2023 Chevrolet Silverado 1500 Powertrain (other) Problems

I drive a 2023 Chevrolet Silverado 1500 3.0L Diesel with the 10-speed transmission. The transmission control software failed to monitor/detect valve body wear or trigger a 5th-gear 'limp mode' safety net, resulting in three separate instances of sudden rear-wheel lockup at speed. The dealer was unable to replicate the issue during a service visit from 6/10 - XXX. The issue was raised as the transmission was shifting increasingly badly leading up to this service visit. The first full lockup occurred a few days after receipt of the vehicle on XXX driving eastbound on [XXX]. Off the gas, coasting downhill. Once everybody started speeding up, I increased the throttle gently and the truck shook violently. I initially thought I had been hit by another vehicle but realized it was the transmission. Speed was noted 24 mph. The second incident occurred XXX while traveling to [XXX]. Driving southbound between [XXX] and [XXX] at approximately 50 MPH in a coasting condition. Went to pass a slow vehicle and the vehicle jerked violently an locked the rear wheels. Initial assumption was that I had been hit. Was able to regain control and continue. The third incident occurredXXX while traveling from [XXX] to [XXX]. Driving eastbound on [XXX] at approximately 35 mph, when moving from a coast to acceleration posture, the vehicle again locked the rear wheels and jerked violently. Finally, onXXX when traveling southbound from [XXX] to [XXX], I stopped for fuel. When attempting to accelerate onto the freeway, the vehicle failed to engage 6 gear, stumbled, and then went into limp mode with a check engine light. On XXX a [XXX] dealer found code P0747 and addressed the issue with [XXX]. I was forced to rent a car to continue my journey to [XXX]. GM ultimately shipped my truck back to me one week later. The software 'fix' clearly did not work as intended and remains a serious safety hazard. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11766750

Incident

Jul 2, 2026

This truck and hundreds, if not thousands of others has many issues with the electronic shifter. Not only do they frequently fail, but Chevrolet does not have any parts available to the dealerships for weeks. These Duramax 3.0 diesel engines are also a huge problem with the emission system and DEF. They constantly fail and we are spending thousands to repair. My truck is stuck at a dealership in [XXX]. I had to rent a vehicle to drive back home to [XXX]. The dealer has no idea how long it will take to get a shifter from Chevy. Is there any help available. Why aren't these shifters under a major recall? I am literally stranded after paying $65,000 for a truck! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11765693

Incident

Sep 12, 2026

While operating at highway speeds this truck lost all engine power and would not start back up. Vehicle was towed to local dealer and determined to be a catosrophic failure of the crank shaft. Repairs are being made as covered under warranty.

NHTSA ID

11763745

Incident

Sep 2, 2026

The engine in my 2023 Silverado ZR2 (6.2L L87 V8) failed. It is available for inspection at Rick Hendrick Chevrolet ([XXX]). On XXX at about 67,000 miles, and the days leading up to it, the truck repeatedly struggled to start due to metal on metal contact, almost leaving me and my family stranded multiple times. Driving the vehicle produced a loud rattling noise at 2200 to 2700 rpm, and felt unsafe to drive. Especially with my family. The problem was reproduced and confirmed to be an engine failure by the Rick Hendrick Chevy dealership a week after being dropped off with an appointment. I have been told the engine needs to be replaced under the special coverage program (N252494003). The L87 recall inspection and oil change was completed on XXX also by Rick Hendrick Chevy. There were not warning lights or other symptoms leading up to this engine failure. The symptoms of struggling to start and the ticking noise as 2200 to 2700 RPM started that weekend before I brought to dealership. They got progressively worse. Dealership has said I will receive a new engine under warranty but no timeline for completion. Additionally I have not been furnished with a service loaner or option for one. Leaving me with no vehicle to replace it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11762936

Incident

Aug 26, 2026

Engine failed and was replaced at 38k. Transmission shudders, have been back to dealership multiple times for transmission shudder, have been told it was tires, torque converter, and valve body. When those items didn’t fix the issue, I was told it was the engine dfm and that it was normal and not a problem, AFTER they had already acknowledged the transmission issue by trying to fix it with a torque converter and valve body. Engine failed again at 54,604 miles while at high way speeds in rush hour like traffic in between [XXX] and [XXX], while pulling a camper. Truck oiled down the interstate and produced a blueish/milky looking cloud that caused drivers behind me to lock up their brakes because of bad vision, creating a hazard. I was told by gm that they wouldn’t tow the camper that I had to take care of that but they wouldn’t tow send a truck for my truck. Tow truck gets there and says my truck is too big and leaves. I called my own rollback to get my truck 3 1/2 hours later and they came and got it. Was stranded on the side of the interstate for 4 1/2 hours in 90 degree weather, to my knowledge the 2nd truck gm was supposed to send never showed up. Requested a buyback and was denied with no reason given. I have a lot of records if anyone wants them. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11762363

Incident

Jul 17, 2026

I had the 6.2 engine replaced at 38k miles. Now at 78k miles my new engine replacement is using 1.5qrt of oil within 4k miles. I am being told i have to watch the oil every 800 miles and report back to Chevrolet. I feel my investment is completely a loss of $60,000.00 + . I was told by the service tech that i will probaly have to have another engine replaced again.. My resale value is NO WHERE near worth anything and I am stuck.

NHTSA ID

11761237

Incident

Aug 29, 2026

Description of the Problem: My 2023 Chevrolet Silverado 1500 has a recurring transmission issue involving hard shifting and shuddering during normal driving. The transmission frequently hesitates, clunks, or jolts when changing gears, especially at low to moderate speeds. These symptoms occur consistently and have worsened over time. Safety Concerns: The harsh gear engagement and shuddering make the vehicle difficult to control smoothly. It feels like something will break while I'm driving. The unpredictable shifting behavior feels unsafe in traffic, during merging, and when accelerating from a stop, or driving on the freeway. I am concerned this may be related to widespread transmission complaints reported by other 2023 Silverado owners, including valve body and TCM failures. Service History: I have not contacted my dealership regarding the issue. Why I’m Reporting: I believe this transmission behavior presents a potential safety defect. I am submitting this complaint so NHTSA can review it as part of ongoing monitoring of similar issues reported for this model year.

NHTSA ID

11759302

Incident

Aug 16, 2026

Hard shifting, Shuddering, clunking sound when shifting between drive and reverse. Was informed by Ken Ganley Chevy in Brookpark , Ohio that the valve body inside the 8speed transmission is faulty and is on a nationwide backorder.

NHTSA ID

11751526

Incident

Jul 20, 2026

I am filing a formal complaint regarding General Motors' handling of a critical vehicle component that has left my vehicle and many others in an unsafe condition. For more than over a one month, I have been waiting for a replacement gear shift module that is currently on backorder. During this time, I have learned that numerous General Motors customers are experiencing the same issue and are also waiting for this part to become available. My primary concern is that this appears to be more than an isolated parts shortage. If so many vehicles require replacement of the same safety-related component, General Motors should be evaluating whether this issue warrants a safety recall or, at a minimum, notifying affected customers of the potential risks. The gear shift module is a critical component that affects the safe operation of a vehicle. Allowing customers to continue driving vehicles that may have a defective gear shift module without providing a safety notification or timely repair raises serious concerns regarding public safety. I respectfully request that the NHTSA investigate this matter and encourage General Motors to: Explain the reason for the extended backorder of this critical component. Provide customers with a reasonable timeline for obtaining replacement parts. Determine whether this issue should be addressed through a formal safety recall or customer safety notification. Offer appropriate assistance to customers whose vehicles have been affected by this prolonged delay. Customers should not be expected to operate vehicles that may present a potential safety risk while waiting indefinitely for a critical replacement part.

NHTSA ID

11750864

Incident

Jun 17, 2026

While shifting my vehicle from Park, a "Service Transmission" warning message appeared on the dashboard. The warning would illuminate and then disappear, but the vehicle continued to shift into the other gears. At the time the issue occurred, my truck had only 47,000 miles. I brought it to Blasius Chevrolet in [XXX] on XXX, for diagnosis. The dealership determined that the Transmission Control Assembly (Part # XXX) had failed and needed to be replaced. I was informed that this repair was not covered under the powertrain warranty because Chevrolet considers the Transmission Control Assembly to be excluded from powertrain coverage, and my basic warranty had already expired. I was quoted more than $900 for parts and labor. Initially, I was told the replacement part would arrive within a few days. Later, the technician stated that other Chevrolet dealerships had the part in stock. However, after contacting those dealerships, he was told they would not release their inventory. Chevrolet then advised that the part was on national backorder, with the earliest estimated availability of XXX. As a result, I have been without my truck for approximately one month, creating a significant hardship. After researching this issue, I found numerous reports from other Chevrolet owners experiencing the same failure involving the Transmission Control Assembly. The apparent frequency of these failures, combined with the nationwide backorder of the part, suggests this may be a widespread defect rather than normal wear and tear. I believe Chevrolet should either: Cover this repair under the powertrain warranty, as it directly affects the operation of the transmission, or Issue a recall or warranty extension if this is determined to be a common defect affecting vehicle safety and reliability. I am submitting this complaint because I am concerned that a failure of the Transmission Control Assembly could impact the safe operation of the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11748458

Incident

Jun 9, 2026

MOMENTARY WHEEL LOCK UP. ENGINE WARNING LIGHT CAME ON. Safety warning not to drive as could cause catastrophic damage to transmission. Same symptoms as noted on update GM bulletin N242454441. 12/24. Only extends warranty 2020- 2022 models up to 150,000 miles. Gen 3 Transmission Control Valve appears to be the fix... My vin not included in the extended mileage. I just turned 62,000. Just out of Standard Warranty.

NHTSA ID

11747259

Incident

Jun 28, 2026

When merging onto the interstate, the vehicle lost ability to shift, started lurching and would not accelerate. No prior transmission issues had occurred and the sudden loss of shifting capability was a significant safety risk. This was GM Case# 89525980 The Transmission Valve body assembly was faulty and gave out with no warning. It had to be towed into the GM dealer and repaired for $2519.79

NHTSA ID

11746739

Incident

Feb 26, 2026

“Service transmission now unable to shift soon” message. Vehicle is stuck in park. Message appeared in May. Transmission stuck shortly after. Safety is at risk due to transmission being unable to shift due to faulty module that is widely reported and known to Chevrolet.

NHTSA ID

11745313

Incident

May 26, 2026

My 2023 Chevrolet Silverado 1500 experiences an intermittant, uncommanded mechanical drivetrain lockup and severe binding when accelerating from a complete stop. The vehicle rolls fine in a straight line for several feet, but the exact moment the steering wheel is turned slightly (a couple degrees), the drivetrain violently binds up. This creates resistance in the steering and acceleration, as well as a severe physical and audible metallic clunking slam and massive shockwave vibrations felt directly through the steering wheel, floorboards, brake/gas pedals, and driver’s seat. During the last event, the vehicle threw a "Service 4 Wheel Drive" dash message and refused to shift out of "Auto" mode back into 2WD. Because this is a pure mechanical interference/binding issue, it does not consistently throw active electronic trouble codes. A standard OBD2 code scan will show nothing. After turning the vehicle off for several hours and testing again, the problem persisted. After towing the vehicle to a dealership (6/10/2026) it sat for at least 5 days before dealership service looked at it. By this time, the active warning lights cleared. My initial servicing dealership refused to perform physical hardware or fluid diagnostics under my factory warranty, stating they would not look at the vehicle unless I paid $860 out-of-pocket or until the drivetrain "completely grenaded" on the road. Because this uncommanded lockup restricts my ability to steer the vehicle safely from a stop, it presents an immediate crash hazard. At the direction of General Motors Corporate, I am escalating this issue and moving the vehicle to a secondary certified facility (Feldman Chevrolet of Novi) on June 23, 2026, for a formal physical hardware and fluid tear-down inspection.

NHTSA ID

11745032

Incident

Jun 10, 2026

6/12/26 ( 2023 Chevy Silverado - 6.2 liter engine) While driving at approximately 40 MPH on a two lane road, the truck shut off. After multiple attempts, the engine failed to restart. The transmission locked up in park and would not release. This required the truck to be dragged up on the flat bed wrecker instead of rolling freely. Prior to this instance there have been several issues with the electrical system. 1. radio sound shuts off. does not come back on. 2. Head lights stay on for 10 minutes after vehicle is turn off. 3. Tail gate opens on it own. Tail gate doesn't open with fob. 4. door locks fail to operate correctly. 5. When drivers door is opened a beeping sound starts and doesn't stop until door is closed. I have reported these problems to GM & have two case numbers. The dealership reports that the 6.2 replacement engines have had multiple failures.

NHTSA ID

11744988

Incident

Jun 12, 2026

ON MONDAY, 6/15/26, WITH APPROX 45,400 MILES, I WAS DRIVING DOWN THE ROAD AND TRUCK SAID SERVICE TRANSMISSION. THE GEARS WOULD SHIFT, BUT IT LAGGED A LITTLE BIT. I SCHEDULED AN APPT FOR TWO DAYS LATER, AND ONLY DROVE IT WHEN I ABSOLUTELY HAD TO, WHICH WAS ONLY TWICE BEFORE MY SCHEDULED APPT. I GET IN IT TO DRIVE AND IT SAYS SERVICE TRANSMISSION- UNABLE TO SHIFT SOON, THEN ON MY WAY TO THE DEALERSHIP, IT SAYS ALL OF THAT, PLUS SERVICE DRIVER ASSIST SYSTEM. CHAVY'S QUALITY ASSURANCE TEAM NEEDS TO GET IT TOGETHER! THIS IS ABSOLUTELY RIDICULOUS.

NHTSA ID

11744715

Incident

Jun 15, 2026

The entire engine was replaced at 5 miles due to catastrophic failure. Work was performed by Ciocca Chevrolet in Atlantic City New Jersey

NHTSA ID

11743098

Incident

Jul 15, 2024

At approximately 24,000 miles the engine had catastrophic failure under normal street/highway driving conditions. The engine is the 6.2L V8. The issue began with a high pitch squeal or chirping sound and noticeable power loss. I parked the truck over night and then drove it to the dealer first thing the next morning. While on the way to the dealership, which was less than 20 miles away, the engine began having much bigger issues. A loud knocking noise was apparent and the rear end began locking up causing the tires to also lock up. Once at the dealership the engine completely failed and locked up. The engine did have the newly recommended 0W-40 oil installed prior to the failure.

NHTSA ID

11742690

Incident

May 13, 2026

Transmission went out while driving on highway, entering limp mode. Ended up needing a valve body replacement at only 20k miles which was covered, but now I am having more transmission issues still with delayed forward engagement and slipping gears and it is only at 65k miles. Seems to be a lot of customers having the same issue. Took months for the truck to be fixed as "many other trucks" were waiting on the same part according to dealership.

NHTSA ID

11740916

Incident

Aug 7, 2024

The contact owns a 2023 Chevrolet Silverado. The contact stated while driving at approximately 40 MPH, the vehicle stalled, the brakes were inoperative, the gear shift was stuck in drive, and all of the doors and windows were locked and inoperative. The check engine warning light was illuminated and the "please restart the engine" message was displayed on the instrument panel. The vehicle was taken to a dealer where it was diagnosed that the fuel pump regulator module needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 373200.

NHTSA ID

11735899

Incident

May 2, 2026

Mileage

373,200 mi

Vehicle has experienced repeated electrical and safety system failures since purchase in 2023. Affected systems include forward collision warning, blind spot monitoring, parking sensors, cameras, and infotainment. Failures include complete loss of camera functionality (rear and front), infotainment system shutdowns or resets while driving, loss of audio, and volume malfunctioning (including sudden increases or no response). The vehicle has also generated false safety alerts, including forward collision warnings and blind spot alerts when no hazard was present. These issues have occurred while the vehicle was in operation, creating safety risks due to loss of visibility systems and unreliable warning alerts. In multiple instances, the system would become completely non-functional for extended periods, sometimes lasting days or weeks, before temporarily returning. The problem has been reported to a dealership multiple times and has been inspected and serviced. Repairs have included software updates and component-related work; however, the issues have continued to persist or reoccur. The failures are intermittent but recurring and have not been permanently resolved despite multiple repair attempts. The condition reduces driver confidence and creates unsafe operating conditions due to unreliable safety systems and loss of critical features while driving.

NHTSA ID

11732877

Incident

Dec 16, 2023

The contact owns a 2023 Chevrolet Silverado 1500. The contact stated that while driving 65–70 MPH, there was an abnormally loud sound coming from the vehicle. Several unknown warning lights were illuminated. The contact attempted to pull over to the shoulder of the road, but the vehicle lost automotive power. Additionally, the engine had seized. The contact stated that while attempting to start the vehicle, the vehicle failed to restart. The vehicle was towed to the dealer; however, the vehicle was not inspected. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. In addition, the contact stated that the gear shifter failed to shift to neutral. The failure had occurred while driving on a busy highway and created an unsafe driving condition. In addition, the contact stated that New York State Troopers assisted with the traffic control. The manufacturer was made aware of the failure. The failure mileage was approximately 47,000.

NHTSA ID

11732366

Incident

Apr 16, 2026

Mileage

47,000 mi

Transmission has jerked/bumped in past and now at approx 85K miles, it supposedly needs a new transmission. I've heard it is a pretty big issue and seems llike relatively low mileage for this to be happening to 2023 year model. I certainly don't drive it hard and rarely tow or haul heavy loads.

NHTSA ID

11731254

Incident

Apr 12, 2026

One day the trucks transmission started to struggle to find the next gear after taking off from a light. The next morning it did it again and that night did it a third time. The third time it about brought the truck to a stop at 30 mph and made a bang noise, in which a check engine light came on and a message saying speed limited and drive with caution. The truck only has 20,000 miles and already is having transmission issues, which is just unacceptable.

NHTSA ID

11730790

Incident

Mar 22, 2026

At cold start vehicle often required several seconds for the transmission to engage before moving. After traveling at highway speed (45+ MPH) vehicle began to make clunking noise as if the transmission were changing gears but it was not and the RPMs on the tachometer did not change. Instances became worse and more frequent over 6 month period, vehicle never displayed any codes and no notifications or check engine/transmission lights on driver information center. Took vehicle to O’Fallon Buick GMC and was advised torque converter and transmission valve body had failed and needed replaced. I inquired about ongoing issue with this vehicle based on my findings online and was told it was not a recall issue at this time. Truck has 74,000 miles and service records for all maintenance to date.

NHTSA ID

11727864

Incident

Mar 26, 2026