2019 Ford F-250 Sd Powertrain (other) Problems

At around 139,000 miles i started to noticed some intermittent noise coming from the drivetrain. I took it to two different repair shops and was told it was tire noise. over time the grinding noise increased to the point of shuddering and jerking while shifting with no warning lamps showing. At 144,500 miles I contacted my aftermarket warranty and they said to take it to a certified shop to get it checked out. They did not have any preferred shops in my area so I took it to US Automotive. At 145,000 miles the shop contacted the warranty company and proceeded with investigation of the issue. After inspection and tear down they confirmed the transmission had the typical failure for the 10R80 10-speed automatic transmissions. They turned over there findings and the warranty company which has agreed to the findings and has offered a replacement used transmission with 125,000 miles on it and will also not cover the full cost to install the used unit. I feel that this is fraud and outside of the warranty agreement. I am now paying the expense to put the original transmission back into the truck to try to take it the 2.5 hours back to the dealership which sold me the truck along with the warranty to see what they will do in the matter. I hope it doesn't fail on the highway on the way.

NHTSA ID

11745407

Incident

Jun 5, 2026

My truck transmission changes gears randomly while in motion. It is terrifying when it happens in traffic and the truck stalls and looses power then kicks back in with a loud noise. I stopped driving it since March of 2026.

NHTSA ID

11739763

Incident

Jan 21, 2026

Violent shaking when driving at high speeds and after hitting bumps or uneven streets

NHTSA ID

11697494

Incident

Nov 3, 2025

transfer case is shifting from 2 wheel high to 4 wheel high while driving down the highway. it does not engage the the 4wheel drive front hubs when doing this so no indication this is happening. eventually the shift fork breaks and transfer case is then either locked in 4 wheel high without knowing or the transfer case goes to a neutral position and loss of all power. in the my incident i was driving on the interstate and transfer case went to neutral without warning. i was in the middle of 4 lanes of traffic and total loss of movement. i was able to navigate the truck to the side of the interstate safely. however had this been in the middle of rush hour traffic this would most likely been a fatality report with multiple cars involved. After discussions with ford techs i was advised this is an ongoing issue that has not been addressed by ford and they are seeing more and more of these issues, so much so that their transmission techs are backed up for 3-5 weeks with these repairs. seems to me this kind of failure nhtsa would be very aware of and demanding a recall be issued to fix this issue. rather the owners are eating the cost of repair for a blatant safety issue being over looked.

NHTSA ID

11633031

Incident

Dec 17, 2024

The contact owns 2019 Ford F-250. The contact stated while the vehicle was at the dealer for routine maintenance, the dealer informed the contact that the heat shield had detached. The dealer determined that the driveshaft and the heat shield needed to be replaced. The contact related the failure to NHTSA Campaign Number: 22V087000(Structure, Power Train); however, the VIN was not included. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 105,000.

NHTSA ID

11623390

Incident

Sep 20, 2024

The contact owns a 2019 Ford F-250. The contact stated that there were oil stains on the driveway where the vehicle was parked. The vehicle was taken to the dealer, where it was diagnosed and determined that the rear main seal had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 68,900.

NHTSA ID

11608968

Incident

Aug 6, 2024

Mileage

68,900 mi

I was driving at 60mph when the truck started shaking so bad I had to come to a complete stop. I could barley steer the truck when this was happening.

NHTSA ID

11603346

Incident

Jul 19, 2024

TRAVELING AT HIGHWAY SPEEDS ON THE INTERSTATE THE TRUCK BEGAN TO SHAKE VIOLENTLY AND THE STEERING WHEEL BEGAN SHAKING SO HARD THAT I HAD DIFFICULTY HOLDING ONTO IT. THE TRUCK WAS OUT OF CONTROL AND I ALMOST WENT INTO THE GUARD RAIL BEFORE I COULD SLOW DOWN TO A STOP AND BRING THE TRUCK UNDER CONTROL. I MADE IT TO MY DESTINATION AND LOOKED AT THE UNDERSIDE OF THE TRUCK AND COULD NOT FIND ANYTHING BROKEN. ON THE WAY BACK HOME, THE TRUCK DID THE SAME THING AGAIN AFTER HITTING A BUMP AND I HAD TO STOP AGAIN TO GET THE STEERING WHEEL TO STOP SHAKING - WHICH WAS VERY CONCERNING BECAUSE OF THE AMOUNT OF TRAFFIC I WAS IN. THERE WAS NO WARNING EITHER TIME THAT THIS WAS GOING TO HAPPEN. GOING TO THE DEALERSHIP TOMORROW!

NHTSA ID

11555940

Incident

Nov 18, 2023

We have the Ford "death wobble"—have had a few scary incidents on the freeway at speeds 50 or above.

NHTSA ID

11518423

Incident

Jan 11, 2023

I was driving approximately 60 mph. There were several small bumps in the road and the Truck went into a Very Violent Shake and Wobble. This is commonly known as the FORD DEATH WOBBLE... Very Scary and Dangerous. The Vehicle was extremely hard to control. Luckily the service advisor at Coggin Ford had warned me about this possible condition. I was told if this wobble ever happened to let immediately back off the accelerator and not Touch the Brakes?? I did exactly as he said and was able to get the truck into the Emergency Lane where I slowed down in a slow and dangerous way. I took the Truck to Coggin Ford. The truck has only 21000 miles. They claim it just needs an alignment and a steering Dampener which was already changed by Ford at 2500 miles? The service department told me that the parts are unavailable but the think it needs an alignment? The alignment was fine until the Death Wobble?? This is a dangerous condition that could have killed myself, my daughter or other drivers... Please let me know what the NHTSA is doing to prevent this from causing accidents and let me know what my options are... Thank you, Philip Monson 904-487-8936

NHTSA ID

11502236

Incident

Jan 11, 2023

“Death wobble” violent shaking going 50+ miles per hour.

NHTSA ID

11498476

Incident

Dec 19, 2022

Uncontrollably shaking (death wobble). Lost control and had to brake quickly.

NHTSA ID

11491703

Incident

Oct 28, 2022

The contact owns a 2019 Ford F-250. The contact stated while driving 75 MPH, the steering wheel started moving violently from side to side. The contact stated that he had experienced the death wobble. There was no warning light illuminated. The contact depressed the brake pedal until he regained control of the vehicle. The contact was able to veer to the side of the road momentarily. The contact was then able to continue driving. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 87,640.

NHTSA ID

11491359

Incident

Oct 28, 2022

Mileage

87,640 mi

I understand that my truck has the Death Wobble. No warning lights, truck shakes vigorously driving on rough roads at 70mph

NHTSA ID

11487534

Incident

Sep 30, 2022

If I hit a bump going over 50mph my vehicle will violently shake until I slow down or stop.

NHTSA ID

11487339

Incident

Sep 30, 2022

Rear passanger axel bolts snapped in half

NHTSA ID

11480832

Incident

Aug 19, 2022

We started having a death wobble while driving between 60-70mph where the steering wheel shook Violently and the vehicle shook so back it hurt and scared me and my kids in the back seat. It was very scary and almost caused me to wreck with my kids in the car on the interstate. We then looked up and saw there was a recall for this problem. We took the truck into a dealership and got it supposedly repaired. It did not work. Roughly 1 month later. I was trusting Ford fixed the issue and on the interstate again and almost wrecked a second time with the kids in the car. This truck shouldn’t be allowed on the road of ford doesn’t have a fix. My business partner has the exact same truck and the exact same scenario occurred where he got the issue fixed at a dealership after almost crashing only to have it happen again. Currently we don’t know what to do as we paid big bucks for a vehicle that isn’t safe to drive, R. Clites

NHTSA ID

11474229

Incident

Jun 28, 2022

We started having a death wobble while driving between 60-70mph where the steering wheel shook Violently and the vehicle shook so back it hurt and scared me and my kids in the back seat. It was very scary and almost caused me to wreck with my kids in the car on the interstate. We then looked up and saw there was a recall for this problem. We took the truck into a dealership and got it supposedly repaired. It did not work. Roughly 1 month later. I was trusting Ford fixed the issue and on the interstate again and almost wrecked a second time with the kids in the car. This truck shouldn’t be allowed on the road of ford doesn’t have a fix. My business partner has the exact same truck and the exact same scenario occurred where he got the issue fixed at a dealership after almost crashing only to have it happen again. Currently we don’t know what to do as we paid big bucks for a vehicle that isn’t safe to drive,

NHTSA ID

11474227

Incident

Jul 1, 2022

The contact owns a 2019 Ford F-250. The contact stated while driving 80 MPH, the vehicle started staking without warning. The contact was able to pull over on the side of the road and after several minutes the vehicle started operating as designed. The contact stated that the failure reoccurred. An appointment with the dealer was scheduled for the vehicle to be diagnosed. The manufacturer was not contacted. The failure mileage was 45,000.

NHTSA ID

11471622

Incident

Jun 26, 2022

Mileage

45,000 mi

AT 60-70 MPH THE FRONT END BEGINS A SERIES OF VIOLENT SHIMMY OR WOBBLES. IT IS A RECURRING ISSUE. THE SERVICE TECHS REFER TO IT AS THE DEATH WOBBLE. i WAS TOLD IT NEEDED A STEERING GEAR REPLACE INITIALLY. TODAY I WAS TOLD IT WAS A STEERING DAMPNER. I HAD THE TRUCK EVALUATED ON 5/26/22 AT PHIL LONG FORD AT MOTOR CITY WHERE I PURCHASED THE VEHICLE NEW. I AM CONCERNED THAT THIS "WOBBLE" COULD CAUSE A LOSS OF CONTROL AND JEOPADIZE MY SAFTEY AS WELL AS ANY FAMILY MEMBERS THAT MAY BE TRAVELING WITH ME

NHTSA ID

11467160

Incident

May 18, 2022

My husband and I were driving 70mph, the speed limit was 75mph. Our truck encountered a bump in the road and then began to shake violently. My husband immediately let off the gas and pulled to the side of the road but the truck continued to violently shake until it reached about 45mph. On the same day while driving down the interstate the truck encountered another bump in the road and did the same thing. My husband could not stop or control the truck from shaking. We were lucky there were not many other vehicles around us or it could have caused an accident. The truck only has 18,000 miles on it.

NHTSA ID

11463969

Incident

May 6, 2022

The contact owns a 2019 Ford F-250. The contact stated that while driving at 62 MPH, the front end of the vehicle inadvertently started shaking violently. The contact stated that the vehicle continued to shake increasingly, causing him to almost lose control of the steering wheel. There were no warning lights illuminated. The contact immediately depressed the brake pedal and veered to the side of the road. The contact stated that he exited the vehicle and looked around but could not determine the cause of the failure. The contact notified the dealer of the failure and scheduled an appointment for diagnostic testing. The contact referenced NHTSA Campaign Number: 20V576000 (Power Train). The manufacturer was not notified of the failure. The vehicle was not diagnosed or repaired. The approximate failure mileage was 14,000.

NHTSA ID

11445288

Incident

Sep 15, 2021

Mileage

14,000 mi

The contact owns a 2019 Ford F-250. The contact became aware of NHTSA Campaign Number: 20V576000 (Power Train) however, the dealer informed the contact that the parts for the recall repair were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue and advised the contact that they were working on getting the parts shipped to the dealer. The contact had not experienced a failure. VIN tool confirms parts are not available.

NHTSA ID

11440695

Incident

Nov 16, 2021

The contact owns a 2019 Ford F-250. The contact stated that while driving approximately 65 mph over a bump, the vehicle started to shake violently. The contact stated the vehicle went into "death wobble" without warning The driver had to pull over for the vehicle to work as designed. The vehicle was taken to the local dealer but was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 3,000.

NHTSA ID

11436388

Incident

Apr 1, 2021

Mileage

3,000 mi

I cant drive truck over 50mph it shakes the whole truck i looked it up its called the death wobble. I almost lost control today and wrecked with my whole family in the car.

NHTSA ID

11436243

Incident

Oct 10, 2021