RoadVitals

2007 Chevrolet Cobalt

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
1,564
Latest Jul 3, 2026
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
6
Latest Apr 30, 2014
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
132
109 injuries, 7 deaths reported

Overview

Our database contains 1,564 NHTSA owner-reported complaints for the 2007 Chevrolet Cobalt, most frequently naming the steering, fuel system and electrical categories. 6 safety recalls have been issued covering this model year; 1 NHTSA investigation names it; and 884 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

6 campaigns cover this model year

View all 6

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
14E021000

ELECTRICAL SYSTEM:IGNITION:SWITCH

Apr 30, 2014
14,529 units potentially affected
The defect: UCI-FRAM Group is recalling certain LS1328 ignition Switches sold as Wells LS1328, Duralast LS1328, Airtex 1S6097, and Carquest 53-27479, and LS1497 Ignition Switches sold as Wells LS1497, Duralast LS1497, Airtex 1S10961, and Carquest 53-27967, for use on various General Motors model and model year vehicles during repair and replacement of the original ignition switch. The weight on the key ring and/or road conditions or some other jarring event may cause the affected ignition switches to move out of the run position, turning off the engine and disabling the air bags.
The risk: If the ignition switch moves from the run position to accessory, the car would stall and the air bags will not deploy in the event of a crash, increasing the risk of personal injury to the occupants.
The remedy: UCI-FRAM Group has notified its purchasers to quarantine and return all inventory. Any switches already installed in vehicles will be replaced by GM dealers as part of NHTSA recall 14V-047, free of charge. UCI-Fram's purchasers should contact UCI-FRAM Group at 1-800-890-2075. GM vehicle owners requiring additional information on that recall campaign should contact GM at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac) or 1-800-553-6000 (Saturn).
UCI-FRAM GroupView on NHTSA.gov
14V171000

ELECTRICAL SYSTEM:IGNITION

Apr 10, 2014
2,191,014 units potentially affected
The defect: General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
The risk: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
The remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
General Motors LLCManufacturer number 14113,14133View on NHTSA.gov
14V047000

AIR BAGS; ELECTRICAL SYSTEM:IGNITION:SWITCH

Feb 10, 2014
2,190,934 units potentially affected
The defect: This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
The risk: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
The remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
General Motors LLCManufacturer number 13454/14063/14092View on NHTSA.gov

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect.

PE10005ClosedPreliminary Evaluation

Electric Power Steering Failure

Opened Jan 27, 2010
Closed Jul 19, 2010

In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.

STEERING:ELECTRIC POWER ASSIST SYSTEMLed to recall 10V073000

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

View all 1,564
ElectricalFuel systemSteering
Filed Jul 3, 2026

Fuel Leak it smells and leaks it seems to be coming from the gas tank and sometimes I get random electric failure when I'm driving I lose power steering and My brakes get stiff and hard to push down and my dash will go Off and then go crazy and show that i have no gas

NHTSA ID
11748103
Incident
Jan 27, 2023
Fuel system
Filed Apr 15, 2026

I observed my mother’s 2007 Chevy Cobalt was leaking fuel near the rear tire by the fuel tank. I inspected the tank with engine off and it does not leak. Only with engine running. I lowered the tank and observed a small crack on the plastic return line on the fuel pump module. I started looking online and could not find a replacement part that was plastic. I then conducted more research and found the recall. I asked my mother and she stated she never received a recall. The recall was issued on 09-19-12. NHSTA ID#12v459000

NHTSA ID
11731276
Incident
Jan 28, 2026
Airbags
Filed Mar 17, 2026
Crash reported1 death reported

The contact owned a 2007 Chevrolet Cobalt. The contact stated that while the son was driving at approximately 52 MPH, the vehicle crashed head-on into a second vehicle. During the crash, no air bags had deployed, and the driver sustained fatal injuries. Also, during the crash, the ignition key broke off inside the ignition switch, and the vehicle was destroyed. A police report was taken at the scene, and the vehicle was towed to a police inbound lot and later towed to the home. The cause of the failure was not determined. The manufacturer and local dealer were not notified of the failure. The failure mileage was unknown.

NHTSA ID
11724877
Incident
Apr 29, 2023
Airbags
Filed Jan 9, 2026
Crash reported2 injuries reported

The contact owns a 2007 Chevrolet Cobalt. The contact stated that while driving at 55 MPH, a 12-point buck jumped into the roadway, causing the contact to abruptly depress the brake pedal; however, the vehicle skidded and crashed into the buck. No air bags deployed. The vehicle was drivable; however, the vehicle was towed to the residence due to the radiator being damaged. The contact stated that he sustained injuries to his left knee, and his fiancée, who was seated in the front passenger side, sustained injuries to her left knee. The contact stated this morning that he noticed his knee was swollen. No medical attention was sought as of yet. The contact stated that a police report was filed. The manufacturer was not notified of the failure. The approximate failure mileage was 16,265.

NHTSA ID
11709925
Incident
Jan 8, 2026
Mileage
16,265 mi
Steering
Filed Dec 4, 2025

The contact owns a 2007 Chevrolet Cobalt. The contact stated that while driving at an undisclosed speed, the steering wheel seized. There was no warning light illuminated. The contact stated that the steering wheel became difficult to turn. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was unavailable.

NHTSA ID
11702992
Incident
Dec 4, 2025
AirbagsElectricalSteering
Filed Sep 26, 2025
Crash reported1 injury reported

I was in a crash on 9/19/25 and at the incident none of my airbags deployed. My daily driver for my children and I. I was lucky I was the only passenger at the time. I never expected my airbags not to deploy in a head on crash. The car still sits in my driveway and I have and identical one just like it that I drive! I’d like them evaluated.

NHTSA ID
11689938
Incident
Sep 19, 2025
Steering
Filed Aug 21, 2025

Hard to Turn Brand New front suspension

NHTSA ID
11682157
Incident
Aug 21, 2025
BrakesElectricalSteering
Filed Apr 23, 2025

The contact owns a 2007 Chevrolet Cobalt. The contact stated that while driving approximately 35 MPH, the power steering warning light illuminated, and the contact had to manually steer the vehicle. The contact continued to drive the vehicle without power steering functionality. The contact stated that additional electrical failures had occurred. The contact also stated that the ABS activated and deactivated independently, and the traction control became inoperable. The instrument panel also became inoperable, and the contact was unable to see the speedometer and fuel gauge functions on the instrument panel. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was unknown. The VIN was not available.

NHTSA ID
11656377
Incident
Apr 23, 2020

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

PIC5650M

This Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. Technician may find Diagnostic Trouble Codes B3055, B3060, B3935, C0750, C0755, C0760, C0765, and/or C0775.

PIP5601C

This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.

PIT5074R

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

PIT5074R

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

PIT5074R

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

PIP5358D

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to call General Motors Technical Assistance Center for further assistance.

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Chevrolet Cobalt by model year
YearComplaintsRecallsInvestigationsIssue Index
2017100—
2016100—
2015000—
2014000—
2013000—
2012100—
2011200—
20105736158.1
20097106361.4
20088455260.2
2007Viewing1,5646157.9
20062,3306157.1
20051,6496156.8
2002200—
2000100—
1996100—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.