1997 Ford Explorer Problems

ON 7/29/2013 WE PURCHASED A SET OF 4 KUMHO SOLUS KR21 TIRES. THE CAR IS USED PRIMARILY FOR HIGHWAY TRAVEL ? ONCE WEEKLY WORK COMMUTE AND FOR VACATION ROAD TRIPS. WE HAD NOT YET DRIVEN IT OFF PAVEMENT WITH THE NEW TIRES. ON 4/16/2014 I STARTED THE CAR TO GO TO WORK. I HEARD AN ODD NOISE FROM THE REAR PASSENGER SIDE, ALMOST LIKE A RHYTHMIC POPPING SOUND, BUT IT STOPPED, AND SINCE IT WASN'T IDENTIFIABLE I PROCEEDED TO LEAVE MY DRIVEWAY. ABOUT A BLOCK AWAY, I HEARD THE NOISE AGAIN, BUT AGAIN IT STOPPED. AT THIS POINT THE CAR WAS HANDLING FINE. AS SOON AS I GOT ON THE FREEWAY (APPROXIMATELY 2 MILES FROM MY HOUSE), I NOTICED I WAS HAVING TROUBLE ACCELERATING TO SPEED (65MPH). I ALSO BEGAN TO HEAR A RHYTHMIC BUMPING NOISE, SO BEGAN TO PULL OVER TO THE SHOULDER. BY THE TIME I GOT OVER, I COULD FEEL THE BUMPING AND KNEW I HAD A FLAT. THE REAR PASSENGER SIDE WHEEL HAD SUFFERED A COMPLETE SIDEWALL SEPARATION (SEE PHOTO). THE TIRES ONLY HAD 6,624 MILES ON THEM ? ALL PAVED ROAD, NO DIRT. THEY WERE SUPPOSEDLY WARRANTIED TO 85,000 MILES. IN RETROSPECT, I BELIEVE THE SOUNDS I HEARD IN MY DRIVEWAY WERE THE INITIAL SIDEWALL SEPARATION. THE SEPARATION DID NOT CAUSE IMMEDIATE LOSS OF AIR PRESSURE OR STRUCTURAL INTEGRITY; THAT ONLY HAPPENED ONCE I GOT ON THE HIGHWAY AND STARTED DRIVING AT 60MPH. THERE WAS NO EXPLOSIVE NOISE LIKE A BLOWOUT. IN SUBSEQUENTLY RESEARCHING KUMHO TIRES, I DISCOVERED THAT THIS BRAND HAS A LONG HISTORY WITH SUDDEN SIDEWALL SEPARATION AND/OR BLOWOUTS ? ALL AT LOW MILEAGES. THIS OCCURS ACROSS SEVERAL TIRE MODELS AND YEARS. THE COMPLAINTS WERE SO CONSISTENT THAT I WENT BACK TO THE TIRE DEALER AND REQUESTED A DIFFERENT BRAND. THEY REPLACED THEM AND I NOTIFIED THEM OF MY RESEARCH RESULTS. I AM VERY CONCERNED THAT KUMHO IS ALLOWED TO CONTINUE SELLING TIRES WITH SUCH A SAFETY RISK. I WAS VERY LUCKY THAT I DID NOT LOSE CONTROL AND THAT TRAFFIC AT THAT MOMENT WAS LIGHT. *TR

TL* THE CONTACT OWNS A 1997 FORD EXPLORER WITH WINSTON WIN WINNER AT TIRES, SIZE: 255/70R16. THE CONTACT STATED THAT THE SIDE WALL OF THE FRONT PASSENGER'S SIDE WAS LEAKING AND THE OTHER THREE TIRES HAD DEVELOPED CRACKS THROUGHOUT THE TIRES. THE VEHICLE WAS NOT DIAGNOSED AND THE TIRES WERE REPLACED BY THE CONTACT. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE OF THE VEHICLE AND TIRES WAS 170,000. THE DOT NUMBER WAS NOT AVAILABLE.

MY LIGHTS DON'T WORK STABILIZING BAR IS BAD,SPEED CONTROL DOSE NOT WORK SECURITY KEY CODE NOT WORKING,DOOR CONTROLS DO NOT WORK.WIPER WORK SOMETIMES.BALL JOINT ARE BAD, TIRES WEARING BAD,,BUSHINGS ARE VERY BAD.TRANSMISSION IS STARTING TO SLIP,ALL WHEEL DRIVE DOES NOT WORK, IT GRINDING SOUND.HEAF LIGHT ONLY BRIGHTS WORK.

THE DRIVERS SIDE SEATBELT WILL NOT ENGAGE TO THE LOCK POSITION.

TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING 50 MPH, THE VEHICLE STARTED TO SHAKE ABNORMALLY, THE CONTACT WAS UNABLE TO DRIVE IN 4 WHEEL DRIVE. THE CONTACT STATED THE CHECK GAUGE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH THE FRONT DRIVE SHAFT, THE CONTROL ARMS, THE FRONT OXYGEN SENSOR, AND THE FRONT AND REAR BRAKES NEEDING TO BE REPLACED. THE CONTROL ARMS WERE REPLACED HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 147,000.

TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE WHILE PARKED IN HIS DRIVEWAY. THE CONTACT STATED THAT AN INDEPENDENT MECHANIC DIAGNOSED THAT THE HYDRAULIC FLUID WAS LEAKING DUE TO THE FAULTY CRUISE CONTROL SWITCH CAUSING THE FIRE. THE CONTACT MENTIONED THAT THE HYDRAULIC FLUID LEAKED OUT WHEN IT GETS WARM EVEN WHEN THE VEHICLE NOT RUNNING. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR A DIAGNOSTIC TESTING AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 23,000. THE VIN WAS NOT AVAILABLE. *BF

TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING 50 MPH, THE VEHICLE STARTED TO SHAKE ABNORMALLY, THE CONTACT WAS UNABLE TO DRIVE IN 4 WHEEL DRIVE. THE CONTACT STATED THE CHECK GAUGE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH THE FRONT DRIVE SHAFT, THE CONTROL ARMS, THE FRONT OXYGEN SENSOR, AND THE FRONT AND REAR BRAKES NEEDING TO BE REPLACED. THE CONTROL ARMS WERE REPLACED HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 147,000.

MY LIGHTS DON'T WORK STABILIZING BAR IS BAD,SPEED CONTROL DOSE NOT WORK SECURITY KEY CODE NOT WORKING,DOOR CONTROLS DO NOT WORK.WIPER WORK SOMETIMES.BALL JOINT ARE BAD, TIRES WEARING BAD,,BUSHINGS ARE VERY BAD.TRANSMISSION IS STARTING TO SLIP,ALL WHEEL DRIVE DOES NOT WORK, IT GRINDING SOUND.HEAF LIGHT ONLY BRIGHTS WORK.

TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING 50 MPH, THE VEHICLE STARTED TO SHAKE ABNORMALLY, THE CONTACT WAS UNABLE TO DRIVE IN 4 WHEEL DRIVE. THE CONTACT STATED THE CHECK GAUGE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH THE FRONT DRIVE SHAFT, THE CONTROL ARMS, THE FRONT OXYGEN SENSOR, AND THE FRONT AND REAR BRAKES NEEDING TO BE REPLACED. THE CONTROL ARMS WERE REPLACED HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 147,000.

WITH NO WARNING OR HINT OF ANYTHING GOING WRONG ON THE BRAKE SYSTEM, AS TRAFFIC SLOWED TO STOP FOR A LIGHT, THE BRAKES WENT COMPLETELY OUT ON MY FORD EXPLORER. THE PEDAL WENT TO THE FLOOR AND PUMPING HAD NO EFFECT. I WAS IN MID DAY TRAFFIC AND HAD ALMOST 2 CAR LENGTHS BETWEEN MYSELF AND THE SUV IN FRONT OF ME, WHICH UNFORTUNATELY, WAS WHAT STOPPED ME. THANKFULLY, I WAS ONLY GOING 20 MPH AND NO ONE WAS HURT NOR DID AIR BAGS DEPLOY. AFTER THE POLICE ARRIVED AND HAD US PULL INTO A PARKING LOT, THE PEDAL FELT LIKE IT HAD THE BRAKES BACK HOWEVER, THE BRAKE PEDAL WENT TO THE FLOOR AFTER CRANKING UP. I WAS ABLE TO STOP FROM ROLLING OUT THE OTHER SIDE OF A PARKING SPACE IN THE BACK OF THE LOT BY USING THE EMERGENCY BRAKES. EVEN THOUGH THE TRUCK HAS SHOWS HIGH MILEAGE,MOST OF WHICH IS HIGHWAY MILES, THE TRUCK AS BEEN MAINTAINED. I HAD THE TRUCK TOWED TO THE SHOP AND TWO MECHANICS COULD FIND NOTHING WRONG. I HAD THE MASTER CYLINDER AND BOOSTER WAS CHANGED EVEN THOUGH I WAS ASSURED IT WAS FINE. THAT SEEMED TO HELP MY PEACE OF MIND FOR ABOUT A WEEK UNTIL I WAS STOPPED AT A LIGHT AND THE BRAKE PEDAL EASED DOWN TO THE FLOOR. I RAN AN INTERNET SEARCH TO SEE IF ANYONE ELSE HAS HAD THIS PROBLEM AND SURPRISED TO SEE IT SEEMS TO BE A COMMON PROBLEM WITH EXPLORER. I'M SURE EVERYONE WHO MENTIONED HAVING THIS PROBLEM HAS NOT REPORTED IT THAT SHOULD HAVE.

TL* THE CONTACT OWNS A 1997 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 70 MPH, THE CONTACT NOTICED THAT THE DEFROSTER WAS NOT FUNCTIONING AND THE WINDSHIELD WOULD NOT CLEAR. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN ADVISED THAT THE DASHBOARD WOULD HAVE TO BE REMOVED AND THE BLENDING CHAMBER WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 126,000. UPDATED 07/10/13*LJ UPDATED 07/12/13 *JS

WAITING AT A TRAFFIC LIGHT THE SUNROOF SHATTERED NOTHING BUT RAIN HAD FALLEN ON THE VEHICLE. *TR

THE DRIVERS SIDE SEATBELT WILL NOT ENGAGE TO THE LOCK POSITION.

TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED THAT THE DRIVER AND PASSENGER SEAT BOLTS FRACTURED AND CAUSED THE SEATS TO SEPARATE FROM THE FRAME. THE BOLTS WERE REPLACED SEVERAL TIMES; HOWEVER THE FAILURE WAS NOT CORRECTED. THE MANUFACTURER ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 03V281000 (SEATS). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 120,000 AND THE CURRENT MILEAGE AS 330,000.

MY LIGHTS DON'T WORK STABILIZING BAR IS BAD,SPEED CONTROL DOSE NOT WORK SECURITY KEY CODE NOT WORKING,DOOR CONTROLS DO NOT WORK.WIPER WORK SOMETIMES.BALL JOINT ARE BAD, TIRES WEARING BAD,,BUSHINGS ARE VERY BAD.TRANSMISSION IS STARTING TO SLIP,ALL WHEEL DRIVE DOES NOT WORK, IT GRINDING SOUND.HEAF LIGHT ONLY BRIGHTS WORK.

I RECENTLY FOUND OUT MY VEHICLE HAS AN OPEN RECALL REGARDING THE POSSIBLE LEAKAGE OF THE SPEED CONTROL DEACTIVATION SWITCH, WHICH COULD CAUSE A FIRE WHETHER THE VEHICLE IS RUNNING OR NOT. THE FORD MANUFACTURER'S RECALL #09S09 AND THE NHTSA RECALL #09V399000. THIS IS STILL AN OPEN RECALL.I CONTACTED FORD RECALL CENTER TODAY AND THEY ARE REFUSING TO REMEDY THIS HAZARDOUS RECALL DUE TO THE AGE OF THE RECALL AND THE AGE AND MILES OF MY VEHICLE. THIS IS A SAFETY ISSUE AND FORD SHOULD FIX IT AS BODILY INJURY OR EVEN POSSIBLE DEATH COULD OCCUR IF THIS RECALL IS NOT REMEDIED. MY VEHICLE IS RUNNING PROPERLY FOR THE MOMENT BUT SINCE THIS IS A SAFETY ISSUE, FORD MOTOR CO. SHOULD BE REQUIRED TO FIX IT NO MATTER THE AGE OF MY VEHICLE.

TL*THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED THAT ON THREE DIFFERENT OCCASIONS, THE VEHICLE SHUT OFF AND THE KEYS COULD NOT BE REMOVED FROM THE IGNITION. ADDITIONALLY, THE VEHICLE SUDDENLY ROLLED BACKWARDS. THE DEALER WAS NOTIFIED OF THE ROLL BACKS. THE CONTACT PLACES BRICKS BEHIND TWO WHEELS TO KEEP THE VEHICLE SECURE. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE IS 120,000 AND FAILURE MILEAGE WAS 100,000.

PARKED ON A SLIGHT SLOPE WITH THE ENGINE OFF, MY 97 FORD EXPLORER ROLLED BACK 5 FEET BY ITSELF, COMING CLOSE WITH COMING TRAFFIC! *NM

THE DRIVERS SIDE SEATBELT WILL NOT ENGAGE TO THE LOCK POSITION.

DRIVER SIDE SEAT BELT BUCKLE WILL NO LONGER SECURELY LATCH. *TR

TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH WHEN HE WAS INFORMED THAT A FIRE HAD ERUPTED FROM UNDER THE VEHICLE. THE CONTACT WAS ABLE TO MOVE THE VEHICLE OFF THE ROADWAY AND EXIT THE VEHICLE JUST AS IT BURST INTO FLAMES. THE POLICE ARRIVED TO ASSIST AND A POLICE REPORT WAS AVAILABLE. THE FIRE WAS EXTINGUISHED AND THE VEHICLE WAS TOWED TO AN UNDISCLOSED LOCATION. THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT TO TAKE PICTURES OF THE FAILURE AND DAMAGES. THE CONTACT WAS ALSO INFORMED THAT THE VEHICLE WAS UNDER RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 98V060000 (FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS), WHICH COULD POSSIBLY HAVE BEEN THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 234,000.

TL*THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT SMELLED GASOLINE IN THE VEHICLE AND AFTER LOOKING UNDERNEATH THE HOOD HE NOTICED THAT THE FUEL LINE WAS LEAKING FROM A BRACKET BEHIND THE MOTOR. THE CONTACT SPOKE TO THE MANUFACTURER ABOUT RECALL CAMPAIGN 98V060000, FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS, BUT THE MANUFACTURER STATED THAT THE RECALL HAD CLOSED. THE CURRENT AND FAILURE MILEAGES WERE 118,034.

THE DRIVER SIDE INTERIOR DOOR HANDLE RETURN SPRING UNSEATED RESULTING IN INTERIOR DOOR HANDLE THAT DOES NOT RETURN TO THE FULLY STOWED POSITION AFTER ACTUATION. IF THE INTERIOR DOOR HANDLE RETURN SPRING IS UNSEATED, COULD THE DOOR UNLATCH IN THE EVENT OF A SIDE IMPACT CRASH, INCREASING THE RISK OF PERSONAL INJURY? *TR

I OWN A FORD EXPLORER XLT 1997 AND THE REAR PASSENGER DOOR ON THE DRIVERS SIDE ONLY OPENS FROM THE INSIDE WHILE THE OTHER REAR PASSENGER DOOR WILL NOT OPEN FROM THE INSIDE OR OUT (CHILD LOCK NOT ACTIVATED). THE DRIVERS DOOR DOESN'T LOCK AND WHEN IT DOES LOCK, IT DOESN'T UNLOCK OR STICKS SO BAD IT HAS BE UNLOCKED WITH PLIERS, CAUSING THE DRIVER TO HAVE TO GET IN AND OUT OF THE CAR THROUGH THE FRONT PASSENGER SIDE DOOR. THE INTERIOR MAP LIGHT AND REAR INTERIOR DOOR LIGHT ABOVE THE BACKSEATS STAY ON CONSTANTLY EVEN WHEN SWITCHED OFF AND THE LIGHTBULBS HAD TO BE REMOVED BECAUSE THEY WOULDN'T TURN OFF AND WERE OVERHEATING. *TR

MULTIPLE ISSUES WITH VEHICLE WHEN TURNING EITHER RIGHT OR LEFT VEHICLE COMES TO A COMPLETE STOPS THEN A VERY LOUD BANG IS HEARD, TOLD IT WAS HUB BUT REPLACED HUB AND STILL HAPPENS, WAS ALSO TOLD IT WAS U-JOINT ON DRIVE SHAFT HAVE YET TO REPLACE IT HAVE NOT NOTIFIED DEALER AS OF YET. *TR

CONSUMER STATES THAT WHILE DRIVING AT ANY SPEED AND WITH NO WARNING STEERING BOLTS ARE LOSE AND IT IS CAUSING THE STEERING WHEEL TO JUMP AROUND, MAKING IT HARD FOR CONSUMER TO STEER THE VEHICLE. DEALER NOTIFIED.*AK

1997 FORD EXPLORER DRIVER'S SEAT BELT LATCH RECEIVER FAILURE. AFTER OWNING THE CAR FOR 12 TO 13 YEARS, THE LATCH/RECEIVER WOULD NOT ENGAGE THE STRAP. I REPLACED IT WITH ONE FROM A SALVAGE YARD AND AFTER THREE YEARS THIS REPLACEMENT LATCH/RECEIVER HAS FAILED ALSO. *TR

TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE CONTACT STATED THAT THE RIMS WERE COMPLETELY RUSTED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.

THIS LETTER IS INTENDED TO ADDRESS INEFFECTIVE SERVICE BY AAMCO THAT LED TO FAILURE OF A TRANSMISSION IN MY VEHICLE. AS YOU SEE BY THE ATTACHED LETTER, I VOICED CONCERN ABOUT THIS LAST YEAR AND ALL AAMCO SUGGESTED WAS TO TAKE IT BACK TO THE DEALER THAT PERFORMED THE INEFFECTIVE SERVICE. I REQUESTED THE RIGHT TO TAKE THE VEHICLE TO ANOTHER AAMCO CENTER, BUT YOUR RESPONSE WAS TO TAKE IT TO THE CENTER THAT I ALREADY HAD DOUBTS ABOUT. LET ME SET THE SCENARIO AGAIN. ?WITH INITIAL GRINDING SOUNDS AND LACK OF REVERSE, I TOOK TO CLINTON TRANSMISSIONS IN 2011 AND THEY INFORMED ME THE TRANSMISSION NEEDED TO BE REBUILT. THE VEHICLE WAS PARKED UNTIL 2012. ?IN 2012, I CALLED THE WALDORF AAMCO CENTER AND THEY INFORMED ME IT MAY NOT BE THE TRANSMISSION AND TO LET THEM LOOK AT IT. IT WAS TOWED IN AND I WAS INFORMED THAT THE TRANSMISSION WAS FINE BUT THE TRANSFER CASE WAS BAD. ?ALL TOTALED, I PAID $1534.76 FOR TRANSFER CASE, $430.03 FOR PARTS, AND $600 FOR LABOR. THIS DOES NOT INCLUDE THE OTHER SERVICES THAT THE CENTER SAID I NEEDED. ?THE VEHICLE WAS TAKEN BACK TWICE FOR AN OD LIGHT THAT CAME ON AS SOON AS I LEFT THE CENTER. THEY SEEMED UNABLE TO DIAGNOSE THE PROBLEM. ?I FELT CONCERN FOR THE PERIOD I WAS DRIVING AND WROTE CORPORATE TO REQUEST ASSISTANCE. ?EARLIER THIS YEAR WHILE DRIVING TO SOUTH CAROLINA, THE GRINDING SOUND STARTED AGAIN AND REVERSE WENT OUT. I NOTIFIED CORPORATE AND THE WALDORF CENTER AND WAS TOLD TO GO TO THE NEAREST AAMCO. ?I WENT TO THE COLUMBIA, SOUTH CAROLINA AAMCO AND AFTER DIAGNOSTIC, TOLD ME THE SAME THING THAT THE CLINTON TRANSMISSION TOLD ME IN 2011. THE TRANSMISSION HAD INTERNAL DAMAGE AND NEEDED TO BE REBUILT. ?I LEFT THE VEHICLE IN COLUMBIA AND HAD TO PURCHASE A NEW VEHICLE. WITH THESE FACTS IN MIND, AAMCO CAN SURELY SEE WHERE INEFFECTIVE SERVICE LED TO A SAFETY FAILURE. *TR

THE ENGINE SLOWED DOWN AND JUST QUIT. WOULD NOT RESTART. HAD IT TOWED TO A REPAIR FACILITY *AGAIN* AND FOUND OUT THAT *2 (TWO)* TIMING CHAINS WENT OUT. THE DRIVERS SIDE SNAPPED IN TWO AND THE PASSENGER SIDE (REAR) HAD OVER 1 1/2 INCHES OF PLAY IN IT AND OBVIOUS STRETCHING OF THE TIMING CHAIN. THE FRONT BROKEN ONE TOTALED THE ENGINE, ALL TENSIONERS, SPACERS ETC WERE NOR IN PIECES LYING IN THE ENGINE. AND GUESS WHAT TO REPLACE THE REAR TIMING CHAIN YOU HAVE TO COMPLETELY REMOVE THE ENGINE FROM THE VEHICLE! THANKS AGAIN FORD!!!!!!!! *TR

I WAS IN A FRONTAL CRASH ON 01/24/2012 THE AIR BAGS DIDN'T DEPLOY.CAUSING INJURIES, SEAT BELTS WERE WORE. *TT

TL* - THE CONTACT CALLED REGARDING A 1997 FORD EXPLORER. THE AIRBAGS DID NOT DEPLOY. THE DRIVER OF THE VEHICLE WAS DRIVING AROUND A CURVE, AND THE ROAD CONDITIONS WERE ICY AND SNOWY. THE DRIVER HIT AN EMBANKMENT HEAD ON AND THE VEHICLE FLIPPED OVER. THE DRIVER SUSTAINED FATAL INJURIES. THERE WERE TWO OTHER PASSENGERS IN THE VEHICLE THAT WERE NOT INJURED. IT IS UNCLEAR WHETHER THE DRIVER WAS WEARING THE SEAT BELT. ONE OF THE PASSENGERS REMOVED THE SEAT BELT AND THE OTHER PASSENGER'S SEAT BELT WAS NOT ON SO THAT THEY COULD GET OUT OF THE VEHICLE. IT WAS UNCLEAR WHETHER THE PASSENGER REMOVED THE SEAT BELT FROM THE DRIVER AS WELL. THE VEHICLE WAS TOWED TO A TOW SHOP WHERE IT REMAINED. THE CONTACT DID NOT TAKE POSSESSION OF THE VEHICLE AT THIS TIME. THE TOW SHOP PLANNED TO SELL PARTS OF THE VEHICLE. ITWAS UNKNOWN WHETHER THERE WERE PICTURES TAKEN OF THE VEHICLE. THE CONTACT HAD A POLICE REPORT THE CONTACT STATED THAT THE PREVIOUS OWNER SAID THAT THE VEHICLE HAD BEEN INVOLVED IN A RECALL FOR THE AIRBAGS IN THE PAST. *AK

THE 1997 FORD EXPLORER 4D EDDIE BAUER EDITION HAS A COMPUTER CONTROLLED MESSAGE CENTER. THE MESSAGE CENTER CONTROLS AMONG OTHER THINGS THE VEHICLE HEADLIGHTS AND FOG LAMPS. THE LIGHT OUT MODULE (LOM) ALSO KNOWN AS THE INDICATOR WARNING SYSTEM CONTROL IS LOCATED INSIDE THE MESSAGE CENTER CONSOLE AND RUNS "HOT" IN TEMPERATURE BECAUSE OF A FLAWED DESIGN. THE CURRENT DESIGN LEADS TO INTERNAL ELECTRICAL SYSTEM FAILURES THAT RESULT IN A LOSS OF THE LOW BEAM HEADLIGHTS. THE SYSTEM IS DESIGNED TO NOTIFY THE DRIVER OF A HEADLIGHT OR LAMP FAILURE, ETC, HOWEVER, THE FAILURE OF THE NOTIFICATION SYSTEM CAUSES THE LOW BEAM HEADLIGHTS (AND FOG LAMPS AS THEY ARE ON THE SAME CIRCUIT) TO FAIL. ON JUNE 25, 2014, THE SECOND FAILURE OF THE SYSTEM OCCURRED (WE ARE THE ORIGINAL OWNERS AND HAVE PREVIOUSLY REPLACED THE INDICATOR WARNING SYSTEM CONTROL OR LIGHT OUT MODULE (LOM) AT GREAT EXPENSE). FORD MOTOR COMPANY MUST RECALL THE 1997 FORD EXPLORER EDDIE BAUER EDITION AND ANY OTHER LIKE DESIGNED FORD PRODUCT WITH A LIGHT OUT MODULE (LOM) THAT FAILS LEAVING THE DRIVER WITHOUT LOW BEAMS AND NO MEANS OF FIXING THE SAID DEFECT WITHOUT AN AUTHORIZED FORD DEALER'S REPAIR (AT GREAT EXPENSE) THAT IS LIFE THREATENING IN THE INTERIM. SUCH REPAIRS ARE NOT POSSIBLE IF ON AN EXTENDED TRIP IN RURAL SETTINGS. THE ABSENCE OF LOW BEAM HEADLIGHTS AFTER SUNSET AND BEFORE SUNRISE IS LIFE THREATENING AND UNACCEPTABLE TO THE OCCUPANTS OF A 1997 FORD EXPLORER AS WELL AS TO PEDESTRIANS AND OTHER VEHICLES WHO CANNOT SEE THE FORD EXPLORER OPERATING WITHOUT HEADLIGHTS. THE CORRECTIVE SOLUTION NEEDS A VENTING SYSTEM SUCH THAT THE MESSAGE CENTER DOES NOT CONTINUALLY MELT THE INDICATOR WARNING SYSTEM CONTROL OR LIGHT OUT MODULE (LOM). THANK YOU FOR YOUR SERVICE AND FOR YOUR PROMPT ATTENTION TO THIS DEFECT REQUIRING A CORRECTIVE RECALL. *TR

I OWN A FORD EXPLORER XLT 1997 AND THE REAR PASSENGER DOOR ON THE DRIVERS SIDE ONLY OPENS FROM THE INSIDE WHILE THE OTHER REAR PASSENGER DOOR WILL NOT OPEN FROM THE INSIDE OR OUT (CHILD LOCK NOT ACTIVATED). THE DRIVERS DOOR DOESN'T LOCK AND WHEN IT DOES LOCK, IT DOESN'T UNLOCK OR STICKS SO BAD IT HAS BE UNLOCKED WITH PLIERS, CAUSING THE DRIVER TO HAVE TO GET IN AND OUT OF THE CAR THROUGH THE FRONT PASSENGER SIDE DOOR. THE INTERIOR MAP LIGHT AND REAR INTERIOR DOOR LIGHT ABOVE THE BACKSEATS STAY ON CONSTANTLY EVEN WHEN SWITCHED OFF AND THE LIGHTBULBS HAD TO BE REMOVED BECAUSE THEY WOULDN'T TURN OFF AND WERE OVERHEATING. *TR

THE DIAL THAT CONTROLS THE HOT/COLD FEATURE OF THE HEATING/AIR-CONDITIONING UNIT IN MY 1997 EXPLORER MALFUNCTIONED. WHEN TAKEN IN TO DEALER THE SERVICE MANAGER TOLD ME THAT THEY HAVE BEEN SEEING ALOT OF THIS PROBLEM IN EXPLORERS AND THE SERVICE TECHNICIAN SAID HE WAS CONCERNED WITH IT HAPPENING IN HIS MOTHER'S CAR. *AK

CANNOT ADJUST THE TEMPERATURE OF THE HEATING AND COOLING SYSTEM - ALWAYS BLOWS COLD AIR. I HAVE BEEN TOLD THE MANUFACTURER INSTALLED THE WRONG PARTS AT TIME OF PRODUCTION. THE PART FAILS AND THEN YOU CANNOT ADJUST THE TEMPERATURE - IT ALWAYS BLOWS COLD AIR. THIS, IT SEEMS TO ME, IS A SERIOUS SAFETY ISSUE AS IT IS IMPOSSIBLE TO KEEP WINDOWS CLEAR IN COLD CLIMATES. *LA