Owner-reported complaints naming the engine system, filed with NHTSA
Data refreshed
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components. Every record below is an owner-reported complaint about the 2015 Ford Escape submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 271 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
The 25 most recent of 271, in the owner's own words
The battery keeps dying even though it's been tested and is good. Lights keep shorting out I've had to replace the brake light and wires twice. The coolant is disappearing causing the vehicle to overheat even after driving ahort diatances but no puddle is left to show a cracked tank or something similar.
THE ENGINE STARTED RUNNING RUFF, AND STALLING AND WHITE SMOKE COMING FROM EXAUST LIKE IT EITHER A BLOWN HEAD GASKET OR A CRACK IN THE BLOCK. I CHECKED FOR OTHER CARS WITH THE SAME PROBLEM AND IT SEEMS TO BE THE SAME ISSUE. THIS SEEMS LIKE THIS WOULD BE A SAFTEY ISSUE WITH THE ENGINE STOPPING ON THE ROAD,
I have coolant intrusion into cylinder 3, pressure in the coolant tank, white smoke from the exhaust. I had code that indicated misfire in cylinder 3. I have taken it to Ford dealer and they did a diagnostic and stated the engine needs replaced. in my research I have found this is a very known issue with thousands of complaints, multiple class action lawsuits for the exact issue i have experienced. The dealer and Ford has stated that there are no active recalls for my vehicle even though it is such a wide spread issue. around 5k miles ago I had to replace the transmission in this same vehicle. I am being told there is no help with repair cost. What are my options. Now with the cost of the new engine on such a know issue and the transmission I feel that Ford has a responsibility in the repairs Yes the Vehicle is Currently at the Ford Dealer in Grand Junction Colorado I feel that with the new transmission and a Very well know engine issue, Ford should replace the engine
Engine coolant intrusion issue known by ford and documemented in prior recall and STB.
The contact owns a 2015 Ford Escape SE. The contact stated that while idle at a stop light with the left-turn signal on, the vehicle started to jerk, and loud noises were coming from the front end of the vehicle. The Check Engine light illuminated, and the vehicle failed to move. The Fire Department arrived and assisted the contact with pushing the vehicle to the side of the road. The vehicle was towed to a certified mechanic at Precision Auto Shop, who diagnosed that the coolant was leaking. After further inspection, the dealer also diagnosed that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure, and a claim was filed. The failure mileage was approximately 111,400.
Vehicle loses coolant over time and requires periodic refilling. There is a medium white smoke puff from exhaust on startup after the vehicle has been sitting for a few hours. Smoke disappears after initial startup. No constant smoke while driving. Mechanic suspects possible coolant intrusion issue.
Vehicle has 126,000 miles on it and has a coolant intrusion into the engine. This has also caused my heater to go out with a weird smell and making the engine shake when driving.
My 2015 Ford Escape is diagnosed with a coolant intrusion due to flawed design issues by Ford. Coolant is slowly leaking into valve 2 and causing white smoke upon startup. The engine block is cracked due to faulty coolant system by per the designed of Ford. Only remedy is a new engine which is quoted at $8000. As this problem is entirely caused by Ford, it is unfair to expect the consumers to pay such a price.
MIL activated, reported misfire in cylinder 2. Attempted to replace spark plugs but they had seized. Took to dealership: was told coolant leaked into cylinder and entire engine needed to be replaced. Technician said this was common with Ecoboost engines for this model year, but not enough to merit a recall. Cost to replace engine more than the vehicle is worth
The contact owns a 2015 Ford Escape. The contact stated that while attempting to start the vehicle, the vehicle failed to start. No warning lights were illuminated. The contact was concerned about driving the vehicle due to a potential fire risk. The contact received notification of NHTSA Campaign Number: 25V695000 (Back Over Prevention) and 26V011000 (Equipment). An appointment was scheduled with the local dealer who confirmed that the parts were on backorder. The vehicle was not diagnosed or repaired. Additionally, the vehicle was scheduled to be towed to the local dealer. The manufacturer was not contacted. The failure mileage was approximately 88,000.
- The car loses coolant while the engine is running. This coolant loss is nearly imperceptible, except that the car's heat stopped working reliably. If the car is left idling with the heat on, it does not become warm. It only begins to become warm at higher speeds, then loses heat after slowing down.There are no easily visible coolant leaks. - If I had not caught it in time, the car could have overheated, causing a breakdown and emergency stop. - I have reproduced the problem, but it has not been brought to a dealer. - It has not yet been inspected. -There were no warning lights, I only noticed the coolant loss because I observed the radiator not working and checked under the hood. - The car is still available to be inspected, and is safe to drive short distances if the coolant is topped off.
Service engine warning light came on. When checked, coolant was found to be leaking into cylinder 3 due to the engine block being porous. Service center said they see this a lot in this particular engine.
The contact owns a 2015 Ford Escape. The contact received notification of NHTSA Campaign: 25V695000 (Back Over Prevention); however, the part to do the recall repair was not available. The contact stated that occasionally, while shifted in reverse, the rearview camera failed to display as intended and was possibly impacted by severe weather conditions. No warning light was illuminated. In addition, the contact stated that during colder weather, the heater failed to operate as intended while activated. After further inspection, the coolant reservoir was abnormally low. The vehicle was taken to a local dealer, where it was determined that the coolant level was extremely low. The coolant reservoir was refilled; however, the failure reoccurred. The manufacturer was not made aware of the failure. The failure mileage was approximately 120,000.
When are the parts available for back up camera and block heater I don’t want my car to start on fire so I want it fixed
Cabin lost heat November 2025. Brought it in to the local Ford dealership right away and they said replacing replacing the oil cooler hose will probably fix it. Car worked fine for a couple of weeks but the cabin heat tapered off again. Made another appointment with the Ford dealership, but the first available appointment wasn’t until 2/23/26. I tried to drive anywhere as little as possible after this because I live in Fairbanks, AK and it’s commonly -30 this time of the year. Tried to leave work on [XXX] and a warning came up as I started driving away that the engine was overheating and power was reduced to minimize damage. I put my car back in my work parking spot and plugged it in until I could get an appointment at a local mechanic shop. Had the car towed to a local shop 1/6/26 and they inspected it 1/7/26. The report came back saying there was an internal coolant leak and found hydrocarbons in the cooling system. The recommended fix was to replace the entire engine with a quote for $12,000. That is more than I paid for the vehicle and way over the Kelly Blue Book worth. I did some research and found that there is a common coolant leak issue damaging engines of a certain range of Ford vehicles that has not become an official recall yet. I looked at other Ford Escape owner complaints and it looks like my 2015 Escape 1.6L has the same engine defect. I’m afraid if I pay for the engine replacement, this will just happen again. If I don’t pay, I still owe for my lease and will only get pennies to sell it as is for parts. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2015 Ford Escape. The contact stated that while driving approximately 50 MPH, the vehicle stalled. The contact pulled over to the side of the road, and after several attempts, the vehicle restarted but continued to stall. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.
Vehicle Information: 2015 Ford Escape – approximately 165,000 miles Incident Description: During normal operation while backing out of a parking space, the vehicle unexpectedly slipped out of the drive gear immediately after I shifted from reverse to drive. There were no warning lights, messages, or prior symptoms indicating a potential issue. After restarting the vehicle, it briefly engaged drive but was only able to travel approximately ten feet before abruptly shifting through multiple gears without any driver input. During each occurrence, the engine surged to unusually high RPMs despite no acceleration being applied. Safety Concerns: The unintended gear changes were accompanied by loud whining noises, and the vehicle was unable to remain in any gear long enough to be operated safely. This failure left the vehicle immobilized on a main roadway, causing a traffic backup and creating a hazardous situation for myself, my children, and surrounding motorists. Current Vehicle Condition: After the vehicle was towed home, I attempted several restarts. At no time did any warning indicators or a check‑engine light illuminate. Each attempt resulted in the transmission immediately disengaging from gear when shifted into either drive or reverse, accompanied by continued loud whining noises and repeated engine surging to high RPMs without throttle input. The vehicle is currently inoperable. Additional Details: I plan to take the vehicle to Keith Hawthorne Ford for diagnostic evaluation. I am concerned that this failure may be related to a previously repaired transmission recall, as the recall documentation states that the defect may recur and could require additional corrective action. The dealership is currently requiring a diagnostic fee of $199.95 to inspect the vehicle.
Unknown coolant leak. Coolant is being lost somewhere in the engine no visible leaks. Added coolant several times.
Engine began giving white smoke from exhaust at start up. 2 Mechanics have checked it and said it’s a well Known coolant intrusion issue with these ford eco boost engines. High risk of overheating and engine failure (while driving, which is a major safety risk for my family).
Coolant leak has been checked by mechanic to not be due to problems with any hoses or connections within the coolant system. Inspection is available upon request. The issue has caused the coolant level to drop below the minimum coolant level 4 times within 3 months with no warning or visible leaking occurring. This has been a regular occurrence with this vehicle for several months now.
The contact owns a 2015 Ford Escape. The contact stated that while driving approximately 45-50 MPH, the engine was overheating. Upon inspection, the contact noticed that the coolant level was significantly low. The contact added coolant to the coolant reservoir. Additionally, the contact noticed that coolant was leaking onto the ground. The vehicle was taken to an independent mechanic, where a coolant line was replaced; however, the failure persisted. The check engine warning light was illuminated. Additionally, the contact stated that the failure had caused collateral damage to the vehicle. The contact stated that the transmission, the serpentine belt, and the pulley were replaced. The dealer and the manufacturer were not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 150,000.
We had to replace the engine about 4 years ago and we’re still getting gas smell into the cabin. About 3 years ago, we broke down on the road because the transmission quit. All our repairs have been done through Ford service department. We are now broke down again because of the transmission. Something has to be done with the Ford Escape!
Vehicle is leaking coolant.
The 6F35 transmission in my vehicle is shuddering and it seems like it’s going to possibly mess up my engine or anything else soon. It also jerks a bit forward from 0-25 along with gears slipping. This has almost caused an accident for me.
all equipped with 1.6-liter gasoline turbocharged direct-injected engines — could be subject to a lack of coolant circulation resulting in the engine overheating
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .