2011 GMC Terrain

On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745

On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.

On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.

No warning before headlights gave up

NHTSA ID

11741914

Incident

Jun 3, 2026

We have 2011 GMC Terrain. We bought it used so we have only had it a couple years. We noticed it seemed to be using a little more oil but then we were told to keep watch on it. My husband did. Then one day while I was driving it I thought I had heard a faint clicking noise. I said that car isn’t going anywhere until it’s fixed. Little did we know it wouldn’t ever start again. We didn’t know about a so call recall or not a recall. Still until we had to have it towed in to be fixed, I heard it mentioned. By then the car was repaired at our expense of $8000+. We are retired and don’t have or didn’t have money for that repair. The only reason we had a little money was because my husband got paid for back (lump sum) payment just a couple of days before this. We still owe on the car. Without it we only have an old 2001GMC SIERRA 1500. We live paycheck to paycheck. I called one of GMC’s phone numbers today and I was told if we didn’t have it done at a GMC FACILITY we get NO reimbursement. I cried. My husband is a real stickler when it comes to our vehicles and maintenance and logs and also keeps receipts.Please tell me there is some to help us.

NHTSA ID

11688571

Incident

Aug 1, 2025

Odometer Fraud. The contact purchased a 2011 GMC Terrain. The contact discovered that there was a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 87,000, and at the time of registration, it was discovered that the mileage was 200,000.

NHTSA ID

11682188

Incident

Aug 21, 2025

Mileage

200,000 mi

The contact owns a 2011 GMC Terrain. The contact stated that the vehicle was consuming an excessive amount of engine oil. The contact stated that the vehicle was leaking engine oil. The check engine warning light was illuminated while driving at undisclosed speeds. The vehicle was taken to a local dealer who confirmed there was no warranty or recall coverage on the vehicle for the failure. The vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic who determined that the engine might be blown. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 110,714.

NHTSA ID

11676206

Incident

Jan 1, 2024

Mileage

110,714 mi

The contact owns a 2011 GMC Terrain. The contact stated while driving 25 MPH and depressing the accelerator pedal, the vehicle failed to respond as intended. The contact pulled over to the right side of the roadway and waited for towing assistance. The contact stated that an independent mechanic was contacted. The vehicle was towed to an independent mechanic and two separate auto body shops, where it was diagnosed and determined that the engine was consuming engine oil, and the engine needed to be replaced. The contact stated that the second time the vehicle was driven to the independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 114,114.

NHTSA ID

11669797

Incident

Jun 18, 2025

Mileage

114,114 mi

SUV gets a slow down warning and it stops shuts off , it’s happened several times now I’m scared!!you wait few minutes it turns back on , mechanic said this a complain about this vehicle all the time , it has not been repaired I’m disabled with no money , I was on the highway and thank God I was on the slow lane if not I would have been killed by an eighteen wheeler. GMC is waiting for someone to die and probably address this issue

NHTSA ID

11605745

Incident

Jul 25, 2024

Two of the valves failed and the dealership told me it was likely due to a manufacturer’s defect.

NHTSA ID

11574922

Incident

Aug 1, 2023

Engine Failure: Timing chain had excessive slack causing guide to be sheared off. Timing chain guide bolt was completely stripped requiring both the timing chain and cylinder head to be replaced. Safety: The vehicle stalled while driving Problem: Problem was confirmed by a dealer Warnings: The check engine light came on as the vehicle stalled

NHTSA ID

11571561

Incident

Aug 12, 2019

This document provides the technician with a diagnostic tip if the vehicle stalls and set diagnostic trouble code P0191 and may also set P0172. The diagnostic tip has the technician inspect the high pressure fuel pump body markings to confirm it is an original manufacture part. If it is not an original manufacture part, they should install one and evaluate the vehicle.

This preliminary information communicates information about how to determine if a wheel and tires size change is available.

This Preliminary information communicates the steps on how to save a GDS2 Session Log and upload to a Technical Assistance Case in CX Connect.

This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.

This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.

This Preliminary Information communication provides information to the technician about vehicles that have had multiple repair attempts that are being performed on customer’s vehicles that exhibit vibration conditions without utilizing the support of General Motors Technical Assistance Center. If valid vibration frequency or Road Force Variation data has been collected and a repair attempt does not correct the customer complaint, contact General Motors Technical Assistance Center for further support. For any vehicles that remains unrepaired after being at the dealer for three days or more and a related bulletin or PI is not found, contact General Motors Technical Assistance Center for further support.