Owner-reported complaints naming the electrical system, filed with NHTSA
Data refreshed
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories. Every record below is an owner-reported complaint about the 1997 Ford Explorer submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 76 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
The 25 most recent of 76, in the owner's own words
MY LIGHTS DON'T WORK STABILIZING BAR IS BAD,SPEED CONTROL DOSE NOT WORK SECURITY KEY CODE NOT WORKING,DOOR CONTROLS DO NOT WORK.WIPER WORK SOMETIMES.BALL JOINT ARE BAD, TIRES WEARING BAD,,BUSHINGS ARE VERY BAD.TRANSMISSION IS STARTING TO SLIP,ALL WHEEL DRIVE DOES NOT WORK, IT GRINDING SOUND.HEAF LIGHT ONLY BRIGHTS WORK.
I RECENTLY FOUND OUT MY VEHICLE HAS AN OPEN RECALL REGARDING THE POSSIBLE LEAKAGE OF THE SPEED CONTROL DEACTIVATION SWITCH, WHICH COULD CAUSE A FIRE WHETHER THE VEHICLE IS RUNNING OR NOT. THE FORD MANUFACTURER'S RECALL #09S09 AND THE NHTSA RECALL #09V399000. THIS IS STILL AN OPEN RECALL.I CONTACTED FORD RECALL CENTER TODAY AND THEY ARE REFUSING TO REMEDY THIS HAZARDOUS RECALL DUE TO THE AGE OF THE RECALL AND THE AGE AND MILES OF MY VEHICLE. THIS IS A SAFETY ISSUE AND FORD SHOULD FIX IT AS BODILY INJURY OR EVEN POSSIBLE DEATH COULD OCCUR IF THIS RECALL IS NOT REMEDIED. MY VEHICLE IS RUNNING PROPERLY FOR THE MOMENT BUT SINCE THIS IS A SAFETY ISSUE, FORD MOTOR CO. SHOULD BE REQUIRED TO FIX IT NO MATTER THE AGE OF MY VEHICLE.
ON DECEMBER 23RD, 2016 I WAS COMING HOME FROM WORK AROUND 6:00 PM. MY CAR WAS A 1997 FORD EXPLORER EDDIE BAUER EDITION. I HAD JUST GOTTEN OFF OF THE HIGHWAY AND TURNED ONTO MY ROAD WHEN I BEGAN TO SMELL SMOKE, SO, I PULLED OFF INTO AN EMPTY PARKING LOT BESIDE A WALKING TRAIL. I COULD TELL THAT IT WAS AN ELECTRICAL FIRE, BUT, IT TOOK ME QUITE A WHILE TO FIGURE OUT WHERE IT WAS COMING FROM. I CHECKED UNDER THE HOOD - BUT NOTHING SEEMED TO BE WRONG THERE. THEN, I GOT BACK INTO THE CAR AND THE SMOKE KEPT GETTING HEAVIER. I BEGAN FEELING AROUND FOR SOMETHING THAT WAS HOT. I CHECKED THE DASH, THE VENTS, THE STEERING WHEEL, THE SEATS - ALMOST EVERYTHING BEFORE I CHECKED THE CENTER COMPUTER CONSOLE. IN THE MIDDLE OF MY CAR - DIRECTLY UNDER THE RADIO - THERE IS A COMPUTER MODULE THAT DISPLAYS THE GAS MILEAGE, OIL STATUS, AND IF THERE IS A PROBLEM WITH THE LIGHTS ON THE CAR. THE MODULE HAD RECENTLY STARTED DISPLAYING A "CHECK HEADLAMPS" MESSAGE. WELL - I HAD DONE SO AND THEY WERE WORKING FINE - SO I DID NOT THINK ANYTHING OF IT. TURNS OUT THAT THE FIRE HAD STARTED UNDER THE CENTER COMPUTER MODULE. I GUESS THAT THE CAR SHOULD HAVE BLOWN A FUSE BUT INSTEAD - STARTED A FIRE. I TRIED TO RIP THE COVER AND THE CONSOLE UP - BUT IT WAS SCREWED DOWN AND I HAD NO LUCK. AT THAT POINT, THE FLAMES STARTED TO SPREAD VERY QUICKLY AND THE ENTIRE CAR WENT UP IN FLAMES IN A MATTER OF MINUTES. I CALLED 911 AND GOT AS FAR AWAY AS I COULD WITH MY BELONGINGS. THE FIRE TRUCK AND FIRE FIGHTERS CAME WITHIN FIVE MINUTES OR SO AND PUT OUT THE FIRE BEFORE IT REACHED THE GAS TANK. THE BOTTOM HALF OF THE CAR REMAINED UNTOUCHED, HOWEVER, THE INTERIOR WAS COMPLETELY DESTROYED. THE SEATS HAD BURNT OFF AND THE STEERING WHEEL WAS COMPLETELY GONE. I'M STILL IN MY TEENAGE YEARS - SO I DID NOT KNOW HOW TO DEAL WITH THIS SITUATION PROPERLY. I AM JUST GLAD I AM ALIVE AND THAT I WAS ABLE TO GET OUT OF THE CAR IN TIME.
THE 1997 FORD EXPLORER 4D EDDIE BAUER EDITION HAS A COMPUTER CONTROLLED MESSAGE CENTER. THE MESSAGE CENTER CONTROLS AMONG OTHER THINGS THE VEHICLE HEADLIGHTS AND FOG LAMPS. THE LIGHT OUT MODULE (LOM) ALSO KNOWN AS THE INDICATOR WARNING SYSTEM CONTROL IS LOCATED INSIDE THE MESSAGE CENTER CONSOLE AND RUNS "HOT" IN TEMPERATURE BECAUSE OF A FLAWED DESIGN. THE CURRENT DESIGN LEADS TO INTERNAL ELECTRICAL SYSTEM FAILURES THAT RESULT IN A LOSS OF THE LOW BEAM HEADLIGHTS. THE SYSTEM IS DESIGNED TO NOTIFY THE DRIVER OF A HEADLIGHT OR LAMP FAILURE, ETC, HOWEVER, THE FAILURE OF THE NOTIFICATION SYSTEM CAUSES THE LOW BEAM HEADLIGHTS (AND FOG LAMPS AS THEY ARE ON THE SAME CIRCUIT) TO FAIL. ON JUNE 25, 2014, THE SECOND FAILURE OF THE SYSTEM OCCURRED (WE ARE THE ORIGINAL OWNERS AND HAVE PREVIOUSLY REPLACED THE INDICATOR WARNING SYSTEM CONTROL OR LIGHT OUT MODULE (LOM) AT GREAT EXPENSE). FORD MOTOR COMPANY MUST RECALL THE 1997 FORD EXPLORER EDDIE BAUER EDITION AND ANY OTHER LIKE DESIGNED FORD PRODUCT WITH A LIGHT OUT MODULE (LOM) THAT FAILS LEAVING THE DRIVER WITHOUT LOW BEAMS AND NO MEANS OF FIXING THE SAID DEFECT WITHOUT AN AUTHORIZED FORD DEALER'S REPAIR (AT GREAT EXPENSE) THAT IS LIFE THREATENING IN THE INTERIM. SUCH REPAIRS ARE NOT POSSIBLE IF ON AN EXTENDED TRIP IN RURAL SETTINGS. THE ABSENCE OF LOW BEAM HEADLIGHTS AFTER SUNSET AND BEFORE SUNRISE IS LIFE THREATENING AND UNACCEPTABLE TO THE OCCUPANTS OF A 1997 FORD EXPLORER AS WELL AS TO PEDESTRIANS AND OTHER VEHICLES WHO CANNOT SEE THE FORD EXPLORER OPERATING WITHOUT HEADLIGHTS. THE CORRECTIVE SOLUTION NEEDS A VENTING SYSTEM SUCH THAT THE MESSAGE CENTER DOES NOT CONTINUALLY MELT THE INDICATOR WARNING SYSTEM CONTROL OR LIGHT OUT MODULE (LOM). THANK YOU FOR YOUR SERVICE AND FOR YOUR PROMPT ATTENTION TO THIS DEFECT REQUIRING A CORRECTIVE RECALL. *TR
APPROX. 2AM, THE VEHICLE CAUGHT ON FIRE. FIRE DEPT. REPORT CONFIRMED ELECTRICAL FIRE. *TR
I HAVE NO EXPLANATION FOR THE FIRE, THE CAR WAS PARKED IN MY DRIVEWAY. IT HAD BEEN DRIVEN ABOUT A BLOCK FROM MY HOME AND THEN IT WAS RETURNED TO THE DRIVEWAY. MY UNCLE SON SITTING IN THE LIVING ROOM WHEN THEY HEARD THE CAR ALARM AND LOOKED OUT OF THE WINDOW TO SEE CLOUDS OF BLACK SMOKE COMING FROM THE TRUCK. MY SON ATTEMPTED TO PUT THE FIRE OUT BUT IT WAS TO INTENSE, MY SON CALLED 911. THIS WOULD HAVE KILLED SOMEONE IF THEY HAD BEEN IN THE CAR. PHOTOS ARE AVAILABLE. FIRE DEPARTMENT COULD NOT SAY WHAT CAUSED THIS FIRE. THE TIRES EVEN MELTED. ALL SEVERE DAMAGE WAS TO THE FRONT END. THE CAR HAD NOT BEEN IN ANY KIND OF ACCIDENT, THERE IS NO EXPLANATION FOR THIS FIRE. PLEASE CONTACT ME FOR PHOTOS. NOT SURE WHAT TO DO BUT I NEED TO MAKE SURE NO FAMILIES. *TR
WHILE DRIVING MY 1997 FORD EXPLORER SPORT THE SPEEDOMETER WOULD DROP TO ZERO AND I WOULD NOT KNOW HOW FAST I AM ACTUALLY DRIVING. THE TACHOMETER IS ALSO AFFECTED AND, PROBABLY, THE ODOMETER. MY MECHANIC HAS CHANGED THE SPEED SENSOR BUT THE PROBLEM REMAINS. AN INTERNET SEARCH HAS TURNED UP NUMEROUS COMPLAINTS OF THE SAME ISSUE WITH THE RESULT BEING A FAULTY PROGRAMMABLE SPEEDOMETER/ODOMETER MODULE (PSOM), WHICH IS LOCATED IN THE DASH. THIS IS A VERY COSTLY REPAIR. SOME INDIVIDUALS ARE JUST PURCHASING GPS UNITS TO DETERMINE HOW FAST THEY ARE DRIVING. IT IS MY OPINION THAT FORD KNOWS ABOUT THIS ISSUE AND SHOULD BE REQUIRED TO REPAIR/REPLACE THE PSOM. ASIDE FROM THE OBVIOUS SAFETY PROBLEM OF NOT KNOWING HOW FAST I AM DRIVING, THIS PROBLEM ALSO CAUSES THE ODOMETER TO READ INCORRECTLY. *TR
ABOUT A MILE FROM AN INTERSECTION I NOTICED THE CHECK ENGINE LIGHT TURNED ON. APPROACHING THE TRAFFIC LIGHT MY BRAKE PEDAL HAD LOST PRESSURE AND WENT TO THE FLOOR. I HAD TO PUMP THE BRAKES TO GET THE VEHICLE TO STOP. I NOTICED SOME SMOKE COMING FROM THE DRIVER SIDE OF THE HOOD BUT THOUGHT IT MIGHT BE FROM THE OLD PICKUP TRUCK NEXT TO ME. THE LIGHT TURNED GREEN AND THE VEHICLE "SPUTTERED" SUFFERING A LOSS OF HORSE POWER BUT I WAS ABLE TO DRIVE THE CAR ABOUT 150 YARDS AND COASTED INTO A GAS STATION WHERE I PARKED AT THE FAR END AWAY FROM THE PUMPS. AT THIS TIME I NOTICED MORE SMOKE AND FLAMES COMING FROM THE DRIVER SIDE OF THE HOOD SO I WENT INSIDE TO ASK FOR A FIRE EXTINGUISHER BUT THE CASHIER SAID HE HAD NONE. I THEN ASKED TO HIM DIAL 911 BECAUSE MY VEHICLE WAS ON FIRE. I WENT BACK TO MY VEHICLE AND REMOVED SOME PAPERWORK FROM THE SEAT AND WAITED FOR HELP TO ARRIVE. I JUST HAD THE VEHICLE SERVICED BY COVERT FORD ON MARCH 16, 2011 FOR THE FACTORY RECALL OF THE SPEED CONTROL DEACTIVATION SWITCH, (BRAKE PRESSURE SWITCH) WHICH IS WHAT I BELIEVE CAUSE THE FIRE. I BELIEVE THAT WHEN I HAD TO PUMP MY BRAKES TO STOP THE VEHICLE THE BRAKE FLUID WAS LEAKING ONTO THE EXHAUST MANIFOLD. ACCORDING TO THE FIRE OFFICIALS AT THE SCENE THERE WAS NO WAY TO DETERMINE THE POINT OF ORIGIN OF THE FIRE BUT THE DAMAGED AREA IS RIGHT BELOW THE BRAKE MASTER CYLINDER. (I HAVE PICTURES AND VIDEO). THANK GOD THERE WAS NO OTHER DAMAGE TO PROPERTY OR LIVES. I ONLY HAD LIABILITY COVERAGE SO I SIGNED THE TITLE OVER TO THE TOW TRUCK DRIVER AND LOST MY TRANSPORTATION. I BOUGHT THE VEHICLE ON APRIL 19, 1999, TOOK CARE OF IT FOR ALMOST 12 YEARS WITHOUT INCIDENT AND A WEEK AFTER HAVING IT SERVICED FOR A FIRE SAFETY ISSUE, IT CAUGHT FIRE AND BURNED. I PUT ABOUT 100 MILES ON IT AFTER IT WAS SERVICED BY THE DEALER BEFORE THE FIRE BEGAN.
FAR LEFT DASH LIGHTS AND LIGHTS BEHIND INDICATORS ON LEFT SIDE OF STEERING WHEEL WENT OUT SHORTLY AFTER RECEIVING THE VEHICLE IN 1998; THIS WAS REPAIRED UNDER WARRANTY; THE LIGHTS WENT OUT AGAIN SOMETIME AFTER THE WARRANTY PERIOD EXPIRED. THE SOUND SYSTEM AMPLIFIER GOES OUT INTERMITTENTLY WITH NO DISCERNIBLE CAUSE; THIS HAS GONE ON FOR YEARS; THE DEALER SAYS IT WOULD COST OVER $600 TO REPLACE THE AMPLIFIER. *TR
TODAY IS THE FIRST TIME SINCE I HAVE OWNED THE TRUCK AS I WAS DRIVING IT AND STARTED RIGHT BACK UP, AND ABOUT 6 HOURS LATER MY NEIGHBOR NOTICED MY TRUCK ON FIRE. FLAMES WERE COMING FROM BEHIND THE LEFT FRONT WHEEL WELL. MY MECHANIC SAID LOOKS LIKE E-BRAKE CABLE STARTED TO WELD IT SELF AND CAUGHT THE BODY MOUNT ON FIRE. E-BRAKE CABLE MELTED PLASTIC HOUSING INSIDE THE TRUCK. *TR
VEHICLE STARTED OUT FINE. AFTER A MONTH OF DRIVING, FAR LEFT DASH LIGHTS DIED OUT. THOSE ARE THE ONES ILLUMINATING THE OIL PRESSURE AND BATTERY. A FEW MONTHS LATER, THE LIGHTS ILLUMINATING THE SPEEDOMETER AND TACHOMETER DIED OUT AS WELL. THIS IS NOT NORMAL. PERSONALLY, I THINK IT MIGHT BE A SHORT TO GROUND, BUT I STILL HAVE YET TO FIND OUT. *TR
MY 1997 FORD EXPLORER STARTED FIRE IN THE ENGINE AREA AFTER PRACTICING FOOTBALL FOR 45 MIN IN THE SCHOOL. IT WAS A TOTAL LOSS BY THE TIME FIRE MEN ARRIVED. THEY SAID IT WAS EITHER FUEL OR ELECTRICAL RELATED. *CN
ON MONDAY, JANUARY 7, 2008, I PARKED MY VEHICLE AND NOTICED A BURNING SMELL. I OPENED UP THE HOOD AND NOTICED FLAMES SHOOTING OUT OF THE ALTERNATOR. BY THE TIME I WAS ABLE TO GET A FIRE EXTINGUISHER FROM THE NEARBY HOUSE, MY SUV WAS FULLY ENGULFED IN FLAMES. FIRE DEPARTMENT AND POLICE CAME TO THE SCENE. FIRE DEPARTMENT EXTINGUISHED THE FLAMES. THE SUV IS A TOTAL LOSS. *TR
TL*- THE CONTACT STATED THAT HE HAD NOT BEEN ABLE TO START UP THE 1997 FORD EXPLORER SINCE 02/09/07. THE CONTACT HAD REPLACED THE STARTER, THE SPARK PLUGS, AND CONTINUES TO EXPERIENCE THE SAME FAILURE. THEY PULLED THE FRONT END OF THE MOTOR AND NOTICED SOMETHING SNAPPED AND WAS SITTING IN THE PAN. THE CONTACT HAD BEEN ON THE INTERNET AND HAD NOTICED THAT OTHER EXPLORERS WERE HAVING THE SAME PROBLEM. THE CURRENT AND FAILURE MILEAGE WERE BOTH 98000 MILES.*AK
THE CARS HEAT/AC WOULD SWITCH BETWEEN HIGH HEAT TO MAX COOL. I TOOK IT TO THE LOCAL FORD DEALER AND WAS TOLD IT WAS A PROBLEM WITH THE BLEND DOOR AND WOULD COST ABOUT $1100.00 TO REPAIR. THE REPAIR WOULD INCLUDE A UPDATED BLEND DOOR MOTOR AND A NEW AIR PLENUM THE SERVICE PERSON ALSO STATED THIS PROBLEM IS VERY COMMON IN EXPLORERS AND IT IS JUST A MATTER OF TIME BEFORE THEY ALL FAIL. *NM
DT*: THE CONTACT STATED WHILE TRAVELING 50 MPH ON ANY ROAD CONDITION, THE VEHICLE SWAYED VIOLENTLY FROM SIDE TO SIDE. THE SWAY BAR WAS REPLACED IN 2003. A FEW MONTHS LATER, THE CONTACT NOTICED THERE WAS A NHTSA RECALL, #00V402000, REGARDING THE SUSPENSION. THE SERVICE DEALER WAS CONTACTED AND DETERMINED THAT A DIAGNOSTICS TEST NEEDED TO BE PERFORMED BEFORE ANY WORK WAS TO BE DONE. THE TEST SHOWED THE UPPER AND LOWER BALL JOINTS ALONG WITH THE CAMBER CASTOR KIT WERE DAMAGED. ALSO THE PASSENGER AND BOTH REAR DOORS DID NOT OPEN. THE FRONT DRIVER'S DOOR HAD DIFFICULTIES CLOSING ON TWO OCCASIONS. THE CONTACT RECEIVED A LETTER FROM THE MANUFACTURER WHICH OFFERED $6000 FOR A TRADE IN. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE LOCKS WERE INOPERATIVE, THE HEADLAMP SWITCH WAS BROKEN. THE VEHICLE NEEDED UPPER AND LOWER BALL JOINTS, HOWEVER THE CONSUMER DECLINED ALL REPAIRS. UPDATED 10/11/06. *JB
OUR 1997 FORD EXPLORER WAS PARKED IN THE DRIVEWAY WHILE WE WERE ASLEEP. IT CAUGHT ON FIRE AND BURNT COMPLETELY UP DESTROYING A 6000.00 STEREO SYSTEM, 2 SETS OF GOLF CLUBS, PART OF A DECK, AND PARTS OF ANOTHER VEHICLE. *NM
DT*: THE CONTACTED STATED WHILE STARTING THE VEHICLE THE FUSES FOR THE HORN, CRUISE CONTROL, DASHBOARD LIGHTS AND COMPASS BURNED OUT. WHILE DRIVING AT 40 MPH. WITH OUT REPLACING THE FUSE, THE ENGINE WARNING LIGHTS ILLUMINATED. WHEN THE ENGINE COMPARTMENT WAS INSPECTED, BRAKE FLUID WAS OBSERVED TO BE LEAKING. THE VEHICLE HAS NOT BEEN TO SERVICE DEALER HOWEVER THE MANUFACTURER CONTACTED. THE MANUFACTURER INFORMED THE CONTACT, THAT THE VEHICLE WAS NOT INCLUDED IN THE RECENT FORD RECALL EXPANSION, WHICH THE CONTACT HEARD ABOUT ON THE NEWS, DUE TO THE VIN.*AK
SEVERAL PROBLEMS WITH THIS AUTO, IT SEEMS TO BE FALLING APART. THE DRIVER SIDE SEAT BELT NO LONGER LATCHES. WE HAVE TO LOOP THE DRIVER SIDE THROUGH THE PASSENGER SIDE. IT APPEARS THIS IS AN ISSUE WITH SEVERAL OF THESE MODELS. THIS IS A SERIOUS SAFETY HAZARD AND SEAT BELTS ARE MANDATORY BY LAW. IS THERE ANYTHING BEING DONE? THE LEFT TURN INDICATOR HAS HAD ELECTRICAL ISSUES FOR YEARS. IT MAKES A ZZZZ SOUND AND NO LONGER WORKS. I AM ALSO DOWN TO ONLY ONE DOOR THAT THE KEY WORKS ON. THAT IS THE BACK LIFT. THE DOOR KEY HAD NOT WORKED ON THE DRIVER SIDE FOR YEARS, THEN THE PASSENGER SIDE WENT. I HAVE THE SAME HEAT PROBLEM THE OTHERS ARE HAVING. YOU EITHER GET FULL ON HEAT AND HAVE TO TURN IT ON AND OFF WHEN IT GETS TOO HOT OR YOU GET PARTIAL AC, ALWAYS A LITTLE WARM. BOTH THE AC AND HEAT HAS BEEN SERVICED, THE PROBLEM IS IN THE SWITCH SOMEWHERE. AND NOW THE REASON I'M WRITING IS I HAVE MAJOR ELECTRICAL PROBLEMS. FUSES AND SOLINOIDS HAVE BEEN LOOKED AT, THERE ARE NO LONGER LIGHTS IN THE DASH AREA. THE LIGHTS ON ALARM (DING DING DING DING) REMAINS ON WHEN THE CAR IS OFF, THE KEYS OUT AND THE DOOR SHUT WHICH HAS DRAINED MY BATTERY COMPLETLY. I HAVE JUMPED STARTED IT TWICE AND NOW IT SITS IN MY DRIVEWAY BECAUSE IT WILL COST A FORTUNE TO HAVE THE ELECTRICAL LOOKED AT. IF THIS IS AN ISSUE WITH ANYONE ELSE IT SHOULD BE REPORTED TO FORD. NOT ONLY CAN I NO LONGER DRIVE THIS CAR, IT WOULD BE TOTALLY UNSAFE TO USE IT. I NEED 4WHEEL DRIVE JUST TO GET OUT OF MY DRIVEWAY IN WINTER AND HAVE NO IDEA HOW I'M GOING TO COME UP WITH THE MONEY FOR ALL THESE REPAIRS. PLEASE ADVISE IF THERE ARE ANY RECALLS THAT ADDRESS THESE ISSUES. THE INCIDENT DATE I LISTED BELOW IS FOR THE TIME THE SEATBELT STARTED TO FAIL COMPLETLY. WE WERE ON A VACATION TRIP!
DT: THE ENGINE LIGHT CAME ON. CONSUMER TOOK VEHICLE TO DEALER ,WHO SAID THEY COULD NOT GET IT IN UNTIL SATURDAY FOR REPAIRS. TUESDAY THE VEHICLE CAUGHTON FIRE WITH THE ENGINE NOT RUNNING. THE VEHICLE HAD BEEN PARKED WITH ENGINE TURNED OFF FOR ABOUT 5 MINUTES , AND WHEN CONSUMER RETURNED THE VEHICLE WAS IN FLAMES. THE FIRE WAS MOST PROMINENT IN THE FRONT. THE FIRE DEPT CAME, AND THEY SAID THE VEHICLE CAUGHT FIRE FROM THE DASH AND HEAD AREA AND IT WAS ELECTRICAL IN NATURE. THE VEHICLE WAS TOTALED. THERE ARE POLICE AND FIRE DEPARTMENT REPORTS AS WELL AS PHOTOGRAPHS. NO OTHER INDICATION AS TO WHY THIS HAPPENED. *AK
WHILE DRIVING 55 MPH VEHICLE CAUGHT ON FIRE ON ITS OWN. PULLED OVER, AND THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. VEHICLE WAS TOWED TO A GARAGE FOR INSPECTION. THE CAUSE HAD NOT BEEN DETERMINED AT THIS TIME. *AK
FEW MONTHS AGO I HAVE PURCHASED A SET OF BOSCH SPARK PLUGS (PLATINUM 2 PART # 4305). ABOUT 3 WEEKS AFTER I INSTALLED THEM WILE DRIVEN ON THE EXPRESSWAY ONE OF THEM EXPLODED RUINING THE WIRE AND CAUSING TO FLIP FLOP ALL OVER SPARKING LUCKY I STOP RIGHT AWAY. THE CERAMIC PORTION OF THE SPARK HAS COME OUT OF IT CLEAN CAN NOT EVEN FIND A TRACE OF CERAMIC ON THE PLUG BUT UNFORTUNATELY THE ELECTRODE OR PORTION OF IT FELL IN TO THE CYLINDER ,CAUSING AN IRREPARABLE DAMAGE TO THE ENGINE, I HAVE REPORTED THE DAMAGE AND DETAILS TO THE MANUFACTURER AND EVEN SEND THEM THE PLUG FOR INSPECTION AND EXPLAIN EVERY THING, BUT THEY HAVE RETURN THE PLUG AND A LETTER SATING THAT THE REASON THE PLUG EXPLODED WAS BECAUSE IMPROPER TORQUE. I HAVE BEEN INSTALLING THE PLUGS ON MY VEHICLES FOR THE LAST 20 YEARS AND I HAVE NEVER HAD A PROBLEM LIKE THIS AND PEOPLE I TALKED TO SAID THE PLUG SHOULD NOT EXPLODE FOR THAT REASON. I THAT IS THE CASE I FEEL THIS IS A SAFETY ISSUE ON THIS PARTICULAR PLUGS AND THERE IS NOTHING ON THE PACKAGE INDICATING TO THE CONSUMER OF THIS DANGER. *AK
REPLACEMENT OF ENGINE DUE TO DEFECTIVE PARTS; THROTTLE BODY PLATE AND CAM CHAIN GUIDE ON MOTORS. *BF THE ENGINE THROTTLE PLATE STUCK WHILE THE CONSUMER WAS WARMING THE VEHICLE ON A COLD DAY. RECALL #00V422000. THE CONSUMER REQUESTED REIMBURSEMENT FOR THE DEFECTIVE ENGINE. THE STARTER DID NOT KICK IN PER INVOICE. *SC
WHILE DRIVING AT 35 MPH CONSUMER HEARD A NOISE, THEN VEHICLE STALLED. THE SPARK PLUGS BLEW OUT. AN INDEPENDENT TECHNICIAN INDICATED THAT ENGINE CYLINDER NEED TO BE REPLACED. *AK
THE VEHICLE AUTOMATICALLY POPPED INTO 4X4 MODE WITHOUT WARNING. WHEN THAT HAPPENED THE VEHICLE MADE A LOUD GRINDING NOISE AND STOPPED IN THE MIDDLE OF TRAFFIC. *NLM THE VEHICLES WIPERS ALSO BECAME INOPERABLE. THE WINDOWS COULD NOT BE OPENED. THE INTERIOR LIGHTS FAILED. IT WAS LATER DETERMINED THAT ALL THESE FAILURES WERE AS A RESULT OF A FAULTY GEM MODULE. THE MODULE HAS BEEN RECALLED IN CANADA. *TS *NLM
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .