Owner-reported complaints naming the interior system, filed with NHTSA
Data refreshed
Reports naming seats, latches, locks, linkages and interior fittings. Every record below is an owner-reported complaint about the 2015 Chrysler Town And Country submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 75 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
The 25 most recent of 75, in the owner's own words
I was sitting in my parked vehicle in my driveway with vehicle turned off, talking on my cellphone and just adjusted the headrest and the headrest popped out like a bang, since I was leaned over I missed gettting hit. My extended warranty was up in July of this year, and was never told from my Chrysler dealership I get maintenance from was told there was a faulty headrest design.
The contact owns a 2015 Chrysler Town and Country. The contact stated that while attempting to open the rear passenger’s side door, the door failed to operate as intended and remained closed. A dealer was contacted. The vehicle was taken to the dealer, where it was diagnosed, and determined that the mechanism in the door needed to be replaced. The vehicle was being repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 126,000.
Passenger side active head rest deployed suddenly while driving down the road on a hot day (90 degrees with heat factor 100+) Called dealer and they stated extended coverage for this expired June 13. This happened on July 28. They want to order parts, approx 170 USD and charge 108 USD labor. This is a common problem because of manufacturing with inferior plastic parts and it is violent when it pops apart unexpectedly.
The Head Restraint (AHR) on the driver's seat opened, without warning, striking the back of my head with considerable force. I was startled and momentarily dazed, as a result. The vehicle was parked at the time, so no impact or collision was involved. The Head restraint has not been repaired and is available for inspection. I have seen many reports of the same problem with numerous other vehicles. The manufacturers should be responsible for the repairs. Thank you!
The passenger side active head restraints (AHRs) deployed unexpectedly while the van was unoccupied inside our garage. Upon investigation the metal latch bar was still in it's undeployed location (latched into the head rest) but there were visible plastic parts missing on the other portion of the headrest. It appears that the plastic clamps had broken at some point and caused the AHR to deploy - luckily nobody was in that seat at the time. The AHR was unable to be reset so a replacement headrest has been ordered for installation.
*The drivers side headrest popped open while I was driving and yes it is available for inspection. Prior to this (several months), the passenger side headrest did the same thing while a passenger was in the seat. *When the headrest deployed/opened, it hit me in the back of the head. *No. *No. No, there were no warnings.
Passenger front head rest exploded/ejected while pulling into driveway.
Minivan was parked in our driveway and we heard a loud bang. The driver side headrest had spontaneously sprung open. Van has never been in an accident.
The contact owns a 2015 Chrysler Town and Country. The contact stated while the vehicle was parked, the rear driver’s side and rear passenger’s side doors were inoperable while depressing the unlock button or attempting to exit the vehicle manually. The contact stated that the children seated in the rear of the vehicle had to go over to the front driver’s or front passenger’s side seats to exit the vehicle. No warning light was illuminated. The vehicle was taken to an independent mechanic and the independent mechanic made the contact aware of TSB Number: D21-15; and informed the contact that the vehicle was under warranty. The contact was informed that the door lock actuators on the rear driver’s side and passenger’s side doors were faulty. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not included in the TSB. The failure mileage was approximately 115,000.
2015 Chrysler Town and Country. Black "Leather". Right Front Passenger Headrest. I was loading something into the Right Sliding door when my elbow bumped the headrest. It was slight enough that I thought nothing of it, but when my passenger got into the R/F seat, the headrest was thrust forward. We attempted to "reset" it but it would not latch in the back position. Upon assessment, we found the plastic "latches" broken. This is a design or quality problem with safety implications and Chrysler needs to replace this headrest in affected vehicles. There are several reports in the 2014-2015 model years with this issue. It should be a safety RECALL. Some complaints are that the parts are on backorder. This cannot be allowed. Chrysler should be held accountable.
Driving on a highway with my teenager sitting in the front passernger seat when all of a sudden we heard a loud pop and the headrest hit the back of my teenagers head. It was like an explosion. Fortunalty my teenager was looking down and said it didn't hurt them. Yes it is available for inspection. Someone could get a concussion given the force that headrest popped so forcefully. I have not taken it to a Chrysler dealer since it sounds like they dont do anything for it. No warnings.
With normal use, no accident has occurred both front driver and passenger active headrest have deployed due to faulty plastic casing. One side, front passenger occured with occupant pulling on headrest to enter vehicle in the middle row. One , front driver side, occured when a shopping bag GENTLY bumped the headrest while being removed from the middle row behind the seat. They will not "click" back into place because of a broken piece. If this deployed while driving, rather than casual contact (not rough contact!) it would cause injury to the neck or confusion in a driver to no longer be alert.
The driver's side headrest deployed while driving. My husband was driving on [XXX] at about 70-75 mph, when his headrest suddenly and unexpectedly burst open. This is a serious safety hazard. He said it felt like he got punched in the back of the head and was startled. Thankfully he didn't lose control of the vehicle and avoided an accident. It appears some plastic inside the headrest broke, causing it to deploy when it shouldn't have. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
I parked my car in the driveway, turned off the engine and exited the vehicle. Before I closed the driver's side door, the front right headrest went off like the vehicle was in an accident. The corresponding air bag did not deploy. I inspected the headrest noticing pieces of plastic had broken off and others were bent. I attempted to reset the headset following the recommended procedure. Because of the broken/bent pieces of plastic, the headrest cannot be reset.
I had to take my car to the dealership about 2 years ago for my headrest popping out and the said there was a recall then. I want to know if there still is a recall because my passenger headrest has done the same thing. Also my blindspot warning is not working. Also my video system does not work.
I was driving down the highway and there was a loud bang and something hit me in the back of my head. It felt like something was thrown and me with significant force from behind. The headrest exploded for no apparent reason while we were traveling 65 miles per hr and threw me forward as I was driving. This could have caused serious harm to me personally or could have caused an accident and harm to other vehicles or my daughter that was riding in the passenger seat.
The passenger side headrest popped forward while parked in parking lot.
When moving the front seats, unexpectedly, the front headrest, engaged and moved forward violently. Unable to move it back to its original position.
The middle row seats headrest will not latch the headrest just drops down and it could fall off and hurt someone if we were to get into a crash. We can not use that seat with a headrest that is faulty.
Car was parked and I was standing outside the front passenger door. When I pulled the seat recline lever, the seat back shot forward quickly and the headrest exploded open. I cannot push it back into place OR take the headrest out. It is available for inspection, however I need to get it fixed for safety concerns asap. Anyone sitting in the passenger seat cannot keep their head in proper alignment, over their shoulders. Their head is forced forward. Not only uncomfortable, but mechanically unsafe. There was no warning lights or known malfunctions prior to the incident.
headrest opened driving down the road and broke the plastic clips, now i have a loose headrest
While the car was parked in the garage, person sat in the passenger seat and buckled, leaned back against the headrest and the headrest impact function triggered, pushing fully forward. Following Chrysler’s instructions on resetting it, I found the plastic locking mechanism was completely broken off.
Both headrests in the vehicle have malfunctioned and popped without the occurrence of an accident. The headrests are broken and cannot be reset in their proper functioning position. Therefore, it poses a safety hazard for occupants. The components have not been inspected by the manufacturer or anyone else other than the owner of the vehicle. There are no indicators denoted the issue.
Car passenger headrest is deployed and cylinder 6 is misfiring as described under the recall description from the previous years vehicles recalls.
The passenger front seat active headrest deployed while car was parked for no reason.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .