2005 Ford Freestyle

On November 29, 2012, Ford Motor Company (Ford) initiated Customer Satisfaction Program 12N03 to extend warranty coverage terms for repair of engine idle RPM surge caused by throttle body deposits in all model year (MY) 2005 through 2007 Ford Freestyle, Five Hundred and Mercury Montego vehicles.The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle (all vehicles are eligible for the program through May 31, 2013, regardless of mileage).Dealers will repair vehicles exhibiting the condition by removing and cleaning the throttle body and reprogramming the PCM with software containing an updated idle speed control strategy.According to Ford, some of the affected vehicles may experience momentary, intermittent engine idle RPM surge (idle flare) when stopped or during low speed driving maneuvers such as in a parking lot or driveway.Unstable idle speed control (dips and flares) around the target engine speed (700 rpm) can occur in vehicles with deposit build-up in the throttle body when the system adjusts engine speed in response to changes in engine load, typically from power steering application or air-conditioner compressor cycling.Idle speed control logic is only active at vehicle speeds below 3.5 mph and when the accelerator pedal is not applied.Ford testing of a vehicle with a worst case throttle body measured a maximum idle flare of 1360 RPM lasting approximately 1 second, which Ford indicated was consistent with system design to limit vehicle speed and acceleration in idle control mode.Ford indicated that the test vehicle was held in place with normal brake effort and that vehicle speed remained under 4 mph without the brake pedal applied.In addition to throttle body deposit accumulation, symptoms associated with the condition may include Check Engine lamp illumination and diagnostic trouble codes (DTCs) P0505, P0506 or P061B.Ford attributed the surge condition to changes in idle air flow resulting from the progressive buildup of deposits in the throttle body from normal Positive Crankcase Ventilation (PCV) system operation.This condition was not adequately compensated for in the original Powertrain Control Module (PCM) calibration.Ford issued a technical service bulletin on August 15, 2011 (TSB 11-8-5), releasing an updated powertrain control calibration for vehicles with CVT transmissions.On October 19, 2011, Ford issued a second bulletin (TSB 11-10-21) superseding TSB 11-8-5 and including updated powertrain control calibration for vehicles with 6-speed transmissions.Prior to Ford issuing the TSB?s, owner?s experiencing the alleged defect either received no repairs, if dealers could not duplicate the condition, or had the throttle body cleaned or replaced, which only provided temporary correction until the throttle deposit build-up returned.Ford?s revised powertrain calibrations appear to be effective remedies for the idle instability caused by build-up of throttle body deposits.However, even after the TSB?s were released, many owners experiencing the condition continued to have difficulty with proper diagnosis and repair as dealers were often either unable to duplicate the condition or were unfamiliar with the new repair procedures.Ford's new program addresses those concerns.NHTSA's testing and complaint analysis indicate that the idle speed control issue in the subject vehicles can only occur at very low speeds, are very brief events, are easily controlled by moderate brake pedal forces and result in minor increases in vehicle speed even with no braking.This investigation is closed.The closing of this in

THE SUBJECT VEHICLES EXPERIENCE A LOSS OF PROPER INSTRUMENT CLUSTER OPERATION.TYPICALLY, THE PROBLEM APPEARS AS THE NEEDLE ON THE GAUGE (SPEEDOMETER, TACHOMETER, FUEL, AND/OR TEMPERATURE) SWEEPS AND RESETS INTERMITTENTLY.FORD REPORTS THE PROBLEM AS MOMENTARY POWER INTERRUPTION CAUSES THE GAUGES TO SWEEP AND THEN RECOVER TO NORMAL FUNCTION.IN AUGUST 2006, FORD ISSUED A TECHNICAL SERVICE BULLETIN (TSB 06-17-9) TO PROVIDE GUIDELINES TO SERVICE TECHNICIANS FOR DIAGNOSIS AND REPAIR OF THIS CONDITION.ODI'S REVIEW OF FORD'S RESPONSE TO THE AGENCY'S INFORMATIONREQUEST LETTER REVEALS THAT THE MAJORITY OF THE REPORTS TO FORD (63%) INDICATE THAT THE INSTRUMENT CLUSTER WOULD EXPERIENCE INTERMITTENT LOSS OF POWER.FORD REPORTS THAT THISLASTS FOR ONLY A FEW SECONDS.ALSO FORD STATES, THE VEHICLE'S EXTERIOR LIGHTING WOULD NOT FAIL TO ILLUMINATE EVEN IN THE EVENT OF POWER INTERRUPTION TO THE CLUSTER BECAUSE THE EXTERIOR LIGHTS ARE POWERED SEPARATELY AND DO NOT RELY ON ANY SIGNAL FROM THE CLUSTER.ADDITIONALLY, ODI CONTACTED COMPLAINANTS WHO AFFIRMED THE INTERMITTENT CONDITION AND THAT NONE OF THE EXTERIOR LIGHTS ON THE SUBJECT VEHICLES WOULD BE AFFECTED BY POWER INTERRUPTIONS TO THE INSTRUMENT CLUSTER.ODI LAST RECEIVED A REPORT REGARDING THIS ISSUE IN AUGUST OF 2007.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.ODI WILL HOWEVER CONTINUE TO MONITOR THE ISSUE AND WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

Our 2005 Ford Freestyle often accelerates or surges forward on its own when applying the brake or parking. It is a very dangerous malfunction that looks to be a wide spread problem for this make and model (based on online reports).

NHTSA ID

11747522

Incident

Jun 30, 2026

When temperature get below freezing car doors will not latch shut and come back open. Car doors work fine when temp are higher. There is a recall already for this NHTSA# 06v383000 Ford# 06545. I have a Ford Case# XXX My car was not included in recall and either should be or needs to be further investigated. I don't want my kids falling out while I go down the highway and I can't wait 45 min for the car to warm up. This had done this all last winter and is doing it again and Ford refuses to do anything. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11704107

Incident

Dec 3, 2025

The contact owns a 2005 Ford Freestyle. The contact received notification of NHTSA Campaign Number: 06V383000 (Latches/Locks/Linkages); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds, the front driver's side door independently unlatched and opened. The local dealer was contacted and informed the contact that the parts for the repair were no longer manufactured. The vehicle was not repaired. The manufacturer was notified of the failure, a case was filed, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 97,000.

NHTSA ID

11696759

Incident

Oct 15, 2023

Mileage

97,000 mi

PASSANGER DOOR LATCH- DOOR OPENED WHILE DRIVING, WILL NOT STAY CLOSED CHECKED SAID RECALL WAS REPAIRED IN 2006, LATCH IN NOT CLOSING

NHTSA ID

11637411

Incident

Jan 21, 2025

The contact owns a 2005 Ford Freestyle. The contact stated that all four door latches failed to latch while attempting to close the doors. The contact had to make several attempts to close and lock the doors before the doors latch and remained closed. The failure had reoccurred intermittently. The contact learned of NHTSA Campaign Number: 06V383000 (Latches/Locks/Linkages) but was unsure if the VIN was included. The dealer was contacted and confirmed that the VIN was not included in the recall The vehicle had not been diagnosed or repaired. The manufacturer was made aware of the failure and confirmed that the VIN was not included in the recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 150,000.

NHTSA ID

11629170

Incident

Nov 29, 2024

Mileage

150,000 mi

The contact owns a 2005 Ford Freestyle. The contact stated that the vehicle was taken to an independent mechanic for routine maintenance however, the contact was informed that the motor mount torque strap needed to be replaced. The contact had not taken the vehicle to a local dealer to be diagnosed or repaired. The contact stated that the motor mounts had been replaced four times. The vehicle was repaired. The contact stated there was no warning light illuminated. The manufacturer was informed of the failure. The failure mileage was approximately 170,000.

NHTSA ID

11610391

Incident

Jul 23, 2024

Mileage

170,000 mi

The contact owns a 2005 Ford Freestyle. The contact stated that while at a stop, the vehicle lunged forward. While starting the vehicle, the vehicle revved high. While driving at high speeds, the vehicle decelerated. The contact stated that several times, the vehicle failed to accelerate as needed. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who cleaned and replaced the throttle body. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 160,000.

NHTSA ID

11569427

Incident

Sep 1, 2023

Mileage

160,000 mi

Doors will not close in cold weather. This is a safety issue that was not resolved with prior recall.

NHTSA ID

11557112

Incident

Nov 27, 2023

Motorcraft® Continuously Variable Chain-Type Transmission Fluid (XT-7-QCFT in non-Canadian markets, CXT-7-LCF12 in Canada) is no longer manufactured and will only be available until inventory depletes. The recommended replacement fluids are Phillips 66 VersaTrans® CVT Plus Fluid or Kendall VersaTrans® CVT Plus Fluid. Mixing Motorcraft® CVT fluid (blue-green color) with these replacement fluids (red color) in the same transmission is acceptable.

The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.

FORD: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. MOMENTARY ENGINE IDLE RPM SURGE MAY BE INTERMITTENT AND MAY OCCUR, DUE TO DEPOSITS BUILDUP IN THROTTLE BODY, AT LOW SPEEDS, WHILE PARKING OR ENTERING DRIVEWAY AND CHECK ENGINE LAMP MAY ILLUMINATE. MODELS 2005-07 FREESTYLE, 500, MONTEGO. *PE

FORD MERCURY SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. CERTAIN 2005 THROUGH 2007 FWD AND AWD FORD FIVE HUNDRED, FREESTYLE AND MERCURY MONTEGO VEHICLES - REAR BRAKE WEAR. ALSO HAVE AN OWNER'S LETTER. *NJ UPDATED 1/25/08. *NJ

MIL WITH DTC P0106 AND/OR P0109. *KB

BATTERY LIGHT ILLUMINATED. *KB