2023 Chevrolet Silverado 1500 Electrical Problems

A valve on the 3.0L Duramax is allegedly sticking, causing the vehicle to go into limp mode or be inoperable. This is a known issue for GM and they have issued a service bulletin on it. Unfortunately, no dealers want to address the issue and now we are left with a vehicle that if we do not pay to repair, after it being ours for only 5 days, the vehicle will be unusable. This vehicle is under warranty still and this part is needed for operation. I believe this avoidance of a recall is harming customers and creating pay to drive schemes. This needs to be addressed before thousands of customers begin paying for a repair that GM knows is their fault.

NHTSA ID

11747650

Incident

Jun 30, 2026

“Service transmission now unable to shift soon” message. Vehicle is stuck in park. Message appeared in May. Transmission stuck shortly after. Safety is at risk due to transmission being unable to shift due to faulty module that is widely reported and known to Chevrolet.

NHTSA ID

11745313

Incident

May 26, 2026

My 2023 Chevrolet Silverado 1500 experiences an intermittant, uncommanded mechanical drivetrain lockup and severe binding when accelerating from a complete stop. The vehicle rolls fine in a straight line for several feet, but the exact moment the steering wheel is turned slightly (a couple degrees), the drivetrain violently binds up. This creates resistance in the steering and acceleration, as well as a severe physical and audible metallic clunking slam and massive shockwave vibrations felt directly through the steering wheel, floorboards, brake/gas pedals, and driver’s seat. During the last event, the vehicle threw a "Service 4 Wheel Drive" dash message and refused to shift out of "Auto" mode back into 2WD. Because this is a pure mechanical interference/binding issue, it does not consistently throw active electronic trouble codes. A standard OBD2 code scan will show nothing. After turning the vehicle off for several hours and testing again, the problem persisted. After towing the vehicle to a dealership (6/10/2026) it sat for at least 5 days before dealership service looked at it. By this time, the active warning lights cleared. My initial servicing dealership refused to perform physical hardware or fluid diagnostics under my factory warranty, stating they would not look at the vehicle unless I paid $860 out-of-pocket or until the drivetrain "completely grenaded" on the road. Because this uncommanded lockup restricts my ability to steer the vehicle safely from a stop, it presents an immediate crash hazard. At the direction of General Motors Corporate, I am escalating this issue and moving the vehicle to a secondary certified facility (Feldman Chevrolet of Novi) on June 23, 2026, for a formal physical hardware and fluid tear-down inspection.

NHTSA ID

11745032

Incident

Jun 10, 2026

6/12/26 ( 2023 Chevy Silverado - 6.2 liter engine) While driving at approximately 40 MPH on a two lane road, the truck shut off. After multiple attempts, the engine failed to restart. The transmission locked up in park and would not release. This required the truck to be dragged up on the flat bed wrecker instead of rolling freely. Prior to this instance there have been several issues with the electrical system. 1. radio sound shuts off. does not come back on. 2. Head lights stay on for 10 minutes after vehicle is turn off. 3. Tail gate opens on it own. Tail gate doesn't open with fob. 4. door locks fail to operate correctly. 5. When drivers door is opened a beeping sound starts and doesn't stop until door is closed. I have reported these problems to GM & have two case numbers. The dealership reports that the 6.2 replacement engines have had multiple failures.

NHTSA ID

11744988

Incident

Jun 12, 2026

ON MONDAY, 6/15/26, WITH APPROX 45,400 MILES, I WAS DRIVING DOWN THE ROAD AND TRUCK SAID SERVICE TRANSMISSION. THE GEARS WOULD SHIFT, BUT IT LAGGED A LITTLE BIT. I SCHEDULED AN APPT FOR TWO DAYS LATER, AND ONLY DROVE IT WHEN I ABSOLUTELY HAD TO, WHICH WAS ONLY TWICE BEFORE MY SCHEDULED APPT. I GET IN IT TO DRIVE AND IT SAYS SERVICE TRANSMISSION- UNABLE TO SHIFT SOON, THEN ON MY WAY TO THE DEALERSHIP, IT SAYS ALL OF THAT, PLUS SERVICE DRIVER ASSIST SYSTEM. CHAVY'S QUALITY ASSURANCE TEAM NEEDS TO GET IT TOGETHER! THIS IS ABSOLUTELY RIDICULOUS.

NHTSA ID

11744715

Incident

Jun 15, 2026

Engine failed and no light or warning besides check oil was shown on truck. The electrical system also went out (a year before engine failure) so car wouldn’t start.

NHTSA ID

11744620

Incident

Jun 6, 2026

electrical fire in rear bumper. vehicle parked not running. point of origin in area of tmp sensor trailer light plug in'

NHTSA ID

11742394

Incident

Jan 13, 2026

Had a vehicle update for my 2023 Chevrolet Silverado and now my Onstar Module is toast and no longer under warranty bc I have 37,000 miles. Many reports of this happening to 2023 models but no recalls for this. Why should I have to pay $1000.00 for a part that is failing in many vehicles of the same year.

NHTSA ID

11737370

Incident

May 11, 2026

The contact owns a 2023 Chevrolet Silverado. The contact stated while driving at approximately 40 MPH, the vehicle stalled, the brakes were inoperative, the gear shift was stuck in drive, and all of the doors and windows were locked and inoperative. The check engine warning light was illuminated and the "please restart the engine" message was displayed on the instrument panel. The vehicle was taken to a dealer where it was diagnosed that the fuel pump regulator module needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 373200.

NHTSA ID

11735899

Incident

May 2, 2026

Mileage

373,200 mi

In 2024 there was a recall for the tailgate locking mechanism - We did not receive that recall - but the part went bad causing the battery to drain - and it had to be repaired. We had to pay for the service $500.00 - We I asked the dealership about this recall they said it did not include my vehicle. But it was indeed that part that went bad. I lease the truck - I had every intention of purchasing after the lease - I am over the miles and was told it was out of warranty. I certainly would not complain about paying for it - but there was a recall last year for said part. Could some please reach out to me regarding this - Thank you

NHTSA ID

11732917

Incident

Apr 21, 2026

Vehicle has experienced repeated electrical and safety system failures since purchase in 2023. Affected systems include forward collision warning, blind spot monitoring, parking sensors, cameras, and infotainment. Failures include complete loss of camera functionality (rear and front), infotainment system shutdowns or resets while driving, loss of audio, and volume malfunctioning (including sudden increases or no response). The vehicle has also generated false safety alerts, including forward collision warnings and blind spot alerts when no hazard was present. These issues have occurred while the vehicle was in operation, creating safety risks due to loss of visibility systems and unreliable warning alerts. In multiple instances, the system would become completely non-functional for extended periods, sometimes lasting days or weeks, before temporarily returning. The problem has been reported to a dealership multiple times and has been inspected and serviced. Repairs have included software updates and component-related work; however, the issues have continued to persist or reoccur. The failures are intermittent but recurring and have not been permanently resolved despite multiple repair attempts. The condition reduces driver confidence and creates unsafe operating conditions due to unreliable safety systems and loss of critical features while driving.

NHTSA ID

11732877

Incident

Dec 16, 2023

Tailgate opens on its own after parking truck. No buttons inside or on the key fob are pressed and the tailgate randomly opens. Caused the battery to drain as well.

NHTSA ID

11727450

Incident

Mar 21, 2026

Battery keeps going dead 4 batteries in 4 months think it is caused by power tailgate release

NHTSA ID

11727171

Incident

Mar 6, 2026

The contact owns a 2023 Chevrolet Silverado 1500. The contact stated that on two separate occasions while hauling the camper, the "High Diesel Exhaust Fluid", Exhaust Fluid Range", and "Fill DEF (Diesel Exhaust Fluid) Now" warning messages were displayed on the instrument panel. The messages indicated that the Diesel Exhaust Fluid was low and needed to be replenished. The contact stated that the failure caused the instrument panel to freeze and not operate as needed. Upon attempting to refuel the vehicle, fuel failed to enter the fuel tank since the diesel tank was full. The vehicle was taken to a dealer, where the contact was informed that the failure was an electrical glitch and that there were no issues with the Diesel Exhaust Fluid system. The contact was also informed by the dealer of Technical Service Bulletin: 22-NA-150, which the contact related to the failure. The dealer reset the vehicle, which caused the instrument panel to return to normal operation. The manufacturer was then notified of the failure, and the contact was informed that vehicle was not included in the TSB. The contact was given a case number and was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 55,000.

NHTSA ID

11726932

Incident

Oct 4, 2025

Mileage

55,000 mi

Tailgate unexpectedly opened when driving. Switch on and off when parked and drained battery

NHTSA ID

11724913

Incident

Mar 16, 2026

My onstar telematics system has failed. I lost all connectivity with onstar and have no vehicle crash detection, communication and onstar based safety feature available anymore. I took the truck to the dealership and they identified the telematics module as faulty and needs replaced. The onstar system buttons are off and will not turn back one and have been off since 2/18/26.

NHTSA ID

11721738

Incident

Feb 18, 2026

On [XXX], my 2023 Chevrolet Silverado 1500 LT caught fire while parked in my residential driveway at [XXX] . The vehicle had been started approximately 10 minutes earlier using the factory-installed remote start system. The vehicle was unattended at the time. My neighbor noticed the vehicle on fire and called 911. The Andover Fire Department responded and extinguished the fire. The fire department indicated the fire appeared to be electrical in nature. The fire appeared to originate in the dashboard and steering column area based on visible damage and fire progression. The vehicle had approximately 60,000 miles and was properly maintained. There were no prior warning lights, messages, or symptoms before the fire. The remote start system was factory-installed and not aftermarket. The vehicle is currently available for inspection by insurance, manufacturer, or investigators at [XXX] . The vehicle is likely a total loss due to the extent of the fire damage. This incident posed a serious safety risk as the vehicle caught fire spontaneously while parked near my home. The fire could have spread to my residence or caused injury if someone had been inside or near the vehicle. The fire department responded, and an official fire report is pending. Insurance claim has been opened and inspection is pending. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11721174

Incident

Feb 27, 2026

The contact owns a 2023 Chevrolet Silverado 1500. The contact stated that while stopped at a traffic light, the engine turned off and the instrument panel became inoperable. The vehicle was restarted; however, the failure persisted. The vehicle was taken to the dealer; however, no cause for the failure was found. The contact stated that on a separate occasion, the message "Tailgate Open" was displayed on the instrument panel. The contact pulled over to the side of the road and, upon inspection, noticed that the tailgate was closed. The vehicle was taken to the dealer; however, no cause for the failure was found. An employee at the dealer closed and opened the tailgate several times until the message disappeared. The contact stated that on a separate occasion, the radio stopped functioning, the driver's door unlocked unintendedly, and the driver’s side seat belt failed to retract as intended. The vehicle was taken back to the dealer, where it was diagnosed that the seat belts had failed. The contact seat belts were replaced. Most recently, there was an abnormal sound coming from the engine. In addition, the brake pedal was depressed, and the vehicle failed to respond. After a while, the vehicle was able to stop. The message "BRAKE System Failure” and “Replace Brake Pads and Rotors" was displayed. The vehicle was not diagnosed or repaired. The contact stated that the failure persisted. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 22,000.

NHTSA ID

11720954

Incident

May 15, 2024

Mileage

22,000 mi

Engine light keeps returning after dealer visits for oil change. Exhaust heat shield rattles since day one of ownership. During Normal commute, when I accelerate reduced power comes on and doesn’t allow me to accelerate much. Engine Electrical System, including the Charging and Starting System. Checked battery, alternator, and starter

NHTSA ID

11719791

Incident

Oct 4, 2025

Tailgate opening automatically

NHTSA ID

11718071

Incident

Feb 13, 2026

Dear Sir or Madam, I am writing to formally report a safety-related defect involving the power unlatching tailgate switch on my Chevrolet 1500 truck and to request that this make and model be added to the current safety recall affecting Chevy HD vehicles. The power tailgate unlatching switch malfunctioned and would repeatedly attempt to open and close the tailgate while the truck was parked. On one occasion, this occurred continuously overnight. The following morning, my key fob was completely unresponsive, and the truck had zero battery life. The battery would not accept a charge, and the vehicle had to be towed to the dealership. Upon inspection, the dealership confirmed that the battery had been fully depleted and permanently damaged due to a short in the power tailgate switch. The faulty switch continuously drew power as it attempted to actuate the tailgate, ultimately destroying the battery. This failure created a serious safety and reliability concern, leaving me stranded with a completely inoperable vehicle. Given that this issue resulted from an electrical short and caused total battery failure, I believe it represents a significant safety defect. Based on the similarity to issues addressed in the current Chevy HD safety recall, I strongly believe this make and model should be included in that recall. I respectfully request that this matter be reviewed and addressed to prevent other owners from experiencing the same hazardous situation. Thank you for your time and attention to this matter. I look forward to your response. Sincerely, Charles Senn

NHTSA ID

11712365

Incident

Jan 15, 2026

The contact owns a 2023 Chevrolet Silverado 1500. The contact stated that the tailgate was constantly opening unintendedly. The failure also occurred while the vehicle was parked overnight, causing the battery to drain. Additionally, the contact stated that the rearview camera was inoperable. The vehicle was taken to the dealer, where it was diagnosed, and determined that the tailgate switch and rearview camera had failed due to water intrusion. The dealer replaced the tailgate switch; however, the rearview camera was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 38,000.

NHTSA ID

11710861

Incident

Dec 14, 2025

Mileage

38,000 mi

The contact owns a 2023 Chevrolet Silverado 1500. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING), but the failure occurred. The contact was informed by the dealer that the vehicle had passed inspection, and the dealer added a higher viscosity oil, installed 6 oil fill caps, and replaced the oil filter. The contact stated that six months after the vehicle was repaired, there was an abnormal squeaking sound coming from the engine. The contact stopped at a gas station to refuel. Afterwards, the vehicle failed to restart, and there was smoke coming from under the hood. The contact stated that the engine had seized. The contact was at the gas station when the failure occurred. The vehicle was towed to a dealer; however, no cause for the engine failure was found. The contact was informed that the sound was coming from one of the drive belts. The vehicle was not repaired. The vehicle was then towed to another dealer, where it was diagnosed and determined that the abnormal sound was coming from loose bearings in the engine. The contact was informed that the engine needed to be replaced. The long block in the engine and the radiator were replaced on January 1st. The contact stated that a week after the vehicle was repaired, the vehicle failed to start. After several attempts, the vehicle restarted. The vehicle was taken back to the dealer. However, no cause for the failure was found. The dealer recharged the battery. The contact stated that shortly afterwards, the vehicle failed to start. The vehicle was taken back to the dealer, where it was diagnosed and determined that the starter had failed. The contact requested that the dealer check the ground strap, but the dealer refused. The vehicle remained at the dealer unrepaired. The contact stated that the dealer would notify the manufacturer of the failure. The approximate failure mileage was 44,469.

NHTSA ID

11709107

Incident

Dec 6, 2025

Mileage

44,469 mi

Tail gate has water intrusion and opens on it own. I was charge over $200 to have this issue looked at that I was told was a recall. Turns out my vehicle is not listed on the recall yet and was not advised before being charged.

NHTSA ID

11708292

Incident

Dec 21, 2025

While driving the vehicle the tailgate came open by itself. I had left my house and when I arrived at my friend’s house to pick him up the tailgate was down. I closed the tailgate and while driving a driver honked their horn to alert me that something was wrong. When I pulled off the road the tailgate had come open for a second time.

NHTSA ID

11707312

Incident

Dec 27, 2025