RoadVitals

1995 Chevrolet Cavalier

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
270
Latest Nov 24, 2014
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
9
Latest May 11, 2009
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
42
27 injuries, 0 deaths reported

Overview

Our database contains 270 NHTSA owner-reported complaints for the 1995 Chevrolet Cavalier, most frequently naming the engine, electrical and visibility categories. 9 safety recalls have been issued covering this model year; 1 NHTSA investigation names it; and 89 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

9 campaigns cover this model year

View all 9

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
09E025000

EXTERIOR LIGHTING:HEADLIGHTS

May 11, 2009
42,540 units potentially affected
The defect: DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
The risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
The remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
DOPE, INC.View on NHTSA.gov
09E012000

EXTERIOR LIGHTING

Apr 7, 2009
16,270 units potentially affected
The defect: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
The risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
The remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
SABERSPORTView on NHTSA.gov
08E063000

STEERING

Oct 17, 2008
3,855 units potentially affected
The defect: DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
The risk: IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
The remedy: DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
DORMAN PRODUCTS, INC.View on NHTSA.gov

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect.

PE02001ClosedPreliminary Evaluation

FIRE IN STEERING COLUMN AREA

Opened Jan 3, 2002
Closed Mar 15, 2002
ELECTRICAL SYSTEMLed to recall 02V070000

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

View all 270
Electrical
Filed Nov 24, 2014

TL* THE CONTACT OWNS A 1995 CHEVROLET CAVALIER. THE CONTACT STATED THAT WHEN THE VEHICLE WAS TURNED ON, THE IGNITION KEY FAILED TO STAY IN THE RUN POSITION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 207,636.

NHTSA ID
10660577
Incident
Sep 7, 2014
Mileage
207,636 mi
Body & structure
Filed Sep 7, 2011

TL* THE CONTACT OWNS A 1995 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE FRAME WAS RUSTING SEVERELY. THE DEALER WAS NOTIFIED OF THE FAILURE BUT DENIED ANY ASSISTANCE WITH REPAIRS. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,800 AND THE CURRENT MILEAGE WAS 61,000. THE VIN WAS UNAVAILABLE. UPDATED 10/18/11*LJ UPDATED 3/29/12 *CN

NHTSA ID
10424056
Incident
Sep 7, 2011
Mileage
60,800 mi
ElectricalEngine
Filed Oct 31, 2008

TL*THE CONTACT OWNS A 1995 CHEVROLET CAVALIER. WHEN THE VEHICLE WAS STARTED, THE BATTERY LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE STALLED. LATER THAT DAY, THE CONTACT DROVE TO THE DEALER AND THEY STATED THAT THE THERMOSTAT WAS DEFECTIVE. THE MECHANIC CLAIMED THAT THE VEHICLE WAS REPAIRED, BUT IMMEDIATELY FOLLOWING, THE BATTERY LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL. THE VEHICLE WAS THEN TAKEN TO A LOCAL REPAIR SHOP AND THE MECHANIC STATED THAT THE BATTERY WAS DEFECTIVE AND MADE THE REPLACEMENT. THE FOLLOWING DAY, THE CONTACT RETURNED TO THE DEALER DUE TO THE SAME FAILURE, BUT THEY COULD NOT DETERMINE THE CAUSE. THE VEHICLE HAS NOT BEEN REPAIRED SINCE THE MOST RECENT FAILURE. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE CURRENT MILEAGE WAS 50,000 AND FAILURE MILEAGE WAS 48,000.

NHTSA ID
10247351
Incident
May 17, 2004
Mileage
48,000 mi
ElectricalEngine
Filed Apr 7, 2008

TL*THE CONTACT OWNS A 1995 CHEVROLET CAVALIER. WHILE TURNING THE VEHICLE AT VARIOUS SPEEDS, THE IGNITION AND ENGINE COMPLETELY FAILED. THE VEHICLE TAKES SEVERAL MINUTES BEFORE IT CAN BE RESTARTED. THE CONTACT CALLED THE DEALER AND THEY STATED THAT THE VEHICLE WAS NOT UNDER A RECALL. THE CURRENT MILEAGE WAS 78,340 AND FAILURE MILEAGE WAS 60,000.

NHTSA ID
10223589
Incident
Apr 5, 2007
Mileage
60,000 mi
Body & structureBrakesEngine
Filed Jul 12, 2007

I BOUGHT A 1995 CHEVROLET CAVALIER NEW, IN JULY 1995. I HAD THE FOLLOWING MAJOR REPAIRS DONE ON THE CAR. ON 8/97 -ENTIRE EXHAUST FROM CONVERTER BACK BAD BAFFLED UNDER WARRANTY. ON 10/97-SERPENTINE BELT/ROTORS/ALTERNATOR & RECALL ON HAZARD LIGHTS UNDER WARRANTY. 4/00-HEAD GASKET,SEAL,OIL,FILTER,COOLANT;RECALL ON COVER,SHIELD,RETAINER,SEALANT (DEALER COVERED COSTS UNDER A SPECIAL POLICY ADJUSTMENT. 4/00-EGR VALVE 10/00-ADJUST SERPENTINE BELT;REPLACE SERPENTINE BELT 10/01-REPLACE BACK BRAKE PADS,CLEAN FRONT PADS 05/02-REPLACE FAN BELT & TENSIONER;RECALL ON IGNITION SWITCH 06/02-BROKEN FORWARD CLUTCH HOUSING,CLUTCH,GASKETS,FLUID,LEFT FRONT AXLE ASSEMBLY 07/02-REPLACE BATTERY,BAD CELL DUE TO CAR SITTING FOR SO LONG DURING PREVIOUS REPAIR 12/03-WATER PUMP, HEAD GASKET, THERMOSTAT,OIL,FILTER,COOLANT $461.79-50% OF BILL REIMBURSED BY CHEVROLET UPON WRITTEN REQUEST 07/03-REAR BRAKES; 08/04-RESISTOR (BLOWER MOTOR, 09/04-ALTERNATOR 07/05-FRONT ROTORS & PADS; 06/06-REAR BRAKE LINE 06/07-WON'T PASS STATE INSPECTION-FRAME RUSTING OUT. REAR BUMPER SUPPORT FRAME MUST BE REPLACED TO PASS INSPECTION, MORE FRAME REPAIR WILL LIKELY BE NEEDED FOR NEXT INSPECTION;HEAD GASKET IS STARTING TO SEEP AGAIN THIRD HEAD GASKET. I CONTACTED CHEVROLET TWICE BY THEIR E-MAIL SITE IN THE PAST 2 WEEKS AND HAVE HAD NO RESPONSE. SITE CLAIMS RESPONSE WILL BE WITHIN 48 HOURS. I ASKED FOR REPAIR COSTS FOR REAR FRAME SUPPORT, HEAD GASKET OR A VOUCHER FOR CREDIT TOWARD A NEW/NEWER VEHICLE. POINTED OUT THE PROBLEM OF THE THIRD HEAD GASKET, THAT FRAME RUSTED ON A CAR ONLY 12 YEARS OLD THAT JUST LAST MONTH TURNED 72,000 MILES. ALSO, POINTED OUT THAT WHEN I BOUGHT THE CAR THE DEALER RECOMMENDED A PROTECTIVE UNDERCOUNTS WHICH I AGREED TO. WHEN I READ THE OWNER'S MANUAL IT STATED NOT APPLY *AK

NHTSA ID
10196202
Incident
Jun 22, 2007
Mileage
72,012 mi
Fuel systemInterior & seatsSteering
Filed May 21, 2007

TL*THE CONTACT OWNS A 1995 CHEVROLET CAVALIER. WHILE DRIVING 65MPH, THE GAS GAUGE IDLED BACK AND FORTH UNCONTROLLABLY. WHEN THE FUEL TANK IS FULL THE GAUGE IDLED FROM FULL TO A QUARTER THEN BACK TO FULL. IT ALSO IDLED FROM A HALF TANK, QUARTER TANK THEN TO EMPTY. WHEN ATTEMPTING TO CLOSE THE TRUNK, IT FAILED TO CLOSE DUE TO THE LINK AND LATCH MOVING OUT OF PLACE (NOT ALIGNED). THIS FAILURE ALSO CAUSED HER TRUNK TO OPEN RANDOMLY. WHILE DRIVING 65 MILES PER HOUR, THE VEHICLE BEGAN SHAKING UNCONTROLLABLY. THE DEALER STATED THAT THE FAILURE IS DUE TO THE STRUTS. THE STRUTS WERE REPLACED THREE TO FOUR TIMES AND THE PROBLEM CONTINUED TO OCCUR. THE FAILURE AND CURRENT MILEAGE WERE 179850.

NHTSA ID
10191386
Incident
Jan 2, 2004
Mileage
179,850 mi
Engine
Filed Jun 7, 2006

CONSUMER REQUESTED RECALL INFORMATION ON A 1995 CHEVROLET CAVALIER. *KB. NAR NO ADDRESS PROVIDED. THE CONSUMER HAD VALVE WORK DONE ON THE VEHICLE. THE CONSUMER BELIEVES THE MANUFACTURER SHOULD BE RESPONSIBLE FOR THIS REPAIR. *NM

NHTSA ID
10160507
Incident
Jan 1, 1901
Engine
Filed Apr 17, 2006

MASSIVE LEAKS OF COOLANT DUE TO FAULTY GASKET CHECK ENGINE LIGHT REMAINS CONSTANT RUNNING THROUGH A BOTTLE OF ANTIFREEZE A DAY B/C OF SAID LEAK. *NM

NHTSA ID
10155499
Incident
Apr 1, 2006
Mileage
149,000 mi

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

17-NA-073

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

PIP4723F

FUEL SYSTEM, GASOLINE; SERVICE BRAKES, HYDRAULIC

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

PIP4723D

ELECTRICAL SYSTEM

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

PIC4696E

EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES; EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.  E version update is to add administrative details.

17NA073

EQUIPMENT

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

PIC4696D

EQUIPMENT

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Chevrolet Cavalier by model year
YearComplaintsRecallsInvestigationsIssue Index
20052871038.4
20043302047.2
20036782455.4
20021965054.5
20012436261.1
20003157361.2
19992408054.6
199834511056.0
199754013466.9
199650313465.4
1995Viewing2709161.2
19942122259.9
19931462156.9
19921341047.8
1991553263.7
1990551257.7
1989432255.2
1988123662.4
1987243463.1
1986183167.6
1985435—
1984838—
1983366—
1982116—
1981002—
1980001—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.