1995 Chrysler Concorde

ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.

THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.

MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.

There is no summary currently available

FUEL LEAKING ONTO INTAKE MANIFOLD. FAULTY (LEAKING) FUEL RAIL.

NHTSA ID

10862940

Incident

Apr 5, 2016

Mileage

133,077 mi

RECALL 790 WAS PREFORMED IN 1999, (A PATCH WAS INSTALLED ON A FUEL RAIL). MARCH OF 2016 THE FUEL RAIL BEGAN LEAKING AND I TOOK THE CAR TO A FORMER CHRYSLER REPAIR GARAGE, (GRAFT, SCOTTDALE, PA 724-887-7800) WHERE THEY FOUND THE RECALL PATCH FAILED AND I HAD TO HAVE A NEW FUEL RAIL INSTALLED. THE SERVICE MANAGER, [XXX] INFORMED ME I SHOULD CONTACT CHRYSLER SINCE THE RECALL REPAIR OF 1999 FAILED AND APPLY FOR REIMBURSEMENT. I CONTACTED CHRYSLER AND THEY TOLD ME DESPITE THE REPAIR OF 1999 FAILING THIS YEAR RECALLS HAVE AN EXPIRATION! THAT IS NOT TRUE ACCORDING TO MULTIPLE DEALERS I'VE CONTACTED. THE REPAIRS FOR THE FAULTY FUEL RAIL COST ME $366.00 AND CHRYSLER REFUSES TO ASSIST. I CAN BE REACHED AT [XXX]....[XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10862012

Incident

Apr 5, 2016

IN A "PANIC STOP " SITUATION THE ABS CONTROLLER MODULATED AND REDUCED VERY SIGNIFICANTLY THE BRAKING EFFORT WHEN THE DRIVER SLAMMED ON THE BRAKES ON DRY PAVEMENT. WHILE BRAKING THE DRIVER ALSO MANEUVERED INTO THE K RAIL TO REDUCE SPEED AND ALMOST AVOIDED A COLLISION. THE AIR BAGS DID NOT DEPLOY AND WERE NOT NEEDED AS THE FINAL CRASH WAS AT LOW SPEED.

NHTSA ID

10747959

Incident

Jul 31, 2015

Mileage

153,611 mi

RUSTED BRAKE LINES CAUSED BRAKE SYSTEM TO FAIL. *TR

NHTSA ID

10552620

Incident

Nov 14, 2013

Mileage

88,000 mi

TL* THE CONTACT OWNS A 1995 CHRYSLER CONCORDE. WHILE ATTEMPTING TO TURN THE STEERING WHEEL, THE CONTACT HEARD A LOUD POP AS THE STEERING WHEEL STARTED SPINNING UNCONTROLLABLY. AFTER INSPECTION, HE NOTICED THAT THE TIE ROD BOLT WAS FRACTURED ON THE STEERING RACK. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE NOR WAS THE VEHICLE DIAGNOSED OR REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 130,931. THE VIN WAS UNAVAILABLE.

NHTSA ID

10432604

Incident

Oct 22, 2011

Mileage

130,931 mi

TRANSMISSION FAILURE, I READ THAT CHRYSLER HAD A RECALL ON TRANSMISSIONS FOR THE 95 CHRYSLER CONCORDE, DUE TO SHIFTING PROBLEMS, MY 95 CHRYSLER CONCORDE, DROVE FINE AND THEN SUDDENLY STOPPED, IF I SHUT OFF THE ENGINE, THEN RESTART IT, IT WILL DRIVE, UNTIL IT TRIES TO SHIFT TO SECOND THEN IT WILL NOT DRIVE ANYMORE, AT ALL, UNTIL I SHUT IT OFF AND THEN RESTART IT, THEN IT WILL IMMEDIATELY DRIVE AGAIN. I WAS TOLD BY A MECHANIC THAT IT IS MOST LIKELY A SOLENOID SHIFT PACK, WHICH WAS RECALLED BY CHRYSLER. *TR

NHTSA ID

10266990

Incident

Apr 20, 2009

Mileage

190,000 mi

MY VEHICLE DOES NOT CHANGE INTO SECOND GEAR. I FOUND OUT WHILE I WAS IN HEAVY TRAFFIC AND BECAME A HAZARD TO OTHER DRIVERS. WHEN IN REVERSE, IT HAS A "CLUNK" NOISE WHEN THE GAS IS APPLIED. THE PROBLEM CAME ALL OF A SUDDEN WITHOUT WARNING. THERE ARE ALSO COMPUTER AND IGNITION PROBLEMS WITH THIS VEHICLE. IT SOUNDS LIKE THERE IS CRACKLING IN THE DASHBOARD WHEN THE HEATER IS ON, THE IGNITION SWITCH CANNOT BE TURNED ALL THE WAY TO THE ON POSITION WHEN THE CAR IS ON OR THE ABS LIGHT WILL COME ON AND PREVENTS FUNCTION OF THE HEATER. *TR

NHTSA ID

10252243

Incident

Dec 3, 2008

Mileage

166,000 mi

MY WIFE WAS DRIVING OUR 1995 CHRYSLER CONCORDE WHEN SHE LOST TOTAL STEERING CONTROL WHILE MAKING A LEFT HAND TURN CAUSING CAR TO GO OVER CURB DAMAGING A SIGN AT THE WARREN PUBLIC LIBRARY AND SIGNIFICANT DAMAGE TO THE CAR. UPON INSPECTION, IT HAS BEEN FOUND THAT THE TIE ROD LINKAGE INTO THE RACK AND PINION HAD BROKEN OFF. *TR

NHTSA ID

10247350

Incident

Sep 16, 2008

Return: Wiring Assy - Engine You have been identified as either having stock, or have stock in transit to your dealership. Please return stock packaged before 2016/07/31 (31 July, 2016)of follow ing part numbers:68176457AF, 68176459AF. Please return suspect parts back to your facing depot using Return Code 02, before 13 September, 2016.

Inspect and Return: Trim Cover Assy - A-Pillar Rt/Lt You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part numbers: 1ZA04DX9AE, 1ZA05DX9AE. See attachments for identifying suspect stock. Replacement part can be obtained by reordering the same part number. Please return suspect parts back to your facing depot using Return Code 02, before 12 September, 2016.

05182535AD - Lamp Assy ?Tail Light LT You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 05182535AD . See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 12 September, 2016.

CBXDP361AA Return: Spacer Kit - Visor You have been identified as either having stock, or have stock in transit to your dealership. Please return stock of part number CBXDP361AA. Replacement part number is CBXDP361AB w hich is in stock and available for order. Please return suspect parts back to your facing depot using Return Code 02, before 16 September, 2016.

Warranty Operations Newsletter Updates from Warranty Operations

1NT30XDVAC - Inspect and Return: Panel - Instrument Panel You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 1N T30XDVAC. See attachments for identifying suspect stock. Replacement part can be obtained by reordering the same part number. Please return suspect parts back to your facing depot using Return Code 02, before 07 September, 2016.