2000 Ford Ford Truck

WHILE DRIVING THE EXCURSION AT A SPEED AROUND 35 MPH, HEARD A VERY LOAD POP NOISE FROM UNDER THE HOOD AND LOST POWER FROM THE ENGINE AND THE VEHICLE ROLLED TO A STOP. HAD THE VEHICLE TOWED TO MY LOCAL FORD DEALERSHIP FOR TROUBLE SHOOTING PURPOSE. THEY TOLD ME THE NUMBER 7 SPARK PLUG BLEW OUT FROM THE HEAD. THE FIX WAS EITHER A HELI-COIL OR A NEW HEAD. THE HELICOIL COST WAS 900 DOLLARS AND THE HEAD WAS 4500 DOLLARS. READING THIS SITE AND MANY MORE THERE IS A SERIOUS ISSUE WITH A WIDE VARIETY OF SIZES FROM FORD MOTORS WITH THE SPARK PLUG BLOWING OUT. I DON'T KNOW WHAT IT WILL TAKE FOR A RECALL FOR THIS PROBLEM BUT SOMETHING NEEDS TO BE DONE. I GUESSNOTHING GETS DONE UNTIL SOMEBODY IS KILLED. *TR

NHTSA ID

10375497

Incident

Dec 18, 2010

Mileage

54,365 mi

2000 FORD WINDSTAR SEL -THE ACTIVE CONTROL LIGHT GOES ON SLIGHT BUMPS OR ROUGH ON HIGHWAYS-GOES OFF, BUT RECENTLY AFTER THE REAR AXLE RECALL AND CHECK OF BY DEALERSHIP ON OCT 4, 2010, OUR CAR HAS ON MORE THAN THREE OR FOUR TIMES WENT INTO THE ACTION CONTROL MODE WHEN THE LIGHT ON DASH WENT ON --AND THIS AT HIGH INTERSTATE OR PARKWAY SPEEDS OF 65 MPH, AND ON DRY SURFACES---IT HAS , I GUESS, BECAUSE OF DRY-NON SLIP CONDITIONS CAUSED DIFFICULTY IN MAINTAINING CONTROL OF VEHICLE. ON SECONDARY SLOWER SPEED HIGHWAYS ONLY THE LIGHT HAS GONE ON --NO REAL NOTICE OF ENGAGING OF ACTIVE CONTROL ACTION, SO TO SPEAK. WE HAVE REPORTED ALL THIS TO OUR DEALERSHIP AND FORD CUSTOMER RELATIONS. ALSO TAKE NOTE THAT AT AROUND 10-19-09 WHEN CAR AT 112,468 MILES OUR DEALERSHIP REPLACED A REAR RIGHT SPEED SENSOR AT PRICE OF $149.19 --ON THAT OCCASION FOR THE REPORT BY US OF ACTIVE CONTROL LIGHT GOING ON AND STAYING ON. THAT WAS NOT AS NOW -AS THE VEHICLE NEVER WENT INTO THE ACTIVE CONTROL ACTION THAT DOING NOW AT AROUND THE MILES OF 114,980. THIS VEHICLE HAS BEEN GARAGE KEPT AND ALL SERVICE RECORDS KEPT-FIRST BY THE OWNER I PURCHASED FROM AND NOW BY US ON OUR HOME PAGE FORD SERVICE RECORDS ACCOUNT. *TR

NHTSA ID

10362961

Incident

Oct 20, 2010

Mileage

114,895 mi

OUR RV SEEMED SLUGGISH ON GOING UP ON HILLS, THEN SUDDEN ENGINE FAILURE WHILE GOING UPHILL ON HWY 77 IN WV. TOWED TO A LARGE AAA REPAIR CENTRE, WHERE THEY LOOKED INTO SOME SPARK PLUGS AND PULLED 5 OUT, ONE OF WHICH WAS SO BADLY DAMAGED, FLATTENED WITH TWISTED THREADS, THEY DETERMINED IT NEEDS A NEW ENGINE. HAD IT TOWED AGAIN DEC. 26 TO AN AUTHORIZED FORD DEALER. THEY INSPECTED THE ENGINE AND FOUND A HOLE IN ONE OF THE PISTONS. REPAIR WOULD BE NEW ENGINE ASSEBLY. NOT ONE THAT HAS SEEN THE SPARK PLUG AND KNOW THE MILES (29,500) ON THIS RV BELIEVE THAT THIS COULD OR SHOULD HAPPEN. IT NEEDS TO BE TOWED AGAIN TO A CAPABLE REPAIR SHOP, WHICH SEEMS TO BE EXTREMELY HARD TO FIND. FORDS MOTOR COMPANY ANSWER IS THAT WARRANTY TIME IS OVER, FIX IT AND PAY FOR IT. APPRX. ESTIMATES ARE $6000.00 - 7000.00. THIS JUST HAPPENING BEFORE CHRISTMAS INVOLVES SO MANY PERSONAL HARDSHIPS, INCLUDING 19 HOUR BUS TRIP GOING NORTH, CANCELLATIONS OF SO MANY RESERVATIONS, INCLUDING AIRLINE TICKETS. THIS IS FAR FROM BEING OVER, AND THE REPAIR COSTS ARE UNBELIEVABLE AND WE ARE NOT READY FOR AND WE HAVE NO IDEA WHERE IT IS GOING TO BE REPAIRED. EVERYONE SEEMS TO THINK THAT IT MUST BE AN ORIGINAL MANUFACTURING DEFECT THAT THERE IS NO OTHER ANSWER TO HAVE A HOLE IN AT LEAST ONE PISTON AND HAVE THAT LOSE METAL PIECE SOMEWHERE IN THE ENGINE MAYBE CAUSING MORE DAMAGE IF THE WHOLE ENGINE IS NOT CHANGED. WE ARE HELPLESS AND FAR AWAY FROM OUR RV. *TR

NHTSA ID

10213180

Incident

Dec 22, 2007

Mileage

29,500 mi

2000 FORD EXCURSION LIGHT SWITCH TO HEADLIGHT BROKE. *NM

NHTSA ID

10152903

Incident

Mar 1, 2006

CLOCK AND RADIO 'READ OUT-NUMBER' JUST QUIT WORKING - FAIL TO LIGHT UP. MILEAGE READ OUT COMES ON AND OFF AS IT PLEASES, DOES NOT WORK CONSISTENTLY. THE RADIO BUTTONS ARE STARTING TO NOT COME ON WHEN YOU START THE CAR AND DO NOT STAY ON - 2005.*JB

NHTSA ID

10140303

Incident

Jan 1, 2003

I OWN A 2000 FORD EXCURSION (4 WHEEL DRIVE). ON THREE OCCASIONS THE CRUISE CONTROL HAS GONE ON AUTOMATICALLY CAUSING THE VEHICLE TO ACCELERATE. DURING THE MOST RECENT EVENT MY WIFE ALMOST HIT ANOTHER VEHICLE. I WILL CONTACT THE DEALERSHIP FIRST THING MONDAY MORNING, BUT THOUGHT YOU SHOULD HAVE THIS INFO ON THE VEHICLE. *NM

NHTSA ID

10132757

Incident

Aug 14, 2005

Mileage

73,500 mi

I WAS DRIVING OUR FORD EXPEDITION AND I STOPPED AT A LIGHT. WHEN THE LIGHT TURNED GREEN I BEGAN TO ACCELERATE AND I HEARD A POP FROM THE ENGINE. THE TRUCK IMMEDIATELY BEGAN TO RIDE VERY ROUGHLY, AND WE SMELLED GAS AS WE PULL THE TRUCK TO THE SIDE OF THE ROAD.

NHTSA ID

10118147

Incident

Apr 9, 2005

Mileage

81,900 mi

WE RECENTLY PURCHASED A 2000 FORD EXC. LTD. AND NOW THE DRIVER SIDE DOOR LOCK WILL NOT LOCK OR UNLOCK HALF THE TIME WHEN WE USE THE REMOTE, EVEN WHEN IN THE VEHICLE WE PUSH THE LOCK BUTTON AND WE STILL HAVE TO MANUALLY PUSH THE ACTUAL LOCK DOWN. WE HAVE FRIENDS THAT PURCH. THE SAME TYPE OF VEHICLE AND YEAR, THEY ALSO HAD THE SAME PROBLEM.ALSO WE HAVE A COMB. LOCK ON THE OUTSIDE AND WE HAVE NO WAY OF BEING ABLE TO GET THE MANUF. CODE SO WE CAN ACCESS THAT IN CASE OUR KEYS GET LOCKED IN THE VEHICLE, THE DEALERSHIP DID NOT HAVE UT AND WE CANNOT FIND IT ANYWHERE.*AK

NHTSA ID

10114044

Incident

Feb 28, 2005

Mileage

69,000 mi

SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY MAY EXHIBIT A WHINE ABOVE 35 MPH. *TT

INFORMATION ON REVISED CLUTCH DISC FOR 7.3L M6 SUPER DUTY TRUCKS. *TT