2012 Chevrolet Volt

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

In September 2019, the Office of Defects Investigation (ODI) opened PE19-013 to assess the potential safety related effects of a malfunction of the Passenger Sensing System (PSS) in 2012-2013 Model Year (MY) Chevrolet Volt vehicles. Consumers reported that due to a malfunction of the PSS, the air bag system malfunction indicator light (MIL) was activated. Many of the complaints noted the malfunction occurred after the warranty period expired and mentioned high repair costs as a major deterrent to the repair of the vehicle.The PSS sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the frontal passenger air bag. The PSS may develop a malfunction due to bunching of the sensor mat in the seat trench. The bunching of the sensor mat could cause the mat to repeatedly fold in the same location. Over time, the repeated folding can cause an increased resistance in the sensor mat. An increased resistance in the PSS sensor mat is detected as a fault in the air bag system diagnostic. If this fault is detected, a diagnostic trouble code will be stored in the air bag control unit and the air bag MIL will illuminate.Further, if the fault is detected, the passenger frontal and knee air bags will be suppressed in a crash of sufficient severity to warrant a commanded deployment regardless of the nature of size of the occupant of the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the PSS sensor mat. Reports alleging only that the air bag light is on with no cause stated, or where a different cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than a PSS malfunction.The subject vehicles have been in service for approximately ten (10) years. An analysis of General Motors (GM) warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar occupant detection system failure investigations, indicates the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.GM has instituted a cost reduction program for the repair/replacement of the PSS in the subject vehicles. Based on this cost reduction program as well as:1) a comparatively low warranty rate; 2) no reported injuries, deaths or asymmetric deployments; and 3) the age of the vehicles; ODI is closing this Preliminary Evaluation. The closing of this investigation does not constitute a finding by NHTSA that a safety related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.

The subject vehicles, which employ emerging technology, are range-extended electric vehicles that utilize a high voltage (HV) battery to provide energy for propulsion. The HV battery is lithium-ion based technology that has a nominal full charge of 390 VDC, a 16 kWh capacity, and a control system that incorporates liquid (antifreeze) cooling and various electronic devices (control modules, sensors, wiring, etc) to monitor and manage the HV battery. The HV battery, portions of the cooling system, and the control system are contained within a common enclosure.During an NCAP oblique side pole impact test conducted by NHTSA in May 2011, the pole struck and deformed the sill plate under the driver's door at a location where there is a structural member. The lateral member displaced inward, pierced the HV battery enclosure and battery, and caused a battery coolant leak. Thereafter, the Agency conducted a rollover test (the rollover test consists of four 90-degree rotate-and-hold movements about the vehicle's longitudinal axis). In that test, the HV battery and electronics were exposed to coolant that leaked as a result of the crash. The vehicle fire that occurred three weeks later and the additional testing NHTSA conducted are discussed in a report titled 2011 Chevrolet Volt Battery Fire Incident Report a copy of which is available in the public file. The report indicates that intrusion induced coolant leakage, and subsequent rollover that saturates electronic components, were the only test conditions which resulted in a subject vehicle HV battery fire.GM announced its intention to conduct a free-of-charge customer satisfaction campaign (CSP) on the subject vehicles on January 5, 2012. The action affects 14,735 vehicles produced prior to December 21, 2011. The CSP addresses three areas related to the issue under investigation. The first involves a modification/strengthening of the structure of the vehicle in the area where battery intrusion occurred in the May 2011 test. The second involves adding a sensor that detects excessive HV battery coolant loss, and control system software that then alerts the driver and prevents recharging of the HV battery. When the battery cannot be recharged, it will be depleted to a lower energy state as the vehicle continues to operate on the internal combustion engine. Lastly, a tamper-proofing device will be added to the system to prevent consumers from adding coolant. GM discusses these revisions in its response to an Information Request (IR) issued by NHTSA, noting that vehicles produced in calendar year 2012 and later will be manufactured to this condition.In December 2011, and at the same test facility, NHTSA repeated the May 2011 side impact test using a model year 2012 Volt modified to the structural condition described in the CSP. The test did not produce intrusion of the HV battery, a coolant leakage, or a fire (see test 7611, available at www.nhtsa.gov/Research/Databases+and+Software). In its IR response, GM describes four (4) additional side impact tests of modified subject vehicles it recently conducted using various build configurations and impact speeds (including higher speeds). GM reports that none produced HV battery intrusion, coolant leakage, or a fire.As noted in the complaint counts above, ODI has not identified a crash occurring in consumer's use of the vehicle that has resulted in a vehicle fire, or produced coolant leakage. ODI notes that side impact crashes with pole-like structures, such as would strike the sill plate, occur fairly infrequently, and such crashes with rollovers are even less frequent. A defect trend has not been identified at this time, and further investi

The contact owns a 2012 Chevrolet Volt. The contact stated that while the vehicle was parked and occupied, the contact attempted to start the vehicle; however, the instrument panel displayed a blank screen. An independent mechanic was contacted. The vehicle was taken to an independent mechanic to be diagnosed, and the contact was informed that the instrument cluster needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 132,000.

NHTSA ID

11746435

Incident

May 25, 2026

Mileage

132,000 mi

Message on dash "Service High Voltage charging system" . Code cleared by inexperienced mechanic. Stalled on the side of the road with "Engine not available" , "Low propulsion" . My local Chevy dealership confirmed a high volt battery leak its now at risk for catching on fire

NHTSA ID

11742075

Incident

May 26, 2026

Car will randomly accelerate when not on gas pedal and/or a delay in brakes working. Has happened on more than one occasion.

NHTSA ID

11724225

Incident

Mar 9, 2026

The contact owns a 2012 Chevrolet Volt. The contact stated that the vehicle failed to start, and the lights inside and outside of the vehicle failed to illuminate. The vehicle was jump-started. The failure reoccurred while attempting to restart the vehicle, and the contact was unable to drive the vehicle. The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was unknown.

NHTSA ID

11712016

Incident

Jan 18, 2026

Airbag sensor failure in seat.

NHTSA ID

11686813

Incident

Sep 11, 2025

passenger presence detection system is malfunctioning, and causing a "service airbag" warning. This is a huge safety issue that could be detrimental or deathly in the event of an accident. This is a common issue among generation 1 volt owners, and should be considered for a recall or warranty coverage. The passenger presence detection system parts are discontinued, and even if I found the part the dealership cannot confirm for the pricey repair, that the airbag / sensor will not simply malfunction again -- which makes this a persistent safety concern and huge owner inconvenience to say the least.

NHTSA ID

11644947

Incident

Feb 25, 2025

Vehicle over-revs in cold weather. Engine runs excessively fast (4250 RPM) at highway speeds and around 3000 RPM when just sitting. Often times if I pull over and restart the car it will correct itself. This results in MPG as low as 22. The internet is full of examples of people with the exact same problem. I have seen no examples of the problem being solved. The engine will operate correctly in warmer weather (above 50° F). I believe it is related to an aging propulsion battery and could be solved by improved programing to accommodate the battery state.

NHTSA ID

11630028

Incident

Nov 1, 2018

THE CONTACT OWNS A 2012 CHEVROLET VOLT. WHILE DRIVING AT THE SPEED OF 70MPH THE INSTRUMENT PANEL BECAME INOPERABLE WITHOUT WARNING. AS A RESULT, THE CONTACT WAS UNABLE TO DETERMINE THE SPEED OF THE VEHICLE, ALONG WITH THE AMOUNT OF FUEL THAT WAS INSIDE THE VEHICLE OR ANY WARNING LAMPS. THE INCIDENT HAPPENED WITH THE VEHICLE HAVING 99,835 MILES.

NHTSA ID

11607202

Incident

Jul 1, 2024

This preliminary information communicates information about how to determine if a wheel and tires size change is available.

This Preliminary information communicates the steps on how to save a GDS2 Session Log and upload to a Technical Assistance Case in CX Connect.

This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.

This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.

This Preliminary Information communication provides information to the technician about vehicles that have had multiple repair attempts that are being performed on customer’s vehicles that exhibit vibration conditions without utilizing the support of General Motors Technical Assistance Center. If valid vibration frequency or Road Force Variation data has been collected and a repair attempt does not correct the customer complaint, contact General Motors Technical Assistance Center for further support. For any vehicles that remains unrepaired after being at the dealer for three days or more and a related bulletin or PI is not found, contact General Motors Technical Assistance Center for further support.

This engineering informational bulletin provides process for a GM engineering study on curtain Takata Airbag Steering Wheel Modules and needs the used Takata airbags to be returned to GM.