1997 GMC Sonoma

ON FEBRUARY 18, 2004, ODI OPENED THIS RECALL QUERY (RQ) BASED ON TWO FATALITY REPORTS INVOLVING MY 1997 GM S-10 PICKUP TRUCKS.EACH REPORT ALLEGED THAT THE BELTED DRIVER OCCUPANT WAS EJECTED IN A MULTIPLE-ROTATION ROLLOVER CRASH.THE MY 1997 S/T SERIES PICKUPS USE AN ENERGY-ABSORBING LOOP IN THE DRIVER SEAT BELT THAT ALLOWS THE WEBBING TO ELONGATE UP TO 10 INCHES (TO MITIGATE DRIVER INJURY IN FRONTAL CRASHES).GM ALSO USED THIS ENERGY-ABSORBING LOOP SEAT BELT DESIGN IN MY1997 S/T SERIES UTILITY VEHICLES (CHEVROLET BLAZER, GMC JIMMY AND OLDSMOBILE BRAVADA).GM CONDUCTED A SAFETY RECALL CAMPAIGN (03V-117) TO REPLACE THE DRIVER SEAT BELT IN THESE UTILITY VEHILCES BASED ON A HIGHER FATALITY RATE OF EJECTED BELTED DRIVERS IN ROLLOVER CRASHES.BOTH FATAL CRASHES ARE SEVERE ROLLOVER CRASHES (MULTIPLE-ROTATION ROLLOVER) AND BOTH VEHICLES SUSTAINED DAMAGE TO THE ROOF STRUCTURE.ODI REVIEWED THE FIELD DATA PERFORMANCE OF THE SUBJECT VEHICLES AND COMPARED THEM TO PEER VEHICLES USING NHTSA'S FATALITY ANALYSIS REPORTING SYSTEM (FARS) DATABASE.THE FARS DATA DID NOT INDICATE A FIELD PERFORMANCE TREND FOR THE SUBJECT VEHICLE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.

APPROX ONE MILE FROM HOME AS I WAS APPROACHING A STOP SIGN ENGINE SUDDENLY SHUT OFF. AFTER A FEW SECONDS MANAGED TO RESTART ENGINE. ENGINE SHUT DOWN TWICE MORE BEFORE ARRIVING BACK HOME. AT HOME WAS UNABLE TO RESTART ENGINE HAD VEHICLE TOWED TO GMC/BUICK DEALERSHIP. DEALERSHIP FOUND THAT PROBLEM WAS DEFECTIVE IGNITION SWITCH ASSEMBLY. REPLACED IGNITION SWITCH AT A COST OF $600.23, I WAS INFORMED VEHICLE WAS NOT ON CURRENT RECALL LIST. IF NOT, WHY NOT. THANK GOD I WAS NOT ON INTERSTATE WITH A 16 WHEELER BEHIND ME. I CONTACTED GMC CUSTOMER ASSISTANCE REQUESTED TO BE REIMBURSED FOR ABOVE COST. REQUEST DENIED BECAUSE VEHICLE NOT ON RECALL LIST. I ALSO HAVE A 2004 CADILLAC WHICH IS ON RECALL LIST FOR IGNITION SWITCH NEVER RECEIVED RECALL LETTER UNTIL I COMPLAINED AT ABOVE CUSTOMER SERVICE THEY DID SEND ME RECALL LETTER CONCERNING CADILLAC. UNABLE TO HAVE SWITCH REPAIRED BECAUSE CADILLAC DEALER CANNOT GET PARTS. *TR

NHTSA ID

10626728

Incident

Jul 28, 2014

Mileage

60,985 mi

TL* THE CONTACT OWNS A 1997 GMC SONOMA. WHILE DRIVING 25 MPH ON A STEEP HILL, THE VEHICLE STALLED. THE DEALER REPLACED THE IGNITION SWITCH. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 73,000. UPDATED 10/02/14*LJ UPDATED 3/6/2015*JS

NHTSA ID

10621500

Incident

Jul 31, 2014

Mileage

73,000 mi

I HAD A 97 GMC SONOMA THAT I WAS GOING DOWN A DIRT ROAD ABOUT 30-35 MPH AND SWERVED TO MISS A TRUCK COMING ON MY SIDE OF THE ROAD AND LOST TRACTION AND FLIPPED OVER A HILL AND ROLLED 3 TIMES AND THE AIRBAGS DIDNT DEPLOY AND THE DRIVERS SEATBELT SNAPPED . *TR

NHTSA ID

10485988

Incident

Aug 14, 2012

Mileage

100,150 mi

TL* THE CONTACT OWNS A 1997 GMC SONOMA. WHILE DRIVING APPROXIMATELY 35 MPH, THE DRIVER HEARD A LOUD POPPING SOUND COMING FROM THE FRONT END OF THE VEHICLE. THE DRIVER INSPECTED THE VEHICLE AND NOTICED THAT THE FRONT AND REAR FRAME WAS CRACKED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 145,261.

NHTSA ID

10473919

Incident

Sep 4, 2012

Mileage

145,261 mi

UNABLE TO STOP DUE TO BRAKE PEDAL GOING ALL THE WAY TO THE FLOOR! BRAKE PEDAL AND ACCELERATOR PEDAL ARE POSITIONED TOO CLOSE, AND WHEN BRAKE PEDAL IS ALL THE WAY DOWN, FOOT COMES IN CONTACT WITH ACCELERATOR PEDAL, MAKING IT IMPOSSIBLE TO STOP! THIS IS APPARENTLY A COMMON PROBLEM WITH THESE GMC PICKUPS, AS I HAD THE SAME PROBLEM WITH A 1991 GMC SONOMA. IN THIS CASE, I COULD HAVE AVOIDED A COLLISION, BUT COULD NOT STOP, EVEN THOUGH I HAD APPLIED THE BRAKES WITH PLENTY OF FORCE. GM SHOULD BE HELD RESPONSIBLE FOR THIS MAJOR DEFECT, WHICH WAS NOT CORRECTED FROM AT LEAST 1991 THROUGH 1997 -- AND PROBABLY BEYOND! *JS

NHTSA ID

10455314

Incident

Apr 4, 2012

Mileage

99,950 mi

VEHICLE THROTTLE STICKS AT 1500RPM AND WILL STICK ABOVE 1500RPM IF DOWNSHIFTED OR INCREASING SPEED. THE ONLY WAY TO LOWER THE RPM TO IDLE IS SHIFT TO NEUTRAL A N D COME TO A COMPLETE STOP -- FIRMLY HOLDING BRAKE TO MAXIMUM DEPRESSION AND THEN ONLY AFTER A FEW SECOND DELAY. UPON ENTERING ANY GEAR [AUTOMATIC XMSN] THE RPM WILL AGAIN GO TO 1500, BUT IF BRAKE PEDAL REMAINS DEPRESSED FOR ABOUT 10SEC THE RPM WILL GO BACK TO IDLE. ANY SLICK ROADS OR MOUNTAIN/STEEP DOWNHILL DRIVING IS EXTREMELY HAZARDOUS! CHECK ENGINE STAYS ON AND COMPUTER READING CALLS FOR REPLACEMENT OF A SENSOR WHICH HAS BEEN REPLACED 3 TIMES. THE DIRECTIONS SAY TO LET THE NEW SENSOR "BREAK IN" BY IDLING FOR 20 MINUTES MINIMUM PRIOR TO DRIVING. IT DOES NOT WORK! THIS IS A FAULTY DESIGN WHEREIN A SENSOR OR COMPONENT MALFUNCTION RESULTS IN THROTTLE BOOST BEYOND OPERATOR CONTROL AND IS OFTEN AT RPM'S ABOVE 2500 !!! THE MALFUNCTION IS PERMANENT AND THE INCIDENT OCCURS EVERY DAY THE VEHICLE IS DRIVEN !!! *TR

NHTSA ID

10374650

Incident

Nov 17, 2010

Mileage

156,000 mi

I HAVE ENCOUNTERED TROUBLE WITH MY WINDSHIELD WIPERS. THEY GO ON AND OFF INTERMITTENTLY. I AM ASSUMING THE PROBLEM IS THE PULSE WIPER RELAY, AND WAS WONDERING IF THERE WAS A RECALL FOR THIS PRODUCT. I WAS DRIVING IN HEAVY RAIN WHEN THIS OCCURRED, AND THERE WAS NEARLY A COLLISION. PLEASE LET ME KNOW IF THERE ARE ANY RECALLS FOR THIS PART. THANK YOU. *TR

NHTSA ID

10250196

Incident

Oct 15, 2008

Mileage

100,000 mi

THE KEY USED TO STICK IN THE IGNITION AND RELEASE ITSELF AFTER A SHORT TIME. THEN THE KEY WOULD NOT RELEASE, AND WHEN THE KEY CAME OUT THE VEHICLE COULD STILL BE STARTED, THEN THE STEERING WHEEL LOCKED AND THE KEY CAME OUT, BUT WHEN PLACED BACK IN, WOULD NOT UNLOCK THE STEERING WHEEL NOR WOULD IT TURN THE IGNITION CYLINDER. *TR

NHTSA ID

10248043

Incident

Nov 7, 2008

Mileage

101,256 mi

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.  E version update is to add administrative details.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.