1999 Mercury Sable

ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.

A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.

I BOUGHT A USED 1999 MERCURY SABLE GS WITH THE U TYPE 3.0L V6 ENGINE 2 MONTHS AGO. JUST RECENTLY I NOTICED THE CAR WANTING TO LUNGE FORWARD WHILE HOLDING THE BRAKE AT STOPS. THEN A FEW DAYS LATER WHENEVER I START THE CAR IT LUNGES FORWARD. NOTHING DRAMATIC BUT DEFINITELY NOTICEABLE. I STARTED LOOKING ONLINE TO SEE ABOUT A RECALL AND 1 WAS PRESENT A LONG TIME AGO. IS IT TO LATE TO GET MY CAR CHECKED OR HOW TO SEE IF IT WAS EVER SERVICED OR CALLED FOR THE RECALL.

NHTSA ID

11383277

Incident

Nov 30, 2020

Mileage

152,000 mi

WHILE DRIVING THE STEERING WHEEL BECAME LOOSE AND MADE IT VERY HARD TO STEER ALMOST CAUSING ME TO HAVE A ACCIDENT AFTER COMING TO A STOP THE STEERING WHEEL WAS OFF CENTER AND VERY HARD TO TURN HAD TO GET CAR TOWED.I FIND THIS TO BE A COMPLETE RIP OFF BECAUSE I SEE NUMEROUS COMPLAINTS OF STEERING PROBLEMS OF THE SAME MATTER

NHTSA ID

11289660

Incident

Dec 16, 2019

Mileage

149,000 mi

TL* THE CONTACT OWNS A 1999 MERCURY SABLE WAGON. WHILE DRIVING 40 MPH, THE STEERING WHEEL BECAME LOOSE AND WAS UNABLE TO CONTROL THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT WAS ABLE TO DEPRESS THE BRAKE PEDAL TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND THEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE RACK AND PINION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 149,000. THE VIN WAS NOT AVAILABLE.

NHTSA ID

11289653

Incident

Dec 16, 2019

Mileage

149,000 mi

REAR SUBFRAME CONNECTION PASSENGER SIDE RUSTED THROUGH DUE TO FACTORY PUT AIR CONDITIONER CONDENSATE LINE SO THAT IT CONSTANTLY DUMPS CONDENSATE ON THIS AREA INSTEAD OF DRAINING CONDENSATE BEYOND AND TO THE GROUND. THE RESULT IS A RUSTED OUT SEVERED CONNECTION THEREBY CAUSING THE ENGINE AND TRANSMISSION TO BE HELD BY ONLY THREE OF THE FOUR CONNECTIONS NEEDED TO SAFELY HOLD ENGINE AND TRANSMISSION AS DESIGNED FROM THE FACTORY.

NHTSA ID

10940302

Incident

Aug 3, 2016

Mileage

115,000 mi

TL* THE CONTACT OWNS A 1999 MERCURY SABLE. WHILE DRIVING VARIOUS SPEEDS, THE BRAKES HESITATED TO STOP THE VEHICLE. IN ADDITION, THE VEHICLE INDEPENDENTLY ACCELERATED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 155,000.

NHTSA ID

10881775

Incident

Jun 20, 2016

Mileage

155,000 mi

THE STEERING IS HORIBLE, ABOUT 3YEARS AGO CHANGED RACK APPION STEERING, AND JUST A WEEK AGO, PUT NEW STEERING PUMP ON, STILL.

NHTSA ID

10836880

Incident

Dec 28, 2015

EVEN AFTER REPLACING THE SECOND POWER STEERING PUMP , IT IS HORRIBLE TURNING THE STEERING WHEEL MOST OF THE TIME. ALSO, IT IS NOISY WHILE I'M DRIVING IT. IT HAD A NEW RACK AND PINION ON IT WHEN I BOUGHT IT . PARKING IN A PARKING LOT IS AWFUL AS IT IS ALMOST IMPOSSIBLE TO MANEUVER AROUND OTHER CARS. TURNING CORNERS ,SOMETIMES IT'S OKAY AND OTHER TIMES REALLY HARD. NOT SURE IF THIS COMPLAINT BELONGS HERE, BUT HEATER DOESN'T WORK ,EITHER. FEELS LIKE A/C IS ON . HAD A FRIEND CHECK IT AND HE IS HAVING A HARD TIME FIGURING IT OUT. DON'T KNOW HOW TO ANSWER "DATE HAPPENED" AS IT HAS BEEN DOING THIS SINCE I BOUGHT IT IN AUGUST.

NHTSA ID

10806809

Incident

Aug 1, 2015

AFTER RAINS THE CAR GOT A WET FLOOR ON THE PASSENGER SIDE ,NO WET SPOTS ON ROOF OR WINDOWS. IT WAS LEAKING WATER FROM THE DASH BOARD COMPARTMENT BOTTOM.WHILE DRIVING ,THE HEATER WAS ON AND IT STARTED SMOKING FROM UNDER THE DASHBOARD COMPARTMENT BY PASSENGER SIDE I TURNED EVERYTHING OFF . I TOOK IT FOR REPAIR AND NOW, ON MAY IT RAINED HEAVY AGAIN AND IT HAS A PUDDLE IN THE PASSENGER SIDE AGAIN ,SAME SITUATION AS BEFORE, WATER CAME FROM INSIDE.IS THIS A SAFETY HAZARD? I BOUGHT THIS CAR ON NOVEMBER 2013 ,AND I KNEW TOO LATE ABOUT THE HEATING SYSTEM RECALL ,I DON'T KNOW IF IT WAS EVER REPAIRED ON THAT RECALL.FORD DEALER IN COLORADO SAYS THERE IS NO WAY TO CHECK IT.ACCORDING TO SOME WEBSITES IT NEEDS SOMETHING TO HAVE A PROTECTION UNDER THE WIPERS VENTS(COWL) AND IT IS A FACTORY MISTAKE. I HAVE HAD THE HEATING SYSTEM REPAIRED 2 TIMES,TOO EXPENSIVE FOR ME.I AM UNDER EMPLOYED. I WANT TO KNOW IF THIS IS A SAFETY HAZARD. IT IS THE ONLY WAY I COULD MAKE FORD TO FIX THIS RECALLED IF THE CAR WAS NEVER FIXED FOR THIS BEFORE.THANKS FOR YOUR HELP. *TR

NHTSA ID

10587324

Incident

Dec 9, 2013

Mileage

65,988 mi

Safety recall 04S17 - Front coil springs - requests for recall service action

For 1999-2001 Taurus or Sable vehicles Safety Recall 04S17 has been issued for vehicles that are operated in high corrosion areas for an extended period, where the front coil springs could potentially fracture. A fractured front coil spring could move past the spring seat and contact a front tire. If a front coil spring should fracture and come in contact with a tire, the tire may rupture resulting in rapid air loss, which could increase the risk of a crash without warning.

MERCURY/FORD: SAFETY RECALL REGARDING FRONT COIL SPRINGS CAN FRACTURE ON VEHICLES OPERATING FOR EXTENDED PERIODS IN HIGH CORROSION AREAS. MODEL 1999-01 TAURUS, SABLE. *PE

MERCURY/FORD: FRONT COIL SPRINGS CAN FRACTURE, AFTER OPERATING, FOR AN EXTENDED PERIOD OF TIME, IN HIGH CORROSION AREAS, MOVE MOVE PAST SPRING SEAT AND CONTACT RUPTURE FRONT TIRE, RESULTING RAPID AIR LOSS. MODEL 1999-2001 TAURUS, SABLE. *PE

SURGE, IDLE ROLL, ROUGH IDLE ONLY WHEN THE ENGINE COOLING FANS ARE OPERATING. *TT

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT