1994 Chevrolet Astro

ON NOVEMBER 21ST, 2011, I WAS DRIVING MY ASTRO VAN ON A STRAIGHT ROAD. THE VEHICLE IN FRONT OF ME APPLIED THEIR BRAKES. I ALSO APPLIED MY BRAKES, BUT MY FOOT SLIPPED OFF THE BRAKE PEDAL. I ATTEMPTED 4 TIMES IN A PANICKED STATE TO TRY AND RE-APPLY MY BRAKES WITH NO SUCCESS. I STRUCK THE VEHICLE IN FRONT OF ME. AFTER CONSIDERING WHAT HAD HAPPENED THAT DAY AND LOOKING AT THE BRAKE PEDAL SIZE IN THE VEHICLE IT IS NO WONDER I COULDN'T READILLY RE-APPLY THE BRAKE. I MEASURED THE BRAKE PEDAL SURFACE AREA. IT IS APPROXIMATELY 4 SQ. INCHES. I HAVE SINCE BEEN LOOKING AT OTHER VEHICLES AND THE SIZE OF THEIR BRAKE PEDAL SURFACE AREA. I HAVE YET TO DATE FOUND SUCH A SMALL BRAKE PEDAL IN ANY OTHER VEHICLE. I HAVE DRIVEN THIS VAN THOUSANDS OF MILES AND KNOW WITHOUT MUCH CONSIDERATION THE PEDALS LOCATION WITHOUT LOOKING, BUT IN A PANICED STATE I FOUND YOU LOOSE THAT REFERENCE AND IT SIMPLY COMES DOWN TO AN INCREASED OR DECREASED CHANCE OF HITTING THAT PEDAL GIVEN SURFACE AREA. *TR

NHTSA ID

10436820

Incident

Nov 21, 2011

Mileage

162,000 mi

TL*THE CONTACT OWNS A 1994 CHEVROLET ASTRO VAN. THE CONTACT STATED THAT WHILE DRIVING, THE ENTIRE DIFFERENTIAL UNIT FELL FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHERE THE TRANSMISSION PIN WAS REPLACED. THE CONTACT WAS WAITING TO FIND OUT IF THE DIFFERENTIAL COULD BE REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 27,000. UPDATED 01/06/11 *BF THE CONSUMER STATED THE PREVIOUSLY, TRANSMISSION PAN HAD TO BE REPLACED AS IT WAS LEAKING DUE TO RUST. THE CONSUMER STATED NO FURTHER REPAIRS HAVE BEEN MADE AS THE VEHICLE WAS CONSIDERED NOT WORTH FIXING AFTER ASSESSING THE AMOUNT OF DAMAGE DO THE ADVANCE RUST CONDITION. UPDATED 03.02.11

NHTSA ID

10359445

Incident

Oct 5, 2010

Mileage

27,000 mi

I HAVE A 1996 CHEVY ASTRO VAN. DURING A HEAVY RAIN,WITH THE WIPERS ON HIGH THE WIPERS STOPPED WORKING. *TR

NHTSA ID

10299712

Incident

Aug 10, 2008

Mileage

130,000 mi

TL*THE CONTACT OWNS A 1994 CHEVROLET ASTRO. WHILE DRIVING LESS THAN 50 MPH, THE ALTERNATOR BRACKET FAILED. WITHIN A THREE MONTH PERIOD, THE BRACKET HAS FAILED TWICE. THE CONTACT ATTEMPTED TO FIND A REPLACEMENT COMPONENT AT A JUNKYARD AND WAS INFORMED BY THE JUNKYARD DEALER THAT HE RECEIVED NUMEROUS REQUESTS FOR THAT PARTICULAR COMPONENT DUE TO FREQUENT FAILURES. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS OVER 100,000 AND CURRENT MILEAGE WAS 105,000.

NHTSA ID

10246372

Incident

Oct 15, 2008

Mileage

100,000 mi

THIS IS THE SECOND TIME I WILL HAVE TO REPLACE THE TORSION BAR ON THIS 1994 CHEVY ASTRO AWD VAN. THE FIRST TIME WAS ABOUT 4 YEARS AGO. I HAVE DONE A SEARCH AND THERE ARE HUNDREDS IF NOT THOUSANDS OF REPORTS OF THE TORSION BARS FAILING WITHOUT WARNING, RESULTING IN BOTTOMING OF THE SUSPENSION. FORTUNATELY, IT FAILED WHEN I WAS PARKED BOTH TIMES IT HAS FAILED BUT COULD HAVE BEEN DEVASTATING IF I WAS ON THE HIGHWAY. *TR

NHTSA ID

10233701

Incident

Jul 5, 2008

Mileage

163,951 mi

TL*THE CONTACT OWNS A 1994 CHEVROLET ASTRO. BEFORE THE CONTACT ATTEMPTED TO DRIVE HER VEHICLE, SHE NOTICED THAT THE DRIVER'S SIDE WAS LAYING ON THE GROUND. SHE DID NOT NOTICE ANY DIFFERENCES IN THE VEHICLE PRIOR TO THE FAILURE. SIX YEARS AGO, THE CONTACT NEEDED TO HAVE THE TORSION BAR REPLACED AT 80,000 MILES. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 180,000.

NHTSA ID

10230737

Incident

Jun 11, 2008

Mileage

180,000 mi

WE OWN A 1994 CHEVY ASTRO VAN. FORTUNATELY, IT WAS SITTING IN OUR DRIVEWAY WHEN ONE OF THE TORSION BARS BROKE, DROPPING THE VAN DOWN ONTO THE FRONT LEFT TIRE. IF THIS HAD HAPPENED WHILE WE WERE DRIVING THE VAN WITH OUR FAMILY, IT COULD HAVE BEEN DISASTROUS. TWO DAYS LATER, THE OTHER TORSION BAR BROKE, AGAIN IN OUR DRIVEWAY. IN LOOKING AT THE WAY THE TORSION BAR IS MOUNTED TO THE CROSS MEMBER, IT APPEARS THAT A MANUFACTURE DEFECT CREATED A PROBLEM WHERE SNOW, SALT, RAIN AND DIRT ACCUMULATED INTO THE CYLINDER SHAPED TUBE THAT THE BAR IS MOUNTED INTO, TOWARDS THE REAR OF THE VEHICLE. THE TORSION BAR, MADE OF SPRING STEEL, RUSTED AND BROKE IN TWO. THE TORSION BAR IS PART OF THE SUSPENSION THAT KEEPS THE FRONT OF THE VAN UP OFF OF THE FRONT TIRES. AFTER READING SEVERAL ONLINE FORUMS, IT APPEARS THAT THIS SAME DEFECT HAS CAUSED SEVERAL ACCIDENTS AND NEAR ACCIDENTS TO OTHER ASTRO VAN OWNERS. WHETHER REPORTED OR NOT REPORTED, THE DESIGN OF THE MOUNTING BRACKET FOR THE TORSION BAR WAS MOST LIKELY USED THIS WAY SO THE MANUFACTURED COULD USE ONE SIZE OF TORSION BAR FOR SEVERAL VEHICLES AND THEN MODIFY THE MOUNT ON EACH VEHICLE TO ACCEPT THE SAME SIZE BAR. WE HAVE PURCHASED REPLACEMENT TORSION BARS (GM PARTS) FOR $462.00 AND NEED TO ALSO PAY TO HAVE THEM INSTALLED. THE REPLACEMENT TORSION BARS ARE NOW 3 INCHES SHORTER, PROVING THAT THE MANUFACTURE BECAME AWARE THIS PROBLEM AND CORRECTED IT WITH THE REPLACEMENT PARTS - NOW WITHOUT THE EXTRA 3 INCHES OF OPEN CYLINDER TO COLLECT SALT AND SNOW. I BELIEVE THIS IS A VERY DANGEROUS SITUATION AND THAT THESE PARTS SHOULD BE RECALLED IMMEDIATELY ON ALL VANS WITH THIS SIZE OF TORSION BAR. WE REGULARLY DRIVE THE INTERSTATE AND HAD IT BROKE WHILE WE WERE DRIVING IT, IT WOULD HAVE BEEN LIKE DRIVING ON THE HIGHWAY AND SLAMMING ON YOUR BREAKS (AS THE FRONT OF THE VAN DROPPED DOWN ONTO THE TIRE) AND SUDDENLY LOSING ANY STEERING ABILITY OR WAY TO CONTROL THE VEHICLE. THANKFULLY, WE DIDN'T HAPPEN TO BE DRIVING IT WHEN IT BROKE. *NM

NHTSA ID

10164660

Incident

Jul 21, 2006

Mileage

126,112 mi

DT: THE CONSUMER STATED THAT WHILE DRIVING AT 30 MPH THE METAL BRAKE LINE HAD BURST ON THE LEFT FRONT DRIVER'S SIDE OF THE VAN WITHOUT ANY PRIOR INCIDENT. THE LINE BROKE AS THE BRAKE PRESSURE WAS APPLIED. THE CONSUMER AVOIDED A COLLISION AND WAS ABLE TO PULL OVER. THE BRAKE PEDAL WAS PUSHED ALL THE WAY TO THE FLOOR. THE CONSUMER'S HUSBAND DROVE THE VEHICLE HOME WITH THE EMERGENCY BRAKE APPLIED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHO CONFIRMED THE PROBLEM WITH THE BRAKE LINES. THE MECHANIC REPLACED THE ENTIRE BRAKE LINE. SINCE THE REPAIR, THERE HAVE BEEN NO FURTHER PROBLEMS. *AK (11/29/05) *SC

NHTSA ID

10141435

Incident

Oct 15, 2005

Mileage

140,000 mi

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.  E version update is to add administrative details.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.

Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules

GENERAL MOTORS: ON ALL 1988-2009 FULL SIZE CHEVROLET/GMC PICKUPS, UTILITIES AND VANS, THE BRAKE PEDAL WILL MOVE DOWN OR SELF APPLY DURING FULL LOCK TURNS OR NEAR FULL LOCK TURNS. CHEVROLET ASTRO AND GMC SAFARI VANS; HUMMER 2 ARE INCLUDED. *PE UPDATED 5/24/11. *PE

DIAGNOSIS OF CRACKED OR BROKEN TRANSMISSION CASE. *TT 2006 AND PRIOR CARS AND LIGHT DUTY TRUCKS. *TT