Owner-reported complaints naming the other system, filed with NHTSA
Data refreshed
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above. Every record below is an owner-reported complaint about the 1997 Ford Explorer submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 31 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
The 25 most recent of 31, in the owner's own words
1997 FORD EXPLORER DRIVER'S SEAT BELT LATCH RECEIVER FAILURE. AFTER OWNING THE CAR FOR 12 TO 13 YEARS, THE LATCH/RECEIVER WOULD NOT ENGAGE THE STRAP. I REPLACED IT WITH ONE FROM A SALVAGE YARD AND AFTER THREE YEARS THIS REPLACEMENT LATCH/RECEIVER HAS FAILED ALSO. *TR
TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE CONTACT STATED THAT THE RIMS WERE COMPLETELY RUSTED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.
SPARE TIRE HOIST CABLE FAILED ON 1997 FORD EXPLORER XLT, RESULTING IN SPARE TIRE BREAKING FREE OF THE VEHICLE WHILE IN MOTION. *TR
ENGINE REVVS AND VEHICLE IS THRUSTED FORWARD AT TOP SPEED FROM DEAD START OR WHEN SLOWING DOWN. THIS IS THE SECOND ON THIS PROBLEM. BOTH TIMES LEAD TO PROPERTY DAMAGE, AND ACCIDENT. *TR
I HAVE SEEN SEVERAL FORD EXPLORERS RANGING FROM YEARS 1995-2001 THAT THE FRAMES ARE RUSTING THROUGH AND BREAKING. I FEEL THIS IS A SERIOUS SAFETY ISSUE. THERE IS A SEVERE RUST PROBLEM WITH THESE FRAMES AND THEY APPEAR TO BE MANUFACTURED QUITE THIN TO BEGIN WITH. FROM WHAT I HAVE SEEN ON OVER A DOZEN OF THESE CARS IN MY AREA, THE FRAME IS RUSTING THROUGH AND BREAKING ON THE LEFT REAR CORNER ANYWHERE FROM THE FRONT MOUNT ON THE LR LEAF SPRING TO WHERE THE BUMPER MOUNTS AT THE BACK OF THE FRAME. THE CROSS MEMBER HOLDING THE BODY MOUNTS IS ALSO RUSTING THROUGH IN THIS AREA AND COMING INTO CONTACT WITH THE GAS TANK AND ALSO MAKING THE SPARE TIRE LOOSE AND AT RISK OF FALLING OUT OF THE VEHICLE AND BECOMING A HAZARD FOR FOLLOWING MOTORISTS. THERE IS NO GOOD WAY TO FIX THIS PROBLEM AND I FEEL THAT THESE VEHICLES SHOULD BE RECALLED TO GET THEM OFF OF THE ROAD. THIS IS A VERY SERIOUS ISSUE AND I AM NOT SURE HOW THERE HAVEN'T BEEN CRASHES AND OR DEATHS AS A RESULT OF THIS VERY POOR DESIGN AND QUALITY VEHICLE. ACTION NEEDS TO BE TAKEN IMMEDIATELY BECAUSE FROM WHAT I HAVE SEEN THIS PROBLEM IS JUST NOW STARTING TO REALLY TAKE EFFECT BECAUSE OF THE AGING VEHICLES. *TR
TL*THE CONTACT OWNS A 1997 FORD EXPLORER. WHILE CHANGING THE TIRE, THE BOTTOM METAL PLATE FOR THE JACK POPPED OFF. THE FAILURE OCCURRED AFTER THE VEHICLE HAD BEEN LIFTED FOR TEN MINUTES. THIS WAS THE FIRST TIME THE JACK WAS USED. THE MANUFACTURER WOULD NOT MAKE A REPLACEMENT. THERE WERE NO INJURIES OR DAMAGE TO THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE 186,000.
PARKED ON A SLIGHT SLOPE WITH THE ENGINE OFF, MY 97 FORD EXPLORER ROLLED BACK 5 FEET BY ITSELF, COMING CLOSE WITH COMING TRAFFIC! *NM
BLEND DOOR FAILURE ON AUTOMATIC CLIMATE CONTROL MODULE. REPLACED AT A COST OF OVER $700. THIS IS A KNOWN AND COMMON FAILURE ON THIS CAR AND SHOULD BE COVERED BY A RECALL BUT IS NOT. *JB
THERE SEEMS TO BE A BURNING RUBBER SMELL COMING FROM THE RIGHT REAR WHEEL WELL. *JB
CONSUMER IS A VICTIM OF ODOMETER FRAUD, ENCOUNTERING PROBLEMS WITH THE VEHICLE THAT'S UNCHARACTERISTIC FOR THE MILEAGE ON THE VEHICLE. (NAR) *PH EXHAUST SYSTEM, BALL JOINT, AND INSTRUMENT PANEL HAD TO BE REPLACED. *CB
SEAT BELTS IN BACK SEAT AND SPEED CONTROL WILL NOT CANCEL AFTER BEING SET. A LADY HAD LATCH HER SEAT BELT IN THE RIGHT REAR SEAT,AND IT WOULD NOT RELEASE HAD TO CUT THE BELT TO GET HER OUT.*AK
RIGHT REAR WHEEL DETACHED FROM 1997 EDDIE BAUER EXPLORER ON FREEWAY NEAR RAWLINS WYOMING ON 7-3-03 THE RATE OF SPEED WAS APPROX. 70 MPH THE REAR TIRES WERE REPLACED ABOUT 4000 MILES PRIOR TO THE INCIDENT. I WITNESSED THE INSTALLER TORQUE THE LUGNUTS TO SPECS.*AK
MECHANISM WHICH HOLDS SPARE TIRE HAD TO BE CUT BEFORE CONSUMER COULD USE TIRE. ALSO ,WRONG JACK WAS WITH THE VEHICLE. PLEASE PROVIDE ANY FURTHER INFORMATION, AND IDENTIFICATION NUMBER. *AK
VEHICLE WOULD PULL TO THE RIGHT WHILE DRIVING 35MPH. HAVE TAKEN TO DEALERSHIP TO CHECK ON ALIGNMENT. INFORMED NOT ALIGNMENT. MECHANIC INDICATED PROBLEM IWAS LOCATED IN WHEEL HUB. IT WAS NOT REPAIRED.*AK
TIRE PLACARD IS NOT REQUIRED IN SUV'S, OWNERS ARE ADVISED TO TAKE SUV TO A SHIPPING COMPANY OR AN INSPECTION STATION TO GET THE VEHICLE'S CORRECT WEIGHT. *CJ
IMPROPER CAMBER ADJUSTMENT COMPONENT PART OF ORIGINAL EQUIPMENT DOES NOT ALLOW WHEEL ALIGNMENT. THIS CAUSES EXCESSIVE TIRE WEAR ON THE INSIDE CORNER OF THE TIRE AND POOR HANDLING OF THE AUTO. CAR PULLS TO THE RIGHT.
BOTH RUNNING BOARDS ON THE DRIVER AND PASSENGER SIDE HAVE A SERIOUS RUST PROBLEM. BOTH SIDES ARE RUSTING THROUGH IN THE EXACT SAME WAY, IN THE SAME AREA. THIS AREA IS ON TOP MAINLY NEAR THE PLASTIC TREAD. IN THE PAST 4 MONTHS I HAVE SEEN NEARLY 12 OTHER EXPLORERS WITH THE IDENTICAL PROBLEM. THIS IS ON THE IDENTICAL MODEL, THE IDENTICAL PART. IN SOME CASES, THE PROBLEM ON THE OTHERS IS MORE ADVANCED AND SEVERE. I HAVE TOLD LOCAL FORD DEALER AS WELL AS FORD CUSTOMER SERVICE, THERE RESPONSE IS NOT COVERED OUTSIDE 3YR./36 MONTH WARRANTY. MAINLY CONTACTING YOU TO SEE IF THIS SIMULAR PROBLEM HAS BEEN REPORTED BY OTHERS.
WHILE VEHICLE WAS DRIVEN SPARE TIRE CABLE SHEARED OFF, CAUSING SPARE TIRE TO FALL OFF WHICH COULD HAVE CAUSED AN ACCIDENT. THE CABLE WAS SWINGING BACK AND FORTH AND RUBBING AGAINST METAL. THIS IS A DESIGN FLAW. *AK *ML
WHILE DRIVING AT 35 MPH FRONT RIGHT PASSENGER'S WHEEL COLLASPED, CAUSING LOSS OF VEHICLE CONTROL. DEALER REPLACED BALL JOINTS AND TIE RODS. *AK
THE ROOF RACK RIPPED OFF WHILE DRIVING, THE THUMB SCREWS DESIGNED TO LOOSEN THE CROSSBAR VIBRATED LOOSE COMPLETELY. *MJS
JACK HANDLE SHATTERED IN JACK BASE WHILE LOWERING VEHICLE AFTER CHANGING TIRE. WAS EVENTUALLY ABLE TO LOWER JACK USING SCREWDRIVER. HOWEVER, JACK HANDLE IS ALSO REQUIRED TO RETRACT THE SPARE-TIRE HOLDING CABLE, SO THAT HAD TO BE LEFT LOOSE UNTIL WE GOT TO A TIRE STORE. HANDLE IS MADE OF VERY WEAK METAL, AND IT IS THINNEST AT THE POINT OF MOST STRESS, WHERE IT IS INSERTED INTO THE JACK.
CONSUMER WAS REMOVING SPARE TIRE FROM BOTTOM OF TRUCK. THE CABLE THAT HOLDS THE TIRE IN PLACE WAS ALMOST BROKE IN TWO, WITH TIRE HANGING UNDERNEATH. *ML
RUSTING AND CORROSION OF THE BUMPERS AND WHEELS.
WHILE DRIVING AT 60 MPH THE REAR WHEELS LOCKED UP. CAUSE UNKNOWN. PLEASE PROVIDE ANY DETAILS. *AK
STARTED APPLYING BRAKES AFTER GOING 30MPH. VEHICLE DID NOT SLOW DOWN OR STOP. REARENDED SEVERAL VEHICLES. UPON IMPACT, AIRBAGS DID NOT DEPLOY. LEFT FRONT WHEEL CAME OFF. PRIOR TO IMPACT, CV JOINT MADE KNOCKING NOISE WHEN TURNING. TOOK TO DEALER TWICE FOR KNOCKING NOISE. *AK
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .