2018 Ford Escape Powertrain (other) Problems

I purchased a used 2018 Ford Escape SE equipped with the 1.5L EcoBoost engine on June 26, 2026. The vehicle currently has approximately 55,088 miles. While driving, I experienced a check-engine warning light after accelerating. The warning light subsequently began flashing while the vehicle was moving and would become solid when stopped or idling. The vehicle also developed noticeable engine shaking and rough operation, particularly when stopped at traffic lights with the transmission in Drive. The shaking is significantly reduced when the transmission is shifted into Park. The vehicle displayed diagnostic trouble code P0302, indicating a cylinder 2 misfire. I also noticed that acceleration was not as responsive as expected, requiring additional time to gain speed. Upon inspecting the engine compartment, I observed that the coolant level appeared low. These symptoms raise safety concerns because the vehicle may experience reduced engine performance or potentially lose power while driving, particularly during acceleration or when merging into traffic. I stopped operating the vehicle because of concerns about further mechanical damage and driving safety. According to the vehicle’s service history, the engine short block was replaced on August 3, 2021, at approximately 28,170 miles. The service history also indicates subsequent cooling-system maintenance. I am concerned that the current misfire and apparent coolant loss may be related to an internal engine or cooling-system defect, including possible coolant intrusion, although the underlying cause has not yet been confirmed. The vehicle has not yet undergone a complete diagnostic inspection by a Ford dealership or independent repair facility for this incident. An experienced mechanic familiar with these engines expressed concern about possible internal engine failure based on the symptoms described, but no physical testing has confirmed that assessment. The vehicle remains parked and is available for inspection

NHTSA ID

11776448

Incident

Oct 23, 2026

Coolant intrusion on my 2018 ford escape 1.5-liter EcoBoost engine. Mileage is only 42500. Ford has offered no resolution or assistance. Known issue: 19b37 and 21n12 and TBS 22-2134. Technical Bullet 22-2229.

NHTSA ID

11776204

Incident

Nov 2, 2026

The car was driving completely fine, then when starting to go at a stoplight it had trouble shifting out of the first gear. At the next stop, it would not go uphill and began slowly rolling backwards as I am trying to move forward. This was in downtown [XXX] traffic with nowhere for me to pull over. It was very close to hitting the car behind me. I had to turn the car off to rest it for a few minutes and was finally able to slowly get up the hill to pull into a parking lot. I ended up getting it towed to a Ford dealership and they said it needed a whole new transmission put in. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11773887

Incident

Oct 22, 2026

My daughter was driving our 2018 Ford Escape at highway speed when it suddenly began shaking and shuddering violently, with no advance warning. The check engine light came on for the first time as the shaking began. The vehicle lost propulsion, and the shaking impaired her ability to control it, creating an immediate safety emergency in moving highway traffic. She had to maneuver quickly out of traffic onto a narrow shoulder. It was dark, and the limited shoulder space made exiting safely difficult. She feared for her life due to the sudden failure and exposure to passing traffic. She reached the shoulder without a collision. The vehicle required an emergency tow through her insurance company, and she received transportation home. The vehicle had undergone a safety inspection in August before this incident. A Ford dealership confirmed an internal engine leak allowing coolant into a cylinder's combustion chamber. A borescope inspection found liquid on top of the piston, and a cooling-system pressure test confirmed coolant entering the combustion chamber. The spark plugs were severely carbon-fouled, causing a misfire. Replacing them temporarily improved the symptoms, but the misfire quickly returned. The dealership determined that the engine requires a rebuild or replacement. The diagnosis appears to correspond to Ford Customer Satisfaction Program 21N12, dated June 9, 2022. We were not notified of this issue before the incident and found no corresponding safety recall for this vehicle in NHTSA's records. This sudden failure caused loss of propulsion and impaired control at highway speed, forcing an emergency maneuver onto a narrow shoulder after dark. The check engine light provided no advance warning. We request that NHTSA investigate this defect and determine whether a safety recall is warranted to prevent similar incidents and injuries.

NHTSA ID

11770962

Incident

Oct 7, 2026

AT 56000 MILES HAVE HAD DEALER REPLACE TRANSMISSION NOW DEALER WANTS TO REPLACE THE FUEL PUMP EVEN THOUGH THE CODE READER SAYS PO0087 , A SENSOR THIS IS THE 2ND TIME THIS VEHICLE HAS HAD TO BE TOWED TO THE DEALER. NOW THE DEALER SAYS HE WILL JUST PUT THE FUEL PUMP BACK IN NOT REPLACING IT. HELP !! THEY HAVE HAD THIS VEHICLE TO REPAIR FOR APPROXIMATLY 30 DAYS

NHTSA ID

11770243

Incident

Sep 15, 2026

Failed Component/System: The engine assembly/engine cooling system. The internal structural failure of the cylinder block (open-deck design defect) allowing engine coolant intrusion into combustion chambers, cylinders 2/3. Safety: The vehicle is experiencing severe engine stalling, immediate loss of motive power on active roadways, dense white smoke from exhaust which blinds trailing traffic. This causes immediate risk for rear-end collision, leaves others with the possibility to be stranded on dangerous traffic situations. The vehicle leaks hot fluids into the combustions system putting everyone at risk for under hood fires. Has the Problem been confirmed: Yes, my vehicle is currently at the Pennyrile Ford Dealership, they performed a cooling system pressure test and borescope inspection, and confirmed internal coolant intrusion requiring a total engine replacement. They have even confirmed and acknowledged that this is an on going issue! Dealer inspection: Yes Warning Lamps/Messages: Check engine soon light, raised engine levels, rapidly depleting coolant within days of refill, rough idling, cold start rumblings, sweet chemical smell and thick white smoke coming from tailpipe. Ford has already admitted this is an ongoing issue with these systems, I currently have a 2.0 engine but the recall is for the 1.0/1.5.

NHTSA ID

11770074

Incident

Oct 9, 2026

The contact owns a 2018 Ford Escape. While driving at an undisclosed speed, an unknown warning light illuminated, and the message to "Pull Over Immediately" was displayed. The contact pulled over and had the vehicle towed to an independent mechanic, who replaced the long block, turbo charger, transaxle oil cooler, an unknown pump, and flushed and refilled the transmission fluid due to coolant intrusion into the transmission. The manufacturer was notified of the failure by phone. The failure mileage was 64,054.

NHTSA ID

11767849

Incident

Apr 1, 2026

Mileage

64,054 mi

Transmission suddenly failed causing vehicle to violently vibrate and stall. No warning lamp or check engine light. Vehicle has been repaired by independent repair shop by installing remanufactured transmission.

NHTSA ID

11766672

Incident

Sep 3, 2026

The engine began misfiring and causing the car to shake and causing an engine light on ignition, pulling an error code of P0304, pointing to an issue with the cylinders. Even after replacing all spark plugs and coils, the engine continued to misfire and cause the car to shake. When we brought it back to our independent mechanic, he diagnosed it as a coolant intrusion, which I've come to read is incredibly common on this type of engine from Ford. The engine has failed and will need a full replacement due to the coolant intrusion into the cylinders. With this issue occurring during a long drive, it put our safety at risk. The problem was confirmed by the independent service center. The vehicle has not been inspected by the manufacturer or police, just the mechanic. The warning signs that appeared were the shaking and engine light, though they did not point directly to the coolant intrusion, as those issues are often caused by things like spark plugs as well. The issue started occuring a week before it was finally diagnosed with the coolant intrusion.

NHTSA ID

11766386

Incident

Sep 23, 2026

Transmission spudder when accelerates only at 75K miles

NHTSA ID

11757726

Incident

Aug 16, 2026

Coolant is leaking into the head causing engine failure. This car has fewer than 60,00 miles. From what I have read this is a common problem and is due to a manufacturer’s design flaw. Ford refused to help me in any way when I contacted them. When I took the vehicle to the dealership they informed me that the engine would need to be replaced. The bill would be $13,000.

NHTSA ID

11756727

Incident

Jul 30, 2026

Check engine light would come on vehicle was not running well, seemed to stall. When I turned off the car I could hear liquid moving around from inside the vehicle. I am a Mom so I am driving with my 2 small children constantly and worried about their safety. The problem was confirmed by the dealership as well as an independent service center.

NHTSA ID

11756696

Incident

Apr 11, 2026

The vehicle suffered a catastrophic engine failure due to an inherent manufacturing defect involving internal engine coolant intrusion into the cylinders. Prior to the failure, the check engine light illuminated on the dashboard, accompanied by engine misfires and rough idling. A certified service technician inspected the vehicle and confirmed that coolant is actively leaking into the engine cylinders, causing complete engine failure and rendering the vehicle entirely un-drivable. The failed engine components remain intact and are fully available for inspection upon request. This defect poses a severe safety hazard. Coolant leaking into the engine cylinders can cause sudden engine stalling, complete loss of motive power while driving at highway speeds, and potential engine fires, creating a high risk of a collision. Crucially, an authorized Ford dealership previously attempted to mitigate this exact coolant defect under warranty in 2020 by applying Customer Satisfaction Program (CSP) 19B37. This software-based patch failed to fix the underlying physical hardware defect, ultimately leading to this total engine failure. Ford has since issued CSP 21N12 for this exact issue, but the vehicle is now left broken down and unsafe to operate.

NHTSA ID

11755288

Incident

Aug 6, 2026

After replacing the engine less than a year, driving on I 96 going back to her home. The car starts losing power and shaking and the engine light come on. She almost get re-ended because the car lost powers so quick. She gets off the freeway and makes it to a friends house and parks the car. Called J and T Towing to tow the vehicle to Dearborn Tire and alignment in Dearborn to be checked. Trans had to be replaced($2,120.00).

NHTSA ID

11752844

Incident

Jun 3, 2026

I have a 2918 ford escape se with what I am now finding has a known flawed 1.5l ecoboost that ford only put a service notice out on long ago. The engine has a know issue with cylinder coolant intrusion problems. I had engine misfire and powertrain code show up and put the car into limp mode while driving at 70 on the interstate. When the limp mode started I came close to being in an accident due to sudden deceleration. I have replaced parts for the misfire and even more codes show up. The motor is now overheating and blowing white smoke when starting due to the coolant intrusion in cylinder one. Please make ford finally responsible for this issue and coverup. There needs to be a recall.

NHTSA ID

11752541

Incident

Jun 12, 2026

2018 Ford escape ecoboost coolant leak and engine overheating. If not repaired, will destroy the entire engine.

NHTSA ID

11752503

Incident

Jul 18, 2026

Multiple instances of low power to ignition coils (all of have been replaced with new coils and plugs). Transmission immediately stopped transmitting power to the wheels and would not re-engage. Transmission would sometimes go into gear, but slam into gear, lurch, or only shift into 1 or 2.

NHTSA ID

11749236

Incident

Jul 9, 2026

The transmission has very harsh and delayed up shifts. It has been maintained by Ford since new. The transmission appears to be defective.

NHTSA ID

11748221

Incident

Jul 1, 2026

Request for NHTSA Investigation – 2018 Ford Escape 1.5L EcoBoost Coolant Intrusion Engine Defect ​Vehicle Information ​Year/Make/Model: 2018 Ford Escape ​Engine: 1.5L EcoBoost ​VIN: [XXX] ​I am submitting this complaint regarding a well-documented coolant intrusion defect affecting my vehicle’s 1.5L EcoBoost engine. The vehicle is experiencing coolant loss without any visible external leaks, and an authorized Ford dealership has confirmed that coolant is entering the engine, causing internal damage. ​The dealership noted that this matches the exact defect Ford has acknowledged in multiple Technical Service Bulletins (TSB 19-2375, TSB 20-2100, SSM 48106, SSM 48150) and Customer Satisfaction Program 21N12. However, I am told my specific VIN is excluded from coverage, leaving me financially responsible for a full engine replacement. ​This defect is a severe safety concern. It can cause sudden engine misfires, overheating, and a complete loss of power while driving, placing my family and other motorists at immediate risk. As a single mother rebuilding my life after leaving a domestic violence relationship, I cannot afford to pay thousands of dollars to fix an inherent, manufacturer-acknowledged design flaw. ​The high volume of consumer complaints proves this is a widespread manufacturing defect, not normal wear and tear. I respectfully request that the NHTSA investigate this further and require Ford to issue a full safety recall or extend coverage to all affected vehicles, regardless of VIN eligibility. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11748094

Incident

Dec 22, 2025

The vehicle experienced a coolant intrusion failure involving the 2.0L EcoBoost engine. While driving, the engine began to misfire and run rough, and the check engine light illuminated. Diagnostic testing confirmed a cylinder misfire. A dealership inspected the vehicle and confirmed that coolant was leaking internally into one or more cylinders due to engine coolant intrusion. The dealership advised that the manufacturer recommends replacing the engine short block rather than performing a head gasket repair because the underlying engine design is the cause of the failure. This condition creates a significant safety concern because the engine can suddenly lose power, run unpredictably, or stall while driving, increasing the risk of a crash, especially in traffic or at highway speeds. Continued operation also risks catastrophic engine failure. The condition has been confirmed by an authorized dealership and is available for inspection upon request. Prior to diagnosis, symptoms included rough engine operation, a check engine light, and a confirmed cylinder misfire. The coolant intrusion was verified during the dealer's inspection. Based on the dealership's findings, this appears to be an internal engine defect rather than normal wear or maintenance-related failure.

NHTSA ID

11747737

Incident

Jun 12, 2026

My pregnant wife and 2 year old daughter we driving to daycare the morning of June 22nd 2026 and the car flashed an engine overheating message while they were on the highway. They were luckily able to pull off safely and get the car home. Then on June 23rd I went to take the car into the shop to get it looked at and the car completely broke down in traffic on my way to get the car serviced. The engine is completely seized up due to the coolant leak known issue with these engines.

NHTSA ID

11746407

Incident

Jun 22, 2026

I have a vehicle whose refrigeration is going into the motor. It started with the check engine light came on notifying the third spark plug was damaged and showed the codes P0303, P04DB, P0316, P0339. Later a warning sign came on the dashboard with the phrase "ENGINE MALFUNCTION, SERVICE NOW". It had a recall almost immediately after it was acquired and was seen by the manufacturer about two years.

NHTSA ID

11744892

Incident

May 5, 2026

1.5 L eco boost engine FORD- COOLANT INTRUSION, cylinder 3 misfire, check engine light at 59,800 miles - known defect by Ford- needs new engine. Some models recalled but not this one (?? Why??). Cannot safely drive this vehicle. Problem diagnosed by dealer[ as well as by independent garage] and dealer acknowledged a recall should be done but they cannot help except to replace the engine at my expense. So many others having the same issue! Can you please help us get Ford to take responsibility for selling us vehicles with defective engines? Please?? Thank you for your attention to this urgent matter.

NHTSA ID

11741776

Incident

Apr 13, 2026

Componet System that Failed: Engine and engine cooling Complaint Description:The vehicle experienced a sudden internal engine failure due to a manufacturer design defect causing coolant intrusion into the engine cylinders. A professional mechanic diagnosed the issue with Diagnostic Trouble Code (DTC) P0303, confirming a Cylinder 3 misfire caused by coolant leaking into the block. The vehicle requires a total engine replacement at just 48,406 miles. This internal coolant leak poses a severe safety hazard, including sudden engine stalling, loss of motive power while driving, and potential thermal runaway/engine fire risks. The vehicle is currently rendered unsafe to drive and is parked at my residence.

NHTSA ID

11741011

Incident

May 28, 2026

Engine displayed overheating, after diagnostic test by Corwin ford in nampa, Idaho, they said it needs gaskets and short block replacement and that there was a technical service bulletin issued by ford for my vehicle. The cost is astronomical and I feel it should be a recall issue since it is a known problem.

NHTSA ID

11740439

Incident

May 19, 2026