2014 Ford C-Max Energi

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD

In January, the Office of Defects Investigation (ODI) opened this Preliminary Evaluation based on consumers' allegations of doors failing to latch and/or inadvertently opening on model year (MY) 2012-2013 Ford Focus vehicles (subject vehicles).ODI has received 464 unique reports related to the alleged problem, with over 200 claiming that the door(s) opened inadvertently while the vehicle was in motion.One consumer alleged an injury that occurred while driving when a door inadvertently opened and then closed on a child's arm.Another alleged that a door that inadvertently opened struck a parked vehicle.In response to ODI's information request, Ford Motor Company (Ford) provided 500 unique reports related to the alleged problem on the subject vehicles.Ford reported no injury or accident claims.Ford also submitted 1,513 warranty claims related to door latch failures.Many customers indicated that the affected door could not be latched at all and some of them decided to restrain the door by other means in order to operate the vehicle.Some customers also reported door latch failures occurring on multiple doors and at different times.Additionally, Ford stated that MY 2014-2015 Ford Focus, 2013-2015 Ford Escape, 2013-2015 Ford C-Max, 2014-2016 Ford Transit Connect, 2015 Ford Mustang, and 2015 Lincoln MKC, all use the same door latch as the 2012-2013 Ford Focus.On September 6, 2016, Ford notified ODI that it would conduct a safety recall (16V-643) to remedy the door latches in the MY 2012-2015 Ford Focus and other Ford models mentioned above (total of approximately 2 million vehicles).According to Ford, a component within the door latch may break preventing the door from latching.Ford dealers will replace all four door latches in the recalled vehicles with a new more robust latch design that is currently in production.The recall action initiated by the manufacturer appears to address the safety risks.Accordingly, this investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

The contact owns a 2014 Ford C-Max Energi. The contact stated while attempting to reverse, the rear-view camera displayed a blank screen. Several unknown messages were displayed. A dealer was contacted. The vehicle was taken to an independent mechanic, and the contact was referred to the dealer for assistance. The vehicle was then taken to the dealer to be diagnosed and it was determined that the rear-view camera needed to be replaced. The vehicle was not repaired; however, the contact stated that two computer modules were replaced. The contact related the failure to NHTSA Campaign Number: 25V442000 (BACK OVER PREVENTION); however, the VIN was not included in the recall. The manufacturer was notified of the failure and opened a case. The failure mileage was 110,700.

NHTSA ID

11675104

Incident

Jul 4, 2025

Mileage

110,700 mi

The contact owns a 2014 Ford C-Max Energi. The contact stated that while stopped at a traffic light, the vehicle was idling rough. The check engine warning light illuminated intermittently. The contact related the failure to NHTSA Campaign Number: 22V413000 (Power Train). The vehicle was taken to the dealer, who confirmed a transmission failure to the contact. The manufacturer was not made aware of the failure. The failure mileage was unknown.

NHTSA ID

11518212

Incident

Feb 1, 2023

The contact owns a 2014 Ford C-MAX Energi. The contact stated the front driver’s seat power seat was stuck in the reclined position. The contact took the vehicle to a local dealer to be repaired. The vehicle was returned, and the contact became aware that the rear driver’s side door panel was loose, causing the door to not open properly. The contact took the vehicle to the local dealer who diagnosed that the door panel was damaged and need to be replaced. The vehicle was not repaired due to the parts not being available. The manufacturer was made aware of the failure. The failure mileage was approximately 92,000.

NHTSA ID

11440251

Incident

Nov 1, 2021

Mileage

92,000 mi

2014 FORD C-MAX ENERGI. CONSUMER WRITES IN REGARDS TO DEFECTIVE CHARGING CORD FOR VEHICLE. *LD THE CONSUMER STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME COMPLETING THE RECALL REPAIR. *JS *JS

NHTSA ID

11290553

Incident

Dec 1, 2018

MY DAUGHTER DROVE THE 2014 FORD C MAX TO PICK UP MY YOUNGER DAUGHTER AND HAD A BLOWOUT WITH HER TIRE ON JUNE 26, 2019. SHE HEARD THE FRONT TIRE POPPED AND HAD TO MERGE FROM THE LEFT LANE TO THE RIGHT SHOULDER. THE SIDEWALL HAD A HOLE AND WASN'T ABLE TO FIX SO HAD TO CALL THE TOW TRUCK. THIS OCCURRED ON HIGHWAY 4 WHICH DIDN'T HAVE ANY ROAD CONSTRUCTION AND SHE DIDN'T RUN OVER ANYTHING. I AM CONCERNED WITH THE INTEGRITY OF THE TIRES. THE MILEAGE IS 43600 AND THE TREADS ARE STILL GOOD. I'VE REPLACED TWO TIRES SINCE EVEN TREADS NEED TO BE PAIRED UP. TWO NEW TIRES IN THE FRONT AND THE ORIGINAL TIRES ON THE REAR. I'VE KEPT THE THIRD TIRE FOR FUTURE USE. HEARING THE WHOLE FACT FROM MY DAUGHTER AM CONCERNED OF THE ORIGINAL TIRES AS WELL AS THE NEW TIRES SINCE REPLACED WITH THE SAME BRAND. THE BRAND IS MICHELIN ENERGY SAVER.

NHTSA ID

11228770

Incident

Jun 26, 2019

Mileage

43,601 mi

TL* THE CONTACT OWNS A 2014 FORD C-MAX ENERGI. THE CONTACT STATED THAT THE ELECTRICAL SYSTEM WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 18V592000 (EQUIPMENT). THE VEHICLE WAS SERVICED AT ED BUTTS FORD (1515 N HACIENDA BLVD, LA PUENTE, CA 91744, (800) 960-3673), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE CONTACT MENTIONED THAT THE ELECTRICAL SYSTEM WARNING INDICATOR ILLUMINATED AFTER THE RECALL REPAIR. THE VEHICLE WAS SUPPOSED TO GET AN "AS" CORD; HOWEVER, THE MECHANIC INSTALLED AN "AH" CORD INSTEAD. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 23,000.

NHTSA ID

11197209

Incident

Apr 13, 2018

Mileage

23,000 mi

I STILL HAVE NOT RECEIVED A NOTICE FROM FORD THAT THE RECALL 18V-592 PARTS ARE IN STOCK TO REPLACE THE RECHARGER CORD. I WAS NOTIFIED ORIGINALLY ON SEPT 2018 BUT NOW 6 MONTHS LATER NO NOTIFICATION OF PARTS AVAILABLE. THE CAR CANNOT BE CHARGED USING 110V POWER AS FORD RECALL NOTICE SAID TO QUIT USING THE DEFECTIVE CHARGE CORD.

NHTSA ID

11191534

Incident

Mar 26, 2019

TL* THE CONTACT OWNS A 2014 FORD C-MAX ENERGI. THE CONTACT STATED THAT THE RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 18V592000(ELECTRICAL SYSTEM) WAS RECEIVED IN SEPTEMBER OF 2018. AFTER CONTACTING THE DEALER (TUTTLE CLICK FORD, 9501 RESEARCH DR, IRVIN, CA), THE CONTACT WAS INFORMED THAT THE PARTS NEEDED TO REPAIR THE DEFECT WERE NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

11184610

Incident

Sep 1, 2018

Certain 2014-2020 Model Year Multiple Vehicle Lines 3G Telematics Control Unit to 4G Upgrade Kit REASON FOR THIS SUPPLEMENT Program Terms & Urgency / Expiration Date: Program extension until July 31, 2023. Service Action: o IDS level 128 or higher is now required to address various programming issues encountered. o C-MAX Energi vehicles are now serviceable with new software and hardware. Labor Allowances: C-MAX labor has been updated. Parts Requirements / Ordering Information: o The C-MAX 4G Upgrade Kit is now orderable at this time with a new part number. o MKX Rear seat backrest nut claim quantity updated. Technical Information updates: o Ensure IDS level 128 or higher is used. o Toggling Valet Mode is no longer required. o C-MAX Energi instructions are now available. Owner Notification: Non-repaired vehicle owners will be mailed the week of April 17, 2023. Pickup and Delivery: Added Customer Acknowledgement Form - Review form contents with customer prior to kit ordering and obtain customer signature prior to installation for Focus BEV, C-MAX, and Fusion Energi vehicles.

Certain 2014-2020 Model Year Multiple Vehicle Lines - 3G Telematics Control Unit to 4G Upgrade Kit. The North America 3G cellular service began decommissioning in August 2021 and a complete shutdown of the 3G network took place in February 2022. Vehicles on the road equipped with a 3G telematics control unit (TCU) / embedded modem will lose mobile app functionality/connectivity.

Certain 2014-2020 Model Year Multiple Vehicle Lines 3G Telematics Control Unit to 4G Upgrade Kit The North America 3G cellular service began decommissioning in August 2021 and will be fully decommissioned in February 2022. Vehicles on the road equipped with a 3G telematics control unit (TCU) / embedded modem will lose mobile app functionality/connectivity. Some owners are still within the *complimentary trial period (depending on model year and brand, see table below) for connected services.

Some 2013-2018 C-Max, 2013-2020 Escape/Fusion/MKZ, 2015-2018 Focus,2015-2019 MKC, 2015-2020 Edge/F150/Mustang, 2016-2018 MKX, 2016-2019 Explorer, 2017-2020 F-Super Duty, 2018-2020 EcoSport/Expedition, 2019-2020 Ranger/Nautilus vehicles may experience seat pan looseness, lateral movement, or a clunk/thump noise on turns. This may be due to the seat pan track. To correct the condition, follow the Service Procedure steps to install a reinforcement.

SSM 48619 - Various Vehicles - Perimeter Alarm Armed And Original Vehicle Keys Cannot Be Accessed to Enter Vehicle - CAN Protection Strategy Some 2013-2016 Model Year Vehicles may exhibit a concern in which the Perimeter Alarm is active and the original keys cannot be accessed to disable the perimeter alarm. This concern would most often occur when a customer loses keys and the dealership is attempting to program new keys to the vehicle. The Workshop Manual (WSM), Section 419-01A Perimeter Anti-Theft Alarm - System Operation and Component Description has been updated to inform of the Controller Area Network (CAN) Protection Strategy. Follow the procedure outlined to prevent replacement of the Body Control Module (BCM) on CAN Protection Strategy equipped vehicles when original keys are lost and perimeter alarm is active. Refer to the WSM for further detail on the CAN Protection Strategy. Lost keys and replacement of BCM for lost keys is non-warrantable.

Some 20132017 C-MAX Energi, 20172018 C-MAX Hybrid, 20132020 Fusion Energi and 2017-2020 Fusion/MKZ Hybrid vehicles may exhibit an illuminated malfunction indicator lamp (MIL) with any of the following diagnostic trouble codes (DTCs): P0496, P1450, P04ED, P04EF, P04EE, P2450, P2451. When performing pinpoint test (PPT) HX in the Powertrain Controls and Emission Diagnosis (PC/ED) Manual for the referenced DTCs, incorrect results may be obtained due to an internal powertrain control module (PCM) software conflict. In order to make sure the PPT provides accurate results, immediately prior to step HX22, make sure the fuel door is fully latched and then press the fuel door release button. Keep the door open while completing HX22, then fully latch again, prior to continuing the remainder of testing