2017 Ford F-150 Electrical Problems

The vehicle experienced intermittent transmission-related drivability issues before the recall remedy was available. The vehicle had delayed/hard shifting, an intermittent wrench warning light, and a reduced power/limp mode condition where the transmission would not shift normally. The vehicle was inspected by an authorized Ford dealer on multiple occasions, including diagnostic visits on 10/09/2023, 05/12/2025, and 02/09/2026. Ford later issued recall 26S28 involving the powertrain control module/transmission control system, and the recall remedy was performed. After the recall repair was completed, the original drivability concern continued, including sluggish shifting and delayed engagement between gears. As a second attempted repair related to the wrench warning light and transmission concern, the dealer identified the possibility of a faulty transmission lead frame and reviewed replacement under the applicable coverage. However, the dealer refused to replace the lead frame because the related fault code was not currently present during their inspection. The intermittent nature of the failure causes the code to clear after the vehicle is restarted, making it difficult to capture during a dealer visit. I provided photographic proof showing the wrench warning light was present after picking up the vehicle on the same day the recall repair was supposedly completed. Despite this evidence and the continued symptoms, the lead frame replacement was not performed. The vehicle has not been involved in a crash, but the intermittent loss of normal transmission operation creates a safety concern, especially during acceleration, merging, or uphill driving. The issue has been reported to Ford and inspected by a Ford dealer. Repair documentation, photos, and service records are available.

NHTSA ID

11750956

Incident

Jul 14, 2026

my 6 speed transmition started shifting erratically. i took it to ford dealership and they did a pcm software download recall and it didnt help. the technition said he drove it and put on the wokorder. no codes stored issue not in leadframe. 1no codes stored to replace leadframe. transmition not shifting properly, most likely cause is internal clutch burnt. i asked what my next thing to do was and she said they would only change the transmition at my cost. this truck is shiftng in 5th and keeps shifting ranomly without showing on the gear panel. it does the same in 6th gear. between 4th and 5th it shifts real hard. all the symtoms of the lead frame recall and they said they wont touch it unless i put a new transmition in.

NHTSA ID

11749588

Incident

Jul 6, 2026

The April 2026 recall for the 6R80 transmission (2015- 2017 F-150s) involves a software update to prevent unintended downshifts to first gear, which, if left unaddressed, can cause significant damage to the transmission and torque converter. The recall aims to prevent this damage, not cause it, though the underlying defect—if it causes violent, abrupt downshifts-can lead to transmission failure, including issues with the torque converter. The pcm tells the transmission what gear to shift into. The trs is what signals the pcm to tell the transmission what gear to shift into. I am saying all of this because I am have a bad downshifting problem almost like it’s causing the transmission to slip it has been doing this for months and I think it is causing more failure in my truck. It is getting worse and worse and this is my only reliable vehicle to get to work. I’ve called ford and they told me to keep driving but I don’t feel safe. They also quoted me for a new transmission saying the problem will occur again if I get one so I don’t get the point in doing that but I think it’s causing my transmission to go out and my torque converter to go out. I am out of ideas and don’t know what to do. I cannot afford a new transmission and it’s unfair to me that it’s their problem and I got quoted a new transmission. Also if I keep driving it and it messes up they are going to deny that that recall isn’t the problem I’m not sure what to do.

NHTSA ID

11749166

Incident

May 6, 2026

My vehicle is currently subject to an open Ford transmission safety recall for which no repair remedy is available at this time. The vehicle is experiencing a recurring and dangerous failure while driving. Approximately twice per day, during my normal commute, all vehicle electronics suddenly shut off while the vehicle is in motion. At the same time, the wheels appear to lock up, causing a sudden loss of vehicle control and creating a significant crash risk. When the failure occurs, I am forced to immediately shift the transmission into neutral while the vehicle is still moving. After approximately 5 to 10 seconds, I can shift back into drive and continue operating the vehicle. However, vehicle electronics often remain inoperative for the remainder of the trip. This condition is occurring repeatedly and has become more frequent. The issue currently occurs approximately once during my drive to work and once during my drive home. My commute is approximately 20 minutes each way. The vehicle has not yet been involved in a crash, but I believe a crash is likely if this condition continues. The sudden loss of power, loss of electronics, and wheel lockup while driving creates an immediate safety hazard to myself, my passengers, and other motorists. I am submitting this complaint because the vehicle is subject to an active safety recall, the condition appears related to the recall, and no repair remedy is currently available. I believe the vehicle is unsafe to operate

NHTSA ID

11741380

Incident

Jun 1, 2026

My truck after doing all the symptoms stated in the recall a ford technician deemed it unsafe to drive has been grounded since May 9th the dealer nor ford manufacture will give me a rental.or help in anyway..so June 9th will be 30 days for a truck I cant drive and still making payments and have full coverage on that I have to pay for it would appreciate if ford would help or buy it back

NHTSA ID

11739877

Incident

May 8, 2026

While driving the car immediately downshifted and I could not accelerate. The Hill assist came on and service advance trac came on. This happened 3 times. The first time we towed it to the dealership April 17th, and they changed the oil and tested the battery secured wires and verified after the repair on April 26th. After we picked the truck up on April 26th it stalled on the highway on the home and we had it towed again. They kept it for 4 days drove it 80 miles and said nothing was wrong no repair was done or needed. On May 13 it stalled again in front of train tracks. Luckly I was able to stop and start it quickly to drive it to a near dealership. We picked up the truck today, and it stalled again on the way home. We drove it back to the dealership today, May 23rd, hopefully they can figure it out. We are again without a car for a long period of time. We have paid $1,964.10 in repairs that have not fixed the problem. The way the truck stops so suddenly is very dangerous as it happened once getting on the highway and once in front of a train track.

NHTSA ID

11739723

Incident

May 23, 2026

Vehicle: 2017 Ford F-150 2.7 EcoBoost, 6R80 transmission VIN: [XXX] While driving at highway speed (approximately 150 km/h / 93 mph) during an overtaking maneuver and moderate-to-heavy acceleration, the vehicle experienced a sudden harsh transmission event. The transmission abruptly entered limp mode and became stuck in 3rd gear. A wrench warning light appeared with the message “See Manual.” The vehicle immediately lost normal acceleration capability and could only continue driving in reduced-power mode. The malfunction occurred suddenly and without prior warning while traveling at high speed. This created a potentially dangerous traffic situation during highway overtaking. After stopping and restarting the vehicle, the transmission returned to normal operation. Diagnostic scan performed using FORScan retrieved DTC code: P0768 – Shift Solenoid D Electrical. The symptoms appear consistent with the currently announced Ford recall involving the 6R80 transmission lead frame / transmission range sensor issue causing unintended harsh downshifts or transmission malfunction. The vehicle is currently located in Poland after being imported from the United States, but the VIN is included in the active NHTSA/Ford recall database. No collision occurred, however the sudden transmission malfunction at highway speed created a serious safety concern. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11739193

Incident

May 9, 2026

While driving about 60 mph on the highway, all warning lights on the dash suddenly came on and the truck immediately lost power/shut down. The wheels sputtered or somethting like that, not sure how to describe it. I was able to safely get off the road and restart the truck. After restarting, it drove normally again with no obvious issues. I recently received a recall notice describing very similar symptoms related to the transmission/lead frame issue, but the notice stated no remedy was yet available. This created a serious safety concern because the failure happened unexpectedly at highway speed. Here is the recall info: Issue Date 2026-04-14 Campaign 26S28/26V237

NHTSA ID

11738478

Incident

May 18, 2026

The BCM keeps failing on my truck when it has already been replaced. The lights won’t stop flashing unless the battery is unplugged.

NHTSA ID

11737782

Incident

May 1, 2018

The front driver door lock/latch actuator is failing. The driver door does not lock or unlock using the key fob or the interior power lock button. The only way to lock or unlock the door is manually with the key or by pushing/pulling the lock from inside the vehicle. This issue started shortly after we had a historic/unusual cold freeze in Florida. The vehicle is kept outside, so it was exposed to the freezing temperatures. This creates a safety and security concern because the driver door power lock system does not work properly and may prevent the door from locking or unlocking normally when needed. The issue has not yet been inspected by a dealer or independent repair shop. No warning lights or messages appeared before the failure. The component is still installed on the vehicle and available for inspection upon request.

NHTSA ID

11737759

Incident

Feb 11, 2026

Between 35 -45 mph transmission seems confused on shifting, sounds like sensor or fluid control issue, also mild periodic vibrations 1-2 sec at random times Also 12v to 120 v transformer constantly faults even when low amp device is connected. Both have been previously reported this to service dept but issue seems to be ignored...

NHTSA ID

11737722

Incident

May 13, 2026

Took my 2017 Ford F-150 in for a diagnostic on May 8 2026 for wrench symbol check engine light and issues down shifting and sliding tires shop manager and technician claimed the vehicle is unsafe to drive and talked to the Service manager deemed the vehicle unsafe to drive wanted it grounded do to the safety concerns related to Recall 26S28 (PCM/TRS) stated the down shifting is cause catastrophic failure to all mechanical components transmission engine and rear end kidding the tires especially in wet weather the truck would cause a accident..cause the sliding of the tires..so my truck is at APPLE FORD OF LYNCHBURG GROUNDED as of May 9 2026 I still owe on the truck and have no ride dealer nor manufacture was willing to pay for a rental that cost $65 a day wanted me to pay then reimburse me once a remedy was available I cant afford that..1600 a month we are roughly 2 months away from hopefully a remedy being available stated by recall website.. so if my truck is showing all the signs of the described in the recall(26S28) has stated in it why is FORD not putting a DO NOT DRIVE on the recall for all these trucks if the technician seems them unsafe.. I shouldn't have to pay for a rental I cant afford cause ford is lacking a remedy and wont even buy it back cause of safety issues codes PO732 INCCORECT 2ND GEAR RATIO

NHTSA ID

11736757

Incident

May 8, 2026

going down highway (60mph) a sudden rear wheels lock up jerking the steering wheel out of my hand sudden down shift causing me to be put in the median...wrench symbol pops up trucks in limp mode... no 1-6 gear light or light to show if i am in P.R.N.D.M.1.2. Truck won't start back up until it wants too if you cut it off in limp mode (factory reset) unhooking negative battery cable dosent work. Check engine light appear had is scanned showed issues with body control, modules power control modules and the Transmission range sensor power steering loss of voltage.. It constantly does it when ever it wants to with no warning with conditions getting worse truck now pops out of gear when stopped if in limp mode. Wrench symbol never disappears still no 1-6 light on the dash.the sudden down shift only occurs sometimes but down shift is called a money shift its catastrophic to all mechanical components (Transmission.Motor. Rear End) truck being diagnostic at Ford in a few days..Cooperate contact has been made multiple times with no help!!!

NHTSA ID

11735917

Incident

Apr 14, 2026

The contact owns a 2017 Ford F-150. The contact stated that while driving in fifth gear, the vehicle suddenly downshifted into second gear. Five minutes later while driving in third gear, the vehicle abruptly downshifted to second gear. The fault with the electrical system was displayed. The recall letter for NHTSA Campaign Number 26V237000 (Power Train) was received. The vehicle was taken to an independent mechanic, but no assistance was provided. The local dealer was contacted, who informed the parts were not available. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was approximately 129,000.

NHTSA ID

11735769

Incident

Apr 3, 2026

Mileage

129,000 mi

Odometer Fraud. The contact purchased a 2017 Ford F-150. It was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 118,337. At the time of registration, it was discovered that the mileage was 218,000.

NHTSA ID

11732759

Incident

Apr 21, 2026

Mileage

218,000 mi

My 2017 F150 5.0. The transmission shift sensor is intermittent. changing gears while driving at low speeds. The indication panel flashes like a Christmas tree.It locked up the brakes twice. Why isn't there a recall for it. The truck only has 73000. Miles.

NHTSA ID

11730657

Incident

Apr 11, 2026

I started my truck this morning and turned on the heat and defrost. Came inside to gather my things for work and when I returned back there was a strong burning smell both inside and outside. I placed my work items in the back seat, closed the door. I heard something falling and found the back windshiled windshield had exploded.

NHTSA ID

11728399

Incident

Mar 31, 2026

Vista Roof not operating as intended

NHTSA ID

11727641

Incident

Mar 28, 2026

While driving vehicle shifts from 6 gear to first gear on 6r80 transmission amd hard shifts..wheels lock upbwhen vehicle downshifts abruptly.....spoke with ford mechanic and this is a known issue with lead shield and or speed sensor.. this item need a recalled and repaired...no codes are thrown but it is a well know issue...recalls are on 10r80 transmissions lead shield but not 6 speed. Please help

NHTSA ID

11723775

Incident

Mar 12, 2026

While driving down the road all of a sudden vehicle slams then shifts down indicator lights for gear selection starts flashing. It has happened 4 times so far this week February 17, February 19 of 2026.

NHTSA ID

11719136

Incident

Feb 17, 2026

THe rear camera displays vertical lines. The camera has been replaced, the tailgate wiring harness has been replaced. The wiring integrity has been verified by Ford technician. The code B115E-08 is diagnosed. Ford wants $1000 to 'replace ' the camera.???? I bought a new camera. Its NOT a faulty camera. There are 100,000+ 2017 Ford truck recalls for this same issue. Its all over Ford F150 Forum, Google etc. Why isnt my truck included? All Ford wants to do is replace all the modules and send me on my way for $1000

NHTSA ID

11719034

Incident

Jun 4, 2025

I bought my 2017 Ford Shelby F150 (V8 5.0L, 6R80 transmission) used from a dealership in 2022, and noticed when depressing the Sport mode on the shifter, and hard acceleration, that the truck will suddenly downshift to a very dangerous gear while on the freeway. I heard the NTSA engineering analysis that is ongoing, and wanted to include my experience. Since I don't touch the Sport mode on the truck, it has not happened since. Ford needs to do a recall on this VERY dangerous issue.

NHTSA ID

11717608

Incident

Mar 22, 2025

While driving, my 2017 Ford F‑150 experienced a sudden loss of the Output Shaft Speed (OSS) sensor signal, causing the transmission to stay stuck in a higher gear and triggering the wrench light. The truck lost power and would not shift properly. A diagnostic scan showed two transmission codes: one for the OSS sensor and a second code indicating an intermittent electrical signal drop. I contacted a Ford dealer before the repair, described the symptoms, and asked for an estimate. The service advisor did not disclose any known issues and never called me back after saying he would check parts availability. These symptoms match the known failure pattern of the molded lead frame in the 6R80 transmission. My truck exhibited intermittent behavior, harsh shifting, and unsafe drivability. I had to pay $1,250 out of pocket to replace the lead frame to restore normal operation. I later learned that NHTSA has opened an Engineering Analysis into 2015–2017 F‑150 trucks for this exact issue (OSS signal loss due to internal electrical degradation of the lead frame). My vehicle’s symptoms, diagnostic codes, and required repair are consistent with the defect under investigation. This failure creates a safety hazard because the truck can suddenly lose the ability to accelerate or shift correctly, especially in traffic or at highway speeds. I am requesting that NHTSA include my vehicle in the investigation and that Ford be required to address this defect.

NHTSA ID

11716402

Incident

Dec 10, 2025

I seen there were some issues going around with the 6r80 and wanted to voice my concerns as I am having this issue as well. Intermittently ive been having issues where ill be driving, could be doing 65 down the highway. The wrench light pops up for a second and my truck slams down into 2nd or 3rd gear and goes into limp mode. This could happen at any given time without warning. This just happened to me on Monday, went and got a code reading, and have a code for the output shaft speed sensor. Although I was fine, it is certainly not okay the truck just decided to slam down into gear ultimately slowing down the vehicle tremendously fast while being in traffic. Could have caused an accident or worse.

NHTSA ID

11716064

Incident

Feb 2, 2026

Odometer Fraud. The contact purchased a 2017 Ford F-150. It was discovered that there was a mileage discrepancy. The vehicle was a private sale. The contact stated that it was discovered that the mileage on the title was 205,690. At the time of purchase, the vehicle mileage was 104,000, and the Carfax report listed the mileage at 189,000.

NHTSA ID

11707842

Incident

Jun 5, 2025