2024 Subaru Impreza

While driving at various speeds, my vehicle consistently produces a clicking noise from the upper right-rear C-pillar area. The noise is most noticeable when the vehicle body twists slightly during normal driving, such as when traveling over uneven pavement, entering driveways, or making turns. The condition has persisted and is repeatable. The vehicle was inspected over approximately six weeks by an authorized dealership. After extensive diagnosis, the dealership identified a suspected welding defect in the upper right-rear C-pillar/body structure. The suspected defective area is available for inspection. The dealership requested authorization from the manufacturer to repair the condition under warranty, but the request was denied. To my knowledge, neither the manufacturer nor the dealership has provided any engineering analysis or technical evidence identifying an alternative root cause for the suspected welding defect. The C-pillar is a structural component of the vehicle that contributes to body rigidity and occupant protection. If the clicking noise is caused by a defective or failed body weld, the condition could indicate reduced structural integrity or progressive deterioration over time. Although no crash or injury has occurred, I am concerned that continued operation with a suspected structural weld defect could compromise vehicle safety or crashworthiness. No warning lights or diagnostic messages were displayed before or during the occurrence of this condition. The primary symptom has been the repeatable clicking noise from the upper right-rear C-pillar area during normal driving. I am requesting that this condition be investigated to determine whether it represents a manufacturing defect that could affect other vehicles of the same model.

NHTSA ID

11751421

Incident

Apr 16, 2026

On Sunday July 5th at approximately 4:10pm The vehicle experienced an unexpected Pre-Collision Braking activation at approximately 25 mph. A vehicle was approximately 40 feet ahead and there was no imminent collision. The vehicle automatically applied the brakes aggressively.

NHTSA ID

11748394

Incident

Jul 5, 2026

My base level 2024 Subaru Impreza , while driving, has a vibration and shake in the drivers side rearview mirror at speeds over 25 mph, making it difficult to see clearly behind my vehicle. Vibration was present as a new vehicle and have reported issue to service advisor at Sport Subaru of Orlando Florida as a new vehicle owner.

NHTSA ID

11731863

Incident

Sep 30, 2024

The fuel tank is leaking at molded seam making the vehicle undriveable and a fire safety hazard. Contacting dealer Monday morning.

NHTSA ID

11730588

Incident

Apr 11, 2026

My entire dash went out. Nothing worked. This car has only 3500 miles on it. I got danger signs and it said to stop driving the car. Danger. I also got messages in my e-mail I think from Starlink to stop driving the car and bring it in to service. It was dangerous. Service had it for two weeks. They didn't know what to do. They asked if I did something with wires. I'm a [XXX] woman and4'10". What a question. Then some guy at Subaru said "they'll probably have to put a whole new dash in. Days later I called again.Another guy said they had to call all over America to try and find the part. No one to my knowledge has inspected this. I am working with Subaru Customer Care. I don't want this car. I do not feel safe in it.For something so new these emergency problems should not be happening. I want a cash back or give me another car.They had it for two weeks and gave me no explanation what happened. It is not a safe car. I hope Customer Care will help me. Someone has to. I don't want this car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11727613

Incident

Mar 13, 2026

225 40 r18 all four of my tires have a crack thats on the side wall that goes around the whole tire took it to my dealership and they said that it was defective and that i couldn't drive my vehicle like that

NHTSA ID

11724807

Incident

Mar 13, 2026

Mileage

32,583 mi

I own a 2024 Subaru Impreza (base trim, FB24 engine). The engine has developed repeated oil leaks into the spark plug wells due to failed spark plug tube seals / valve cover sealing on the same engine. The first occurrence was around 24,000 miles. The dealer found engine oil in the spark plug tubes, diagnosed leaking spark plug tube seals (and/or valve cover gasket), and performed repairs under warranty. At that time, the car was relatively new and maintained on schedule. The second occurrence happened again around 30,000 miles. The dealer again found oil in the spark plug tubes, indicating repeat failure of the same type of seals on this low‑mileage engine. This has already happened twice within approximately 6,000 miles on a 2024 vehicle. Oil in the spark plug tubes can cause misfires, rough running, and potential damage to ignition coils and the catalytic converter. It also raises concerns about stalling or loss of power if the misfires worsen while driving. I am concerned that this may be a systemic defect in the FB‑series engines used in late‑model Subaru vehicles, not normal wear. I am requesting that NHTSA track this issue as a potential safety‑related defect involving engine sealing components (spark plug tube seals / valve cover gaskets) that allow engine oil to leak into the spark plug wells on 2024 Subaru Impreza models at low mileage.

NHTSA ID

11722134

Incident

Mar 4, 2026

PART 4 SUBARU STRUT ISSUE How come no one can tell me what’s actually wrong. Was this a faulty part or was it not installed correctly, who knows, no one can tell me. The strut was loose and I could hear it rattling or jolting on many occasions before I knew that’s what it was. Was it not torqued to specs, installed in hurry, or defective part. They had my car for atleast a week the first time, so why not take the time to fix it right. The fact remains though, the problem was never initially fixed. You again let me drive an unsafe vehicle which caused premature wear on the tire, and god knows what else. On multiple occasions of inspections you said you found nothing or the vehicle was fine, when it wasn’t. This has created anxiety for me when driving my car, and visiting your facility. I don’t feel comfortable or trust this dealership, service department, or any staff there. I can feel the awkwardness with every visit and the bias that has now been created, but I did not create it, all I did was document and report my experience. Let my complaint serve as record and as a reference for any future complaints, investigations, or similar concerns that others may report.

NHTSA ID

11713925

Incident

Dec 12, 2025

This bulletin announces the design change made to the high-pressure fuel pump developed to prevent DTC P0087 (Fuel Rail/System Pressure – Too Low Bank 1). (This is an revised version of the original bulletin.)

This bulletin provides new diagnostic steps for DTC P0851 and P0852 to be used in conjunction with the applicable Service Manual.

This bulletin announces the diagnostic procedure to be performed before the service manual.

This bulletin outlines a repair procedure to be performed if DTC B2781 is set in the steering lock control module.

This bulletin provides instruction for use (FOTA) of a new reprogramming procedure to optimize the Denso Gen 4.5 Audio and Navigation system utilized in the models listed. (This is an revised version of the original bulletin).

This bulletin provides updated parts information and a service procedure to follow for removing accumulated carbon deposits from fuel injectors and internal engine components (e.g. intake valves and / or manifold, and combustion chambers). (This is an revised version of the original bulletin.)