Aug 15, 2012

TL* THE CONTACT OWNS A 1997 CADILLAC DEVILLE. WHILE DRIVING OVER A SPEED BUMP, THE TRACTION WARNING LIGHT ILLUMINATED. IN ADDITION, THE AIR CONDITIONER FAILED TO OPERATE. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN THE NHTSA CAMPAIGN NUMBER: 97V064000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,000.

NHTSA ID

10822794

Incident

Dec 3, 2015

Mileage

92,000 mi

1997 CADILLAC DEVILLE. CONSUMER WRITES IN REGARDS TO IGNITION RECALL REPAIRS. *SMD THE CONSUMER STATED THERE WAS A PROBLEM WITH THE THEFT SYSTEM. ACCORDING TO THE INVOICE, THE IGNITION LOCK CYLINDER WAS REPLACED.

NHTSA ID

10702615

Incident

May 28, 2014

TL* THE CONTACT OWNS A 1997 CADILLAC DEVILLE. WHEN ATTEMPTING TO STOP THE VEHICLE, THERE WAS AN INCREASE IN STOPPING DISTANCE. THE CONTACT MENTIONED THAT THE VEHICLE WENT INTO ANTI LOCK BRAKING MODE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DETERMINED THAT THE ELECTRONIC BRAKE CONTROL MODULE OR THE ELECTRONIC BRAKE AND TRACTION CONTROL MODULES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 55,000.

NHTSA ID

10715699

Incident

Apr 13, 2015

Mileage

55,000 mi

AT ABOUT 12:30 - 1:00 AM IN THE MORNING THE CAR WAS PARKED AT MY HOME IN THE DRIVEWAY DIRECTLY IN FRONT OF THE GARAGE. [XXX] THE OWNER GETS UP TO GET SOMETHING TO EAT WHEN HE LOOKED OUTSIDE THE PATIO, HE SAW HIS CAR SMOLDERING AND THAN IMMEDIATELY BURST INTO FLAMES AT THE ENGINE AREA. CALLED THE FIRE DEPARTMENT IMMEDIATELY AND IN THE MEANTIME TRIED TO SUPPRESS THE FIRE BUT NOT SUCCESSFUL. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10681493

Incident

Jan 26, 2015

Mileage

87,000 mi

TL* THE CONTACT OWNS A 1997 CADILLAC DEVILLE. THE CONTACT STATED WHILE DRIVING 65 MPH ATTEMPTING TO ENGAGE THE BRAKES, THE VEHICLE FAILED TO STOP. THE CONTACT MENTIONED THAT THE ANTI-LOCK BRAKE, TRACTION CONTROL, BRAKE AND SECURITY LIGHT ILLUMINATED WHEN THE FAILURE OCCURRED. ALSO, THE CONTACT STATED THAT ALL THE GAUGES AND SIGNALS ON THE INSTRUMENT PANEL FAILED AND FAILED TO SHOW ANY INFORMATION. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE BRAKE FLUID WAS LEAKING WHEN ATTEMPTING TO MOVE THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 12/01/14*LJ UPDATED 10/1/15 *JS

NHTSA ID

10651429

Incident

Oct 9, 2014

I BACKED OUT OF MY DRIVEWAY AND PROCEEDED DOWN THE HIGHWAY AND THE PASSENGER SIDE AIRBAG EXPLODED ON MY WIFE'S ARM. I AM AFRAID THAT IT WILL HAPPEN ON THE DRIVERS SIDE WHILE DRIVING. WHAT SHOULD I DO FOR SAFETY SAKE? *TR

NHTSA ID

10650750

Incident

Oct 27, 2014

Mileage

189,000 mi

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.  E version update is to add administrative details.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.