2012 Subaru Impreza

The Office of Defects Investigation opened this investigation on April 10, 2015 based on 26 Vehicle Owner Questionnaire reports involving the passenger frontal air bag in MY 2012 Subaru Impreza vehicles.These vehicles use a capacitive type Occupant Detection System (ODS), which is intended to classify the occupant of the passenger seat as either full sized, small stature, a child seat, or other object.The reports alleged that the ODS failed to operate properly and incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied.In a frontal crash sufficient to warranty deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On June 25, 2015, Subaru of America, Inc. submitted a Defect Information Report (DIR) advising NHTSA that it would conduct a safety recall to remedy the ODS in 32,400 MY 2012 Subaru Impreza vehicles equipped with a capacitance type ODS for the front passenger's seat.The DIR notes that the WRX/STI models are excluded from this recall as they are equipped with a different type (weight-recognition based) ODS for the front passenger's seat. ODI is closing this investigation based on Subaru's recall action.The ODI reports cited above can be viewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following ID numbers:10668512, 10668243, 10662987, 10641835, 10640574, 10626384, 10622234, 10621456, 10619273, 10605789, 10604506, 10575908, 10559081, 10557856, 10556661, 10545059, 10538562, 10532118, 10481308, 10478660, 10473662, 10472608, 10470865, 10468157, 10463432, 10672345, 10712288, 10713178, 10731645.

My ignition key gets stuck when I shifted into park on my 2012 subaru impreza.

NHTSA ID

11739696

Incident

May 22, 2026

The fan controls in the center of the dash failed. Fan speed 1&2 work, but 3&4 do not. After pulling the center dash controls out, I found that the plug connecting the fan speed controls to the wiring harness was burnt. This is a concern cause it could have burned other components or caused a fire.

NHTSA ID

11682604

Incident

Jun 1, 2025

HVAC plug pigtail Blower motor resistor Heater control harness Is available for inspection HVAC electrical plugin was badly burned and melted causing risk of fire Summer months created dangerous interior temperatures Winter months & inclement weather created physical distress- & created dangerous vision restrictions/blockage because unable to use defroster Dangerous cab temperatures, limited or blocked vision through windshield created physical distress and distraction for me thus others and property were at elevated risk Yes confirmed by garage. No inspection performed. No warnings available. There are 2 separate incidents: July 2023/august 2023 September 2024/april 2025

NHTSA ID

11661254

Incident

Jul 1, 2023

The contact owns a 2012 Subaru Impreza. The contact stated while driving at an undisclosed speed, the brake pedal was depressed and went to the floorboard. The vehicle failed to stop immediately. The brake warning light was illuminated. The vehicle was taken to an independent mechanic, who determined that the control arms and brake lines were severely corroded and needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 14V311000 (Service Brakes, Hydraulic); however, the VIN was not included in the recall. The manufacturer was made aware of the failure but informed the contact that there was no recall associated with the VIN. The failure mileage was approximately 126,000.

NHTSA ID

11648309

Incident

Mar 12, 2025

Mileage

126,000 mi

The contact's son's father owns a 2012 Subaru Impreza. The contact stated that upon activating the heating system, a burning odor would emit from the vehicle without warning. The vehicle was taken to a dealer where the mechanic discovered melted plastic; as well as black soot, inside the vehicle's instrument panel and harness blower resistor. The contact stated that an unknown fuse and the heater motor were replaced; however, the failure returned. The vehicle was taken to a second dealer(Prestige Subaru of Turnersville NJ) where a diagnostic was performed and the contact was given an estimate for the repair. The vehicle was not repaired. The contact reached out to the manufacturer but was offered no assistance. The failure mileage was approximately 129,173

NHTSA ID

11640388

Incident

Aug 1, 2021

Mileage

129,173 mi

The contact owns a 2012 Subaru Impreza. The contact stated that while driving approximately 30-40 MPH, the vehicle lost power steering functionality and was driven with manual steering. The failure occurred while driving at various speeds. The contact stated that approximately four days after the first failure, the steering wheel failed to move. Additionally, the vehicle was losing oil and one quart of oil had to be added every month. The contact stated that the power steering, ABS, TPMS, transmission automatic transmission fluid (ATF), and 4-WD failure warning lights were illuminated. The passenger occupant sensor chimed for the passenger to secure the seat belt consistently even though the occupant was seated with the seat belt buckled securely. The contact who is a certified mechanic had replaced the rack and pinion. The contact noticed that the threads on the tie rods were close in proximately risking the chance of damaging the tie rods. The ABS module had been replaced. The contact believed that the engine needed to be replaced but the engine was not replaced. The manufacturer was made aware of the failure and opened a case. The manufacturer confirmed there was no recall for the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 164,964.

NHTSA ID

11640376

Incident

Jan 31, 2025

Mileage

164,964 mi

The Airbag warning light has been lit within the dashboard. The front passenger seat airbag is faulty and is not able to correctly sense when a passenger is within the seat or not, which disables the airbags. This can be deadly to the passenger if in an accident. The issue seems to be in the ODS passenger seat mat that determines when the airbag is active or not. If moisture is able to get within the mat, then it can short the circuit and cause airbags to not deploy. My car was "supposed" to already been fixed with the issue in 2015 on the recall #WQT55, NHTSA Campaign 15V419000, but I don't believe the underlying issue was fixed correctly or the same part has failed again. Looking further into recalls, the exact same issue is happening again with Subarus with #WRA-24 and NHTSA campaign 24V227. The dealer has asked me to pay over $1700 on to replace this part. Subaru America should fully cover the cost of any Passenger ODS issue especially when there have already been two recalls with the exact same issue.

NHTSA ID

11634194

Incident

Feb 1, 2022

The AC unit suddenly shutoff and there was a burning smell while I was driving. It turns out that the connector on the back of the climate control unit had either drawn too much current, or the resistance was too high, and the connector had started burning. Fortunately, the melted plastic interrupted the electrical connection, and the fire had went out on its own. It looks like this is not an isolated incident, and several others have dealt with similar when looking online.

NHTSA ID

11633290

Incident

Dec 7, 2024

This announcement is requesting retailer staff to retain the EyeSight protective hood covers from Generation 4 EyeSight cameras.

This bulletin announces a design change made to the CVT Control Valve Body which incorporates an enhanced valve sleeve to improve durability. (This is an revised version of the orignal bulletin.)

This bulletin contains additional information for recommended materials listed in the Service Manuals for individual models.

This bulletin announces a design change made to the CVT Control Valve Body which incorporates an enhanced valve sleeve to improve durability.

This announcement provides information on the remanufactured CVT transmission program.

This Service Information Bulletin was developed to provide interim guidance for vehicles exhibiting DTC B2A20.