1999 Buick Regal

BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.

EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

07/25/2021 STARTED THE MOTOR, IN STATIONARY IN PERSONAL DRIVEWAY, IN IDLE IT BEGAN TO PUFF THICK WHITE SMOKE FROM THE TAIL PIPE AND EXHAUST MANIFOLD IN THE ENGINE COMPARTMENT. TURNED ENGINE OFF WITHIN 15 SECONDS OF STARTING THE ENGINE. LEFT VEHICLE OFF FOR 24 HRS, AND TRIED TO TURN THE MOTOR BACK ON AND THE ENGINE SEIZED AND WOULD NOT CRANK OVER. TRIED 3-5 ADDITIONAL TIMES TO START ENGINE, WITH THE SAME OUTCOME. SINCE THIS OCCURENCE VEHICLE HAS BEEN LEFT UNDRIVEABLE AND STILL REMAINS IN PERSONAL DRIVEWAY. RECALL NUMBER: 240412

NHTSA ID

11387360

Incident

Jul 25, 2020

Mileage

86,000 mi

WEIRD ENGINE NOISE , WHEN SWITCHING THE IGNITION SWITCH SOMETIMES DELAY, ALSO DASH LIGHTS AND HEADLIGHTS ALSO AC DOESN'T WORK AND LOW OIL , LOW AIR , AND LOW COOLANT LIGHTS TURN ON EVEN IF ALL OF THEM ARE FULL AT THE RIGHT LEVEL .

NHTSA ID

11289542

Incident

Oct 21, 2019

PASSENGER AIR BAG LIGHT STAYS ON ALL THE TIME. TAKATA INFLATORS

NHTSA ID

11172607

Incident

Jan 27, 2019

Mileage

120,000 mi

AUGUST 2017', THE STEERING BEGAN TO PULL VERY SLIGHTLY LEFT AND RIGHT AT ALL SPEEDS BUT MORE NOTICEABLE AT LOW SPEEDS OR WHEN TURNING THE WHEELS AT A STOP WITH A VERY SLIGHT CLUNK NOISE THAT GOT LOUDER OVER THE YEAR. VISIBLE INSPECTION AT MY REPAIR SHOP DURING A FLAT REAR TIRE REPAIR DID NOT FIND ANYTHING WORN OUT OR DAMAGED BUT SUGGESTED MAYBE A BALL JOINT COULD BE GETTING OLD ENOUGH TO NEED REPLACED AS IT DID HAVE ABOUT 158,000 OR SO MILES ON IT BUT THEY COULDN'T INDICATE IF IT WAS A BALL JOINT SPECIFICALLY AS THERE WAS NO UNUSUAL MOVEMENT OR NOISE FROM ONE. I ALSO CHECKED AND FOUND NO ISSUES WITH ANY COMPONENT UNDERNEATH. NO LEAKS AND POWER STEERING FLUID WAS GOOD.THEN SEPTEMBER 7, 2018', WHILE DRIVING AROUND TOWN THE STEERING MADE A LOUD CLUNK STEERING LEFT AND REALLY BEGAN TO PULL ESPECIALLY LEFT. I GOT IT HOME 3 MILES LATER AND PUT IT ON RAMPS AND HAD SOMEONE WORK THE STEERING WHEEL BACK AND FORTH AND I FOUND THE CLUNK IS COMING FROM THE DRIVERS SIDE OF THE RACK AND PINION ASSEMBLY. YOU CAN LITERALLY SEE IT JUMP WHEN IT CLUNKS. AFTER THIS STATIONARY TEST THE STEERING WAS MUCH WORSE, THE CAR WAS NOT DRIVABLE F THE BLOCK WITH OUT HEAVY EFFORT ON THE STEERING WHEEL SO IT IS PARKED UNTIL IT CAN GET FIXED. COMPLAINT HISTORY FOR THIS ISSUE WITH GM VEHICLES IN THIS +/- 2 YEAR RANGE IS ALARMING.

NHTSA ID

11128826

Incident

Sep 7, 2018

Mileage

162,000 mi

TL* THE CONTACT OWNS A 1999 BUICK REGAL. WHILE ATTEMPTING TO PLACE THE GEAR SHIFTER IN DRIVE, THE VEHICLE JERKED AND BEGAN TO SHAKE. WHILE THE VEHICLE WAS ON AN INCLINE, IT FAILED TO PROPERLY ACCELERATE AND STARTED TO SHAKE. ALL OF THE WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO PENSKE CHEVROLET OF CERRITOS (18605 STUDEBAKER RD, CERRITOS, CA 90703 (562) 924-1676). BUT NO DIAGNOSTIC FAILURE CODES WERE FOUND AND THE FAILURE COULD NOT BE REPLICATED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO BOULEVARD BUICK GMC (2800 CHERRY AVE, SIGNAL HILL, CA 90755 (562) 492-1000) WHERE IT WAS DIAGNOSED THAT THE OIL NEEDED TO BE CHANGED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED A CASE NUMBER. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

NHTSA ID

11031897

Incident

Aug 15, 2015

Mileage

80,000 mi

TL* THE CONTACT OWNED A 1999 BUICK REGAL. AFTER DRIVING AND PARKING THE VEHICLE, SMOKE AND FLAMES APPEARED. THE VEHICLE WAS DESTROYED AND TOWED. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT DIAGNOSED BY A DEALER. THERE WAS A RECALL REGARDING THE FAILURE, BUT THE CONTACT RECEIVED THE NOTIFICATION TOO LATE. THE RECALL INFORMATION AND FAILURE MILEAGE WERE UNKNOWN.

NHTSA ID

10957664

Incident

Jan 1, 2012

THE ENGINE CAUGHT ON FIRE NO MORE THAN 3MINUTES AFTER I PARKED THE CAR. THE VALVE COVER RECALL WAS REPAIRED IN 2016. CAR WAS RUNNING FINE. I JUST HAPPENED TO GO BACK OUT TO THE CAR TO GET MY CELL PHONE WHEN I SAW SMOKE. I OPEN THE HOOD AND SAW FLAMES. I USED A FIRE EXTINGUISHER TO OUT HE FLAME OUT. NOW THE CAR STARTS BUT RUNS TOO ROUGH TO EVEN TRUST TO DRIVE IT! WHY HAVE THE RECALL IF IT WAS GOING TO CATCH FIRE ANYWAYS!

NHTSA ID

10953933

Incident

Jan 10, 2017

ON 10/28/2016 MY WIFE HAD DROVE THE CAR ABOUT 3 MILES TO THE STORE DID SOME SHOPPING FOR APPROXIMATELY 30 MINUTES. SHE RETURNED HOME THE 3 MILES PARKED THE CAR IN THE DRIVEWAY IN FRONT OF THE GARAGE AND WENT IN SIDE. SHE WAS IN THE GARAGE A FEW MINUTES LATER AND SAW SMOKE FILLING THE GARAGE. SHE WENT OUT THE BACK DOOR AND AROUND THE HOUSE AND THE CAR WAS IN FLAMES. NEIGHBORS HAD ALL READY CALLED 911. IT TOOK ABOUT TEN MINUTES FOR THE FIRE DEPARTMENT TO ARRIVE. THE ENTIRE ENGINE BAY AND FRONT OF THE CAR WAS DESTROYED. THE PAINT WAS BURNED OFF OF THE GARAGE DOOR AND BLISTERED PAINT AND SOOT ON THE HOUSE. THE HOOD STRUT EXPLODED AND PUT A HOLE IN THE GARAGE DOOR.

NHTSA ID

10920124

Incident

Oct 28, 2016

Mileage

100,000 mi

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.  E version update is to add administrative details.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.