2019 Ford F-250 Sd Problems

Experienced the oft reported death wobble while driving home from TN and had to limp my vehicle home while experiencing the constant, extreme and dangerous wobbling.

The contact owns a 2019 Ford F-250. The contact stated that while cleaning the steering wheel, the steering column became loose. No warning light was illuminated. An Independent mechanic was contacted. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 127,000.

Experienced the oft reported death wobble while driving home from TN and had to limp my vehicle home while experiencing the constant, extreme and dangerous wobbling.

While driving at highway speeds, I drove over an expansion joint on a bridge and experienced violent shaking of the vehicle. This included violent shaking of the steering wheel and interior of the truck. I also slowed down to under 30 mph on the highway to stop the shaking. This occurred several other times and, upon researching, found it to be called a "death wobble". I brought my truck to a Ford dealership service center and mentioned the death wobble, which was immediately acknowledged. This cost $1758 out of pocket to fix. From research I have done, it seems all suspension components should not need any type of repair or replacement prior to reaching 50,000 miles, with some components lasting as much as 100,000 miles.

Experienced the oft reported death wobble while driving home from TN and had to limp my vehicle home while experiencing the constant, extreme and dangerous wobbling.

The contact owns a 2019 Ford F-250. The contact purchased four aftermarket steel rims for the vehicle. The vehicle was taken to have the rims balanced, and the contact was advised by the technician that the steel rims were not rated for a 3/4-ton vehicle. The contact stated that the seller's website had listed the rims as compatible for a 3/4-ton vehicle. The contact returned the rims to the seller; however, the contact felt that the seller should have correctly identified the wheels for the correct vehicle weight, because the vehicle was used to haul trailers.

Ford Motor Company Has Decided to Cancel/Pause Customer Satisfaction Campaign 22M03 without Reason or Notice Given to Customers at this Time after being Told By Service Advisor Ron Fultz #3689 at Anderson Ford 3601 Stockton Hill Rd Kingman, AZ 86409....That the effected Cameras as well as the Recall for the Rear Tailgate camera 22S51 would be Preformed....To no Avail as was told at the end of the Service Visit Could not Preform the Needed Side and Front Face Camera upgrade as Per Canceled/Paused with no Timeframe Given and Lied to as the Scope of Service to be done upon Scheduled Appointment for all to Addressed

The rear view backup camera will get scrambled or become blurry from time to time . It is happening more frequently causing the inability to know what is behind you when backing up.

While driving the truck completely just shutdown and then would not start.

Original Fuel pump stated intermittent long cracks about 35,000 miles. And continues to do so. It seems like FORD uses the all time favorite “ we cannot recreate the issue” in order to send the customer on their way and not take ANY responsibility whatsoever ,WOW! Its rediculous that they don’t want to acknowledge the issue after thousands of customers complain. Our whole family has been riding in this vehicle when the truck experienced the truck lag and turn off at highway speeds. Does someone have to be hurt or killed by this for this company to finally own up? I hope none does!!! Make it right FORD!!! Yet they changes and updated the newer trucks pumps after this, why? REDICULOUS

At around 139,000 miles i started to noticed some intermittent noise coming from the drivetrain. I took it to two different repair shops and was told it was tire noise. over time the grinding noise increased to the point of shuddering and jerking while shifting with no warning lamps showing. At 144,500 miles I contacted my aftermarket warranty and they said to take it to a certified shop to get it checked out. They did not have any preferred shops in my area so I took it to US Automotive. At 145,000 miles the shop contacted the warranty company and proceeded with investigation of the issue. After inspection and tear down they confirmed the transmission had the typical failure for the 10R80 10-speed automatic transmissions. They turned over there findings and the warranty company which has agreed to the findings and has offered a replacement used transmission with 125,000 miles on it and will also not cover the full cost to install the used unit. I feel that this is fraud and outside of the warranty agreement. I am now paying the expense to put the original transmission back into the truck to try to take it the 2.5 hours back to the dealership which sold me the truck along with the warranty to see what they will do in the matter. I hope it doesn't fail on the highway on the way.

My truck transmission changes gears randomly while in motion. It is terrifying when it happens in traffic and the truck stalls and looses power then kicks back in with a loud noise. I stopped driving it since March of 2026.

The rear view camera is not working when placing the vehicle in reverse. The dash screen is blank even though it changes to appropriate display mode. The area where camera image is supposed to be to display is blank.

The contact owns a 2019 Ford F-250. The contact stated that the passenger’s side headlight bulb was blown, and the battery was not operating as needed. The vehicle was taken to the dealer and the headlight bulb was replaced; however, the bulb failed to illuminate. The vehicle was returned to the dealer two more times and the headlight bulb was replaced; however, the failure persisted. The vehicle was taken to another certified mechanic and the headlight bulbs were replaced. Additionally, the contact stated that the vehicle intermittently failed to start. The check engine warning light was illuminated. The dealer was contacted and advised the contact to replace the battery and filters. The contact replaced the battery and filters; however, the failure persisted. The vehicle was taken to the dealer, who diagnosed that there were metal shavings inside the fuel. The filters were replaced; however, the failure persisted. The dealer informed the contact that a defective fuel pump had caused the failure and the fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 190,000.

The back window shattered after turning on the rear window defroster. This put back seat occupants in harm. It impaired my vision. There were no warnings to this failure. My insurance company has been notified. Independent auto repair & glass repair shops have inspected the damage. Window must be replaced.

The contact owns a 2019 Ford F-250. The contact stated that while driving at various speeds, all doors independently locked, and the front headlights independently illuminated. The contact stated that the Brake warning light was illuminated. In addition, the contact disconnected the battery and lowered the windows to open the doors from outside as a temporary fix; however, the key was only able to unlock the front driver’s side door. The vehicle was taken to a local independent mechanic, where it was diagnosed with water intrusion in the BCM (Body Control Module). The local dealer was contacted. The vehicle was not diagnosed or repaired due to the cost. The manufacturer was made aware of the failure. The failure mileage was approximately 75,000.

The contact owns a 2019 Ford F-250. While driving at approximately 20 MPH, there was an abnormal sound coming from underneath the vehicle, and the check engine warning light illuminated. The vehicle was taken to a dealer to be diagnosed; however, the dealer stated that the cause of the abnormal sound and the illuminated check engine warning light was unknown. The contact was notified of an unknown recall; however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to have the VIN added to the recall. The failure mileage was approximately 205,000.

After sitting for extended durations the engine experiences a no start or long crank condition. Research and discussion with local mechanic indicate this is an issue with a failed/failing fuel pump and/or fuel pump module. It is my understanding a recall exists for similar failures on other ford models.

The contact owns a 2019 Ford F-250. The contact stated that while driving over a pothole, the vehicle started shaking, and the steering wheel was uncontrollable. The contact stated that after it rained, the driver's side and passenger's side doors were filled with water. Additionally, the interior lights failed to turn on as needed. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 98,000.

The contact owns a 2019 Ford F-250. The contact stated that while driving at an undisclosed speed, the taillights failed to operate properly, and the radio stopped working. An unknown warning light illuminated on the instrument panel. The contact also stated that the headlights remained illuminated after the vehicle was turned off, and the doors failed to lock. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and advised the contact to call the NHTSA Hotline to report the failure. The failure mileage was approximately 3.

Ford Diesel 250 flat out stalled while driving on a very congested Highway. Full tank of Diesel. No warning. Complete stall at 65MPH, no brakes, no power steering, no lights. Was almost killed when the truck almost crashed into a bus. Happened (4) more times as we made our way back home. Internet search shows that Ford Motor Company is fully aware of this common failure of their fuel system. Federal regulators need to pressure Ford for a Recall before someone is killed

The contact owns a 2019 Ford F-250. The contact stated that upon inspection it was discovered that water was present inside the rear high mount stop light assembly. The vehicle was taken to the local dealer who diagnosed that the assembly needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was concerned that the water intrusion might cause internal corrosion to some electrical components. The failure mileage was 22,250.

The contact owns a 2019 Ford F-250. The contact stated that while driving approximately 65 MPH on a cross-country move, the rear windshield was loose and was shaking inside the frame. The contact stated the rear glass remained attached and hanging within the frame. The vehicle was taken to a dealer to be diagnosed. The dealer replaced the rear window frame and window bracket, and the vehicle was repaired. The manufacturer was notified of the failure but offered no assistance. The failure mileage was approximately 80,000.

There was no accident, I am experiencing the same issue with my Ford Super Duty that was in a recall 22S51 but my VIN was not included in the recall. The back up camera on my truck is so cloudy you can barely see, Ford states they will not take of this as well as the dealership I bought the truck from.

The contact owns a 2019 Ford F-250. The contact stated that while driving approximately 45 MPH and after driving over a bump in the road, the vehicle experienced a "Death Wobble" causing the driver to lose control of the steering and crash into a garbage truck. During the crash, the front end of the vehicle was severely damaged but the air bag did not deploy. The driver sustained a head injury and later received medical treatment which revealed multiple strokes had occurred during the crash. A police report was taken at the scene and the vehicle was towed away. The cause of the failure was not determined. The local dealer and manufacturer were notified of the failure. The contact indicated that prior to the crash the steering arm had been replaced on three separate occasions. The failure mileage was 25,000.

The contact owns a 2019 Ford F-250. The contact stated that while driving at 70 MPH, the trailer hitch bolt lock that connected a trailer to a nearby truck detached and crashed into his vehicle's front bumpers. The air bags failed to deploy. An unknown warning light illuminated. The contact decelerated but continued to drive the vehicle. The contact did not sustain any injuries. A police report was not filed. The vehicle was taken to the dealer but was not diagnosed for the air bags failure. The manufacturer was notified of the failure and referred the contact to NHTSA for assistance. The vehicle was not diagnosed or repaired. The approximate failure mileage was 25,000.

The contact owns a 2019 Ford F-250 equipped with Cooper Tires, Tire Line: Discoverer AT3, Tire Size: 295/60/R20, DOT Number: (N/A). The contact stated that while driving 60 MPH and hauling a trailer, the vehicle jolted into oncoming traffic and started wobbling. The contact regained control of the vehicle and eventually steered to the side of the road and parked the vehicle. The contact became aware of a flat spot on the tire, and the spare tire was placed on the driver’s side front. The contact continued driving, and the wobbling became controllable at speeds under 50 MPH. The vehicle was taken to the residence, where the contact observed that the driver's side front tire had tire separation in the middle of the tire. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The tire failure mileage was 37,000. The vehicle failure mileage was 52,000.

Tire size LT285/75 R18 Component/System Failure: The front suspension and steering damper malfunctioned, leading to the "death wobble." This issue also caused excessive tire wear due to the violent vibrations and instability in the steering system. The components are available for inspection, and the worn tires and replaced parts can be provided if necessary. Safety Risk: The excessive tire wear, combined with the loss of steering control due to the wobble, significantly increased the risk of a blowout or loss of traction. At highway speeds, this made it difficult to control the vehicle, posing a serious risk to myself and others on the road. Problem Reproduced/Confirmed: Yes, the problem, including excessive tire wear and steering instability, was reproduced and confirmed by a Ford dealership service center during their inspection. Vehicle/Component Inspection: The vehicle was inspected by the Ford dealership, where they identified the steering and suspension issues that contributed to the wobble and tire wear. No other entities, such as insurance or police, have inspected the vehicle since no accidents occurred. Warning Lamps/Symptoms: There were no warning lamps or messages before the failure. However, prior to the issue, symptoms included rapid and uneven tire wear, increased steering vibrations, and vehicle instability, particularly after hitting bumps or potholes.

The contact owns a 2019 Ford F-250. The contact stated that the passenger’s side headlight bulb was blown, and the battery was not operating as needed. The vehicle was taken to the dealer and the headlight bulb was replaced; however, the bulb failed to illuminate. The vehicle was returned to the dealer two more times and the headlight bulb was replaced; however, the failure persisted. The vehicle was taken to another certified mechanic and the headlight bulbs were replaced. Additionally, the contact stated that the vehicle intermittently failed to start. The check engine warning light was illuminated. The dealer was contacted and advised the contact to replace the battery and filters. The contact replaced the battery and filters; however, the failure persisted. The vehicle was taken to the dealer, who diagnosed that there were metal shavings inside the fuel. The filters were replaced; however, the failure persisted. The dealer informed the contact that a defective fuel pump had caused the failure and the fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 190,000.

The housing for the headlights have started to delaminate from the inside of the housing and starting to create a problem with the effective lighting and turn signal area. Where the delaminating is occurring, the lens has a milky , etched, , water spot film like appearance clearly on the inside of the housing. Since it first appeared , it has grown in size on both headlamps and appears that it will continue to grow over time. I first noticed this several months ago and reported it to the Ford dealer. After a lot of back and forth , and much to my dismay Ford is refusing to cover this under its top tier extended warranty even though it is a safety issue . It would have been covered under the initial 3/36 bumper to bumper . Ford has officially stated that it’s not a common problem, though it’s pretty easy to find quite a few others with the same issue from browsing Ford Internet forums.

The contact owns a 2019 Ford F-250. The contact stated that while driving at an undisclosed speed, the transmission imploded while shifting into first gear with the powertrain warning light illuminated. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 89,000.

The contact owns a 2019 Ford F-250. The contact stated while driving 60 MPH and attempting to accelerate, the vehicle failed to respond as needed. The vehicle was turned off and restarted. The contact stated that on another occasion the vehicle hesitated while accelerating and then operated normally. The contact stated that a scanner retrieved fault code: P0762 (Shift Solenoid Failure). The vehicle was taken to the dealer however, the mechanic found no fault with the vehicle. The manufacturer was not contacted. The failure mileage was 7,135.

The contact owns a 2019 Ford F-250. The contact stated while driving 40–45 MPH, the front passenger’s side seat started to smoke. The driver was able to pull over. The contact noticed that the heated seat module was melting at the wiring harness. The contact stated that the wiring harness was burned at the plug. The P/N: GU5T-14B663-AA. The TPMS, low-windshield fluid, and oil change warning lights were illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and informed the contact that the repairs was at his expense. The failure mileage was approximately 93,000.

THERE IS A PROBLEM WITH THE SEAT BELTS STAYING LATCHED AND THEY WILL NOT HOLD THE CAR SEATS IN PLACE, I HAVE 2 SMALL GRANDCHILDREN THAT RIDES IN MY VEHICLE AND IT'S NOT SAFE FOR THEM TO BE IN MY VEHICLE UNDER THESE CONDITIONS. THIS OCCURED BEFORE THE VEHICLE IS IN MOTION AND CONTINUES WHEN THE VEHICLE IS MOVING.